Security Datasheet
®
Safety data sheet
according to 1907/2006/EC, Article 31
Page 1/7
SECTION 1: Identication of the substance/mixture and of the
company/undertaking
SECTION 2: Hazards Identication
SDB-D100L_(EN)
Printing date: 01.03.2022 Version number 1 Revision: 19.06.2023
1.1 Product identier
Trade name DeoxIT® D-Series D100L (Part Nos. D100L-2C, D100L-2CP, D100L-B2C, D100L-CPK,
D100L-58D, D100L-2DB, D100L-12C, D100L-25C, D100P, D100L-P6C, D1W, D50W, D50FW,
D100W-3X3, D100FW-3X3, D100L-SWP10, D100L-2, D100L-8, D100L-12, D100L-13, D100L-13HPE,
D100L-16, D100L-32, D100L-8G, D100L-55G )
1.2 Relevant identied uses of the substance or mixture and uses advised against
No further relevant information available.
Application of the substance / the mixture: Cleaner, deoxidizer, protector for electrical contacts
& connectors
1.3 Details of the supplier of the safety data sheet
Manufacturer/Supplier:
Distributor:
Sonic Sales GmbH
Liebigstr. 24
33803 Steinhagen, Germany
Tel: +49 | 5204 / 9247734
email: pratheep.kumarasamy@sonic-sales.de
Manufacturer:
CAIG Laboratories, Inc.
12200 Thatcher Court, Poway, CA
92064-6876 USA
1.4 Emergency telephone number: CHEMTREC: +1(703)527-3887
2.1 Classication of the substance or mixture
Classication according to Regulation (EC) No 1272/2008
The substance is not classied, according to the CLP regulation.
2.2 Label elements
Labeling according to Regulation (EC) No 1272/2008
Void
Hazard pictograms Void
Signal word Void
Hazard statements Void
Information pertaining to particular dangers for man and environment
Electric Shock Hazard: The container and applicator conduct electricity. Keep away from live parts.
2.3 Other hazards
Results of PBT and vPvB assessment
PBT: Not applicable.
vPvB: Not applicable.
3.1 Chemical characterization: Substances
CAS No. Designation:
Preparation of substances listed below and non-dangerous materials.
4.1 Description of rst aid measures
General information No special measures required.
After inhalation Supply fresh air; consult doctor in case of symptoms.
After skin contact
On contact with skin clean with water and soap.
If skin irritation continues, consult a doctor.
After eye contact
Immediately rinse out eye with open eyelids for at least 15 minutes. Consult doctor afterwards.
Remove any contact lenses.
Use eye protection.
After swallowing
In case of persistent symptoms consult doctor.
4.2 Most important symptoms and eects, both acute and delayed
No further relevant information available.
4.3 Indication of any immediate medical attention and special treatment needed
No further relevant information available.
5.1 Extinguishing media
Suitable extinguishing agents
CO2, extinguishing powder or water jet. Fight larger res with water jet or alcohol-resistant foam.
5.2 Special hazards arising from the substance or mixture
Can be released in case of re
Carbon monoxide (CO)
Under certain re conditions, traces of other toxic gases cannot be excluded.
5.3 Advice for reghters
Protective equipment:
Fire ghters must wear self-contained breathing apparatus and full protective equipment.
Wear self-contained breathing apparatus.
Additional information
Dispose of re debris and contaminated re ghting water in accordance with ocial regulations.
Cool endangered containers with water spray jet.
Remove containers out of danger zone, if possible without risk.
6.1 Personal precautions, protective equipment and emergency procedures
Ensure adequate ventilation
Keep ignition sources away.
Use breathing protection against the eects of fumes/dust/aerosol.
6.2 Environmental precautions:
Do not allow product to reach sewage system or water bodies.
Dilute with much water.
6.3 Methods and material for containment and cleaning up:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
6.4 Reference to other sections
See Section 7 for information on safe handling
See Section 8 for information on personal protection equipment.
See Section 13 for information on disposal.
7.1 Precautions for safe handling.
Store in cool, dry place in tightly closed containers.
No special measures required.
Ensure good ventilation/exhaustion at the workplace.
Information about protection against explosions and res:
No special measures required
7.2 Conditions for safe storage, including any incompatibilities
Storage Requirements to be met by storerooms and containers:
Requirements to be met by storerooms and containers: Store in cool location.
Information about storage in one common storage facility: Not required.
Further information about storage conditions: None.
Storage class 3
7.3 Specic end use(s) No further relevant information available.
8.1 Control parameters
Additional information about design of technical systems: No further data; see item 7.
Components with critical values that require monitoring at the workplace: Not required
Additional information: The lists that were valid during the compilation were used as basis.
8.2 Exposure controls
Personal protective equipment
General protective and hygienic measures
Do not eat, drink or smoke while working.
Breathing equipment: Not necessary if room is well-ventilated.
Protection of hands: Not required
Material of gloves: Not relevant.
Eye protection: Not required.
Body protection: Not required.
9.1 Information on basic physical and chemical properties
General Information
Appearance:
Form: Fluid
Colour: Light red
Smell: Characteristic
Odor threshold: Not determined.
pH-value: Mixture is non-polar/aprotic.
Change in condition
Melting point/freezing point: Not determined
Initial boiling point and boiling range: 171-204 °C
Flash point
(DIN 51758; SETA CLOSED CUP): Not applicable.
Inammability (solid, gaseous) Not applicable.
Decomposition temperature: Not determined.
Self-inammability: Not determined.
Explosive properties: Product is not explosive.
Critical values for explosion:
Lower: Not determined.
Upper: Not determined.
Steam pressure: Not determined.
Density (DIN 51757) at 20 °C: 0.884 g/cm³
Relative density Not determined.
Vapor density Not determined.
Evaporation rate Not determined.
Solubility in / Miscibility with Water: Not miscible or dicult to mix
Partition coecient: n-octanol/water: Not determined.
Viscosity:
dynamic: Not determined.
kinematic at 20 °C: 10 mm²/s
9.2 Other information No further relevant information available.
10.1 Reactivity No further relevant information available.
10.2 Chemical stability
Thermal decomposition / conditions to be avoided:
No decomposition if used according to specications.
10.3 Possibility of hazardous reactions No dangerous reactions known
10.4 Conditions to avoid Keep ignition sources away.
10.5 Incompatible materials: Contact with strong oxidizing agents has to be avoided.
10.6 Hazardous decomposition products: No dangerous decomposition products known
11.1 Information on toxicological eects
Acute toxicity Based on available data, the classication criteria are not met.
Primary irritant eect:
Skin corrosion/irritation Based on available data, the classication criteria are not met.
Serious eye damage/irritation Based on available data, the classication criteria are not met.
Respiratory or skin sensitization Based on available data, the classication criteria are not met.
CMR eects (carcinogenity, mutagenicity and toxicity for reproduction)
Germ cell mutagenicity Based on available data, the classication criteria are not met.
Carcinogenicity Based on available data, the classication criteria are not met.
Reproductive toxicity Based on available data, the classication criteria are not met.
STOT-single exposure Based on available data, the classication criteria are not met.
STOT-repeated exposure Based on available data, the classication criteria are not met.
Aspiration hazard Based on available data, the classication criteria are not met.
12.1 Toxicity
Aquatic toxicity: No further relevant information available.
12.2 Persistence and degradability No further relevant information available.
12.3 Bioaccumulative potential No further relevant information available.
12.4 Mobility in soil No further relevant information available.
Additional ecological information:
AOX-indication: not relevant
According to recipe contains the following heavy metals and compounds according to EC
guideline NO. 76/464 EC: none
General notes:
Water hazard class 1 (Self-assessment): slightly hazardous for water.
Do not allow undiluted product or large quantities of it to reach ground water, water bodies or
sewage system.
12.5 Results of PBT and vPvB assessment
PBT: Not applicable.
vPvB: Not applicable.
12.6 Other adverse eects No further relevant information available.
13.1 Waste treatment methods
Recommendation
Smaller quantities can be disposed with household garbage
Uncleaned packagings:
Recommendation: Disposal must be made according to ocial regulations.
14.1 UN-Number
ADR, IMDG, IATA Void
14.2 UN proper shipping name
ADR, IMDG, IATA Void
14.3 Transport hazard class(es)
ADR, ADN, IMDG, IATA
Class Void
4.4 Packing group
ADR, IMDG, IATA Void
14.5 Environmental hazards: Not applicable
14.6 Special precautions for user Not applicable
14.7 Transport in bulk according to Annex II
of Marpol and the IBC Code Not applicable.
UN "Model Regulation": Void
15.1 Safety, health and environmental regulations/legislation specic for the substance or
mixture
Directive 2012/18/EU
Named dangerous substances - ANNEX I Substance is not listed.
National regulations
Information about limitation of use: none
Technical instructions (air):
Class Share in % not relevant
Water hazard class: Water hazard class 1 (Self-assessment): slightly hazardous for water.
International Listings 00-1
15.2 Chemical safety assessment: A Chemical Safety Assessment has not been carried out.
These data are based on our present knowledge. However, they shall not constitute a guarantee for
any specic product features and shall not establish a legally valid contractual relationship.
Abbreviations and acronyms:
ADR: Accord relatif au transport international des marchandises dangereuses par route (European
Agreement Concerning
the International Carriage of Dangerous Goods by Road)
IMDG: International Maritime Code for Dangerous Goods
IATA: International Air Transport Association
GHS: Globally Harmonised System of Classication and Labelling of Chemicals
CAS: Chemical Abstracts Service (division of the American Chemical Society)
MAL-Code: Måleteknisk Arbejdshygiejnisk Luftbehov (Regulation for the labeling concerning
inhalation hazards, Denmark)
PBT: Persistent, Bioaccumulative and Toxic
vPvB: very Persistent and very Bioaccumulative