Installation Instructions

ManualsBrandsToro ManualsRiding ProductsFlashing Beacon Kit, LT-F3000 Heavy-Duty Triple Turf Flail Mower

FormNo.3404-154RevA

FlashingBeaconKit

LT-F3000Heavy-DutyTripleTurfFlailMower

ModelNo.02920—SerialNo.316000001andUp

InstallationInstructions

PreparingtheMachine

1.Parkthemachineonalevelsurface,settheparking

brake,shutofftheengine,removethekeyfromthe

ignitionswitch,andapplythecutting-unittransport

latches.

2.Opentheenginecover.

3.Disconnectthebatteryasfollows:

WARNING

CALIFORNIA

Proposition65Warning

Batteryposts,terminals,andrelated

accessoriescontainleadandleadcompounds,

chemicalsknowntotheStateofCalifornia

tocausecancerandreproductiveharm.

Washhandsafterhandling.

A.Disconnectthenegative(black)groundcable

fromthenegative(-)batterypost.

WARNING

Incorrectbatterycableroutingcould

damagethemachineandcables,causing

sparks.Sparkscancausethebatterygases

toexplode,resultinginpersonalinjury.

•Alwaysdisconnectthenegative(black)

batterycablebeforedisconnectingthe

positive(red)cable.

•Alwaysconnectthepositive(red)

batterycablebeforeconnectingthe

negative(black)cable.

WARNING

Batteryterminalsormetaltoolscould

shortagainstmetalmachinecomponents,

causingsparks.Sparkscancausethe

batterygasestoexplode,resultingin

personalinjury.

•Whendisconnectingorconnecting

thebattery,donotallowthebattery

terminalstotouchanymetalpartsof

themachine.

•Donotallowmetaltoolstoshort

betweenthebatteryterminalsand

metalpartsofthemachine.

B.Disconnectthepositive(red)cablefromthe

positive(+)batterypost.

4.Removethebulkheadtoenableaccesstothemain

wiringloombyremovingthe4screws.

InstallingtheKit

InstallingtheBrackets

1.EnsurethattheROPSpivotboltsandclampboltsare

inplaceandtight.

2.OnthesamesideoftheROPSonwhichyouplanto

installthekit,removethenut,bolt,andwasherfrom

theROPSanddiscardthenutandbolt;refertoFigure

Note:Retainthewasher.

8111LyndaleAvenueSouth

Bloomington,MN55420

Registeratwww.Toro.com.

OriginalInstructions(EN)

PrintedintheUK

AllRightsReserved

*3404-154*A

Summary of content (8 pages)

PAGE 1
Form No. 3404-154 Rev A Flashing Beacon Kit LT-F3000 Heavy-Duty Triple Turf Flail Mower Model No. 02920—Serial No. 316000001 and Up Installation Instructions WARNING Preparing the Machine Battery terminals or metal tools could short against metal machine components, causing sparks. Sparks can cause the battery gases to explode, resulting in personal injury. 1.
PAGE 2
Figure 1 1. Bolt (discard) 3. Washer (retain) 2. Lanyard washer 4. Locknut (discard) 3. Align the hole in the ROPS bracket with the hole in the ROPS and install the new bolt with the existing washer (Figure 2). Figure 3 1. Beacon bracket 3. Small washer (4) 2. Small bolt (2) 4. Small locknut (2) Installing the Beacon 1. Install the beacon stand to the beacon bracket (Figure 4). Note: Rotate the cable as you screw in the connector. This prevents the cable from being twisted. Figure 2 1.
PAGE 3
2. To fit the beacon cable, start by removing the fitting in the top of the beacon stand and feed the beacon cable through the bottom and out through the top. 3. Connect the beacon cable, ensuring that the red connector is fitted to the central positive terminal of the beacon stand fitting, and the black connector to the outer terminal. Screw the fitting back into the beacon stand. 4. Loosen the wing nut on the beacon (Figure 5). Figure 7 Figure 5 1. Wing nut 7.
PAGE 4
Important: Always use a fuse of the same type and amperage as the one you are replacing; otherwise, you could damage the electrical system. Figure 10 1. Fuse block 2. Cover Figure 9 1. Switch Completing the Installation 1. Install the bulkhead. 2. Apply the serial label adjacent to the machine serial label. 3. Install the positive (red) battery cable to the positive (+) battery terminal. 4. Install the negative (black) ground cable to the negative (-) battery terminal. 5.
PAGE 5
Notes: 5
PAGE 6
Notes: 6
PAGE 7
International Distributor List Distributor: Agrolanc Kft Asian American Industrial (AAI) B-Ray Corporation Brisa Goods LLC Casco Sales Company Ceres S.A. CSSC Turf Equipment (pvt) Ltd. Cyril Johnston & Co. Cyril Johnston & Co. Fat Dragon Femco S.A. FIVEMANS New-Tech Co., Ltd ForGarder OU G.Y.K. Company Ltd. Geomechaniki of Athens Golf international Turizm Hako Ground and Garden Hako Ground and Garden Hayter Limited (U.K.) Hydroturf Int. Co Dubai Hydroturf Egypt LLC Irrimac Irrigation Products Int'l Pvt Ltd.
PAGE 8
The Toro Warranty A Limited Warranty Conditions and Products Covered The Toro® Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly warrant your Toro Commercial product (“Product”) to be free from defects in materials or workmanship for two years or 1500 operational hours*, whichever occurs first. This warranty is applicable to all products with the exception of Aerators (refer to separate warranty statements for these products).