OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 LISTE DES RENVOIS ATA 23-11-02 Fabricant P/N Date d'édition originale: 2000/02/15 Date d'édition révision 2000/02/15
KVJEVR718 F0057 OPERATION AND INSTALLATION MANUAL Enhanced VHF Radio VHF Communications Transceiver PN : FIRST ISSUE: 2000/02/15 Ref/Doc : 36710392-AA REVISION No.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 SERVICE INFORMATION LETTER LIST SERVICE INFORMATION LETTER No 1 INCLUDED IN REVISION DATE OF INCORPORATION - - Not applicable for P/Ns : EVR716-11-0300A and EVR71611-0350A. 2 First Issue 2000/02/15 To upgrade the current Transmitter (TX), Receiver (RX), and HIRF boards to industrial level a re-layout of the printed circuit.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 LIST OF EFFECTIVE PAGES SUBJECT PAGE DATE Title Page 1 2 2000/02/15 Blank Record of Revisions 1 2 2000/02/15 Blank Record of Temporary Revisions 1 2 2000/02/15 Blank Service Bulletin List 1 2 2000/02/15 Blank Service Information Letter List 1 2 2000/02/15 Blank List of Effective Pages 1 2 2000/02/15 Blank Table of Contents 1 2 2000/02/15 Blank List of Illustrations 1 2 2000/02/15 Blank Introduction 1 2 3 4 200
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 RECORD OF REVISIONS REV. ISSUE No. DATE INSERTED DATE REV. ISSUE No.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 RECORD OF TEMPORARY REVISIONS TEMPORARY REV Nr PAGE NUMBER ISSUE DATE BY 23-11-02 DATE REMOVED BY RTR Page 1/2 2000/02/15
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 SERVICE BULLETIN LIST SERVICE BULLETIN NUMBER R E V INCLUDED IN REVISION DATE OF INCORPORATION 23-11-02 TITLE SBL Page 1/2 2000/02/15
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 TABLE OF CONTENTS SUBJECT PAGE INTRODUCTION ........................................................................................................................ INTRO-1 1. General.................................................................................................................................INTRO-1 2. Uncommon Abbreviations /Acronyms..................................................................................
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 LIST OF ILLUSTRATIONS FIGURE PAGE 10-1 - GENERAL VIEW ........................................................................................................10-2 10-2 - INTERFACE BLOCK DIAGRAM ...............................................................................10-2 10-3 - MECHANICAL CHARACTERISTICS ........................................................................10-5 10-4 - MECHANICAL CHARACTERISTICS .........
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 INTRODUCTION 1. General This Operation and Installation Manual includes information related to the operation and installation of the THOMSON-CSF COMMUNICATIONS EVR716 Enhanced VHF Radio Communications Transceiver. The Operation and Installation instructions are presented in the following sections: Introduction. 10 - System Description. 20 - External Interfaces. 30 - Installation. 40 - Operating Instruction.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 2.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 ABBREVIATIONS/ ACRONYMS IDENTIFICATION UHF Ultra High Frequency VAC Voltage Alternative Current VDC Voltage Direct Current VHF Very High Frequency VHFCP VHF Control Panel EVR Enhanced VHF Radio 23-11-02 Introduction Page 3/4 2000/02/15
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 SYSTEM DESCRIPTION 1. Function and Composition The Radio communication airborne system (see figure 10-1), known as the EVR716, is a VHF transceiver operating in the aeronautical band (118 MHz to 137 MHz), used by Air Transport Aircraft as a primary equipment for communications with the ground ATC infrastructure (in continental areas) or for communications between aircrafts (relay, emergency).
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 ARINC 600 connector Rear panel Test pushbutton Display LEDs Handle Attaching lug Interface General blockview diagram Figure 10-2 10-1 23-11-02 A0Z-MAA1 Page 10-2 2000/02/15
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 VHF Control Panel (VHFCP) Freq in Squelch Disable ARINC 2x 429 LS Automatic Test Equipment (ATE) OMS/CFDS ARINC 429 LS Serial Line POWER SUPPLY Discrets +27.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 2. − an ACARS MU (Management Unit, ARINC 724 or 724A) or a CMU (Communications Management Unit, ARINC 758), − an Audio Management Unit (AMU), audio control panel (microphone, loudspeakers), − a maintenance computer : OMS (ARINC 624) or CFDS (ARINC 604), − a VHF antenna. Mechanical Characteristics (see figures 10-3 and 10-4) DESIGNATION T/R Unit EVR716 3. DIMENSIONS (mm) 3 MCU to ARINC 600 ie 200 x 94 x 387.5 WEIGHT (kg) 4.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 NOTE: All dimensions are in mm.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 BOTTOM VIEW INTLET AREA 63,5 13 57,3 O3 RIGHT VIEW 2 30 0 0,5 3,6 92 +- 5 194-0,1 CENTRE OF GRAVITY 160 +- 5 318 +- 5 53,5 319,5 323 13 O3 NOTE : All dimensions are in mm. OUTLET AREA 52 TOP VIEW A0Z-MAA2 NOTE: All dimensions are in mm.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 EXTERNAL INTERFACES 1. Interwiring The inputs/outputs go through the ARINC 600 rear connector and the front panel.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 TOP PART OF THE CONNECTOR (continued) Pin number Signal name Type I/O To/From Serial bus O Management Module Serial bus I TP5B RS232 Transmission TP5C DC Ground TP5D RS232 Reception TP6A LED 1 Discrete O Management Module TP6B LED 2 Discrete O Management Module TP6C LED 3 Discrete O Management Module TP6D LED 4 Discrete O Management Module TP7A LED 5 Discrete O Management Module TP7B Reserved for
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 TOP PART OF THE CONNECTOR (continued) Pin number Signal name Type I/O TP9B Reserved TP10A BLOSQLT Discrete O TP10B CANOCT Discrete O TP10C COMP To/From MIDDLE PART OF THE CONNECTOR Pin number Signal name Type I/O MP1A Hi Mike Input I MP1B Lo Mike Input I MP1C PTT Mike Input Discrete I MP1D Key Event Discrete O MP2A Max TRANS Cut-off Discrete I MP2B Mike Input MP2C MP2D Data loader Input ARINC 42
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 MIDDLE PART OF THE CONNECTOR (continued) Pin number Signal name MP4C MP4D Data Loader Output MP5A Data Link Input HI Data Link Input LO MP5B Type I/O To/From ARINC 429 High Speed O Management Module I MP5C Reserved for 716 compatibility MP5D 8.33 kHz program for 716 compatibility Discrete Grounded for T/R with 8.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 MIDDLE PART OF THE CONNECTOR (continued) Pin number Signal name Type I/O Discrete I MP9B SDI Code Input MP9C Ground MP9D Reserved for AGC MP10A Reserved MP10B Interlocking Control input MP10C MP10D Data to both CMUs Output Port ARINC 429 High Speed O MP11A MP11B Data from ARCDU Port A ARINC 429 Low Speed I MP11C Reserved MP11D Data Select Discrete MP12A MP12B To/From O Management Module I Discrete I Data
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 MIDDLE PART OF THE CONNECTOR (continued) Pin number Signal name Type I/O To/From ARINC 429 Low Speed O Management Module O Receiver Module O Management Module MP14C MP14D CDS/ARCDU /SCP MP15A MP15B Audio/Sidetone output MP15C Muting Discrete MP15D Muting Return (Ground) Ground BOTTOM PART OF THE CONNECTOR Pin number Signal name Type I/O To/From Antenna / Receiver Module BP1 Antenna RF I/O BP2 Power input +
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 The links with the aircraft environment are distributed as follows: 2. − Antenna Input/Output via a coaxial insert located in the lower part of the rear connector. − Power supply inputs. − Discrete Inputs/Outputs. − Serial ARINC 429 link (four low speed inputs and one output, three high speed inputs and two outputs).
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 INSTALLATION 1. Environment The EVR716 transceiver is provided for the following environmental conditions: 2. − Operating temperature : - 40°C to + 70°C (- 40°F to + 158°F) − Storage temperature : - 55°C to + 85°C (- 67°F to + 185°F) − Ventilation : The EVR716 transceiver has an inlet air area on its bottom face and an outlet air area on its top face (see figure 10-4).
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 OPERATING INSTRUCTION 1. Energization of the Equipment The EVR716 transceiver is not provided with an "ON-OFF" switch. The EVR716 transceiver starts operating as soon as 28 VDC is applied to the connector of the EVR716 unit. 2. Normal Operating Modes The EVR716 transceiver is not provided with operating buttons. It operate via the aircraft controls. A. Operational State This is the EVR716 transceiver normal operating.
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 (2) Default Mode At power up, the default mode is mode 0A, tuned to the fast tuned frequency (before switching off). NOTE: In less than one second, the aircraft control provides the ARINC 429 word indicating the active frequency use. (3) Change of Mode Possible modes are ARINC 716 VOICE (0A or 0B modes) and ARINC 716 data (mode 1A).
OPERATION AND INSTALLATION MANUAL KVJEVR718 Enhanced VHF Radio EVR716 3. Default Operating Instructions The result of the tests activated either by power up or by the "TEST" pushbutton on the front panel, is displayed on six LEDs on the front panel (see figure 10-3).
