Page 3
IMPORTANT SAFETY INSTRUCTIONS WARNING 1.Electrical grounding is required on all SteamSpa Generators. 2.All electrical supplies should be disconnected when servicing generators. 3.To reduce the risk of explosions, 4.To reduce the risk of injury, children under the age of 16 should not use the steam bath. 5. To reduce the risk of injury: A. The wet suffaces of steam enclosures may be slippery. Use care when entering or leaving. B. The steam head is hot.
IMPORTANT SAFETY INSTRUCTIONS 6.Be certain that steam bath enclosures are properly sealed to avoid water damage from escaping steam. It's recommended that 100% silicone caulk be used to seal all pipes and fittings. Steam must be prevented from escaping into the wall cavity. 7.Never shut off the water to a steam generator that is in use. 8.We recommend choosing steamers which are closely matched in power. The highest kW steamer should be the primary unit. Each steamer should have its own automatic drain. 9.
7 7 7 8 9 10 12 14 15 16 18 19 19 21 27 27 28 APP MANUAL FOR STEAM GENERATOR 31 39 40 41 42 43 Page 6
4. SteamSpa shall not be responsible for product damage or malfunction caused by self-installation or installation procedures which do not comply with user manual. 14. Always install generator in horizontally so that the water level sensor works normally.
Steam outlet Safety valve Water inlet Water drainage Fuse for wire power supply Controller wire and light wire hole Power wire hole Fuse for wire power supply Steam outlet Safety valve Water inlet Water drainage Fuse for wire power supply Power wire hole Controller wire and light wire hole Fuse for wire power supply Page 8
Steam outlet Safety valve Water inlet Water drainage Fuse for wire power supply Power wire hole Controller wire and light wire hole Fuse for wire power supply Ampere Meter Electricity Electricity Specifications for 1. Test the voltage of the power supply Type Power KW supply (1PH) current(A) power wire (AW G) and make sure suitable voltage is used B-450 4.5 240V 19 12 for the steam generator. 2. or local electricity consumption code B-600 6 240V 25 10 for the pecifications.
Page 10
Illustration 1.
INSTALLATION DRAWING OF DUAL STEAM GENERATORS Bluetooth Box Power supply cable for bluetooth box Control cable Control panel Steam Generator1 Adaptor Supply (Not provide) Pressure Relief Valve Steam Generator2 Dual Steam Outlet for 10.5kw 12kw Illustration 1.
6" 15 " Service clearance minmum Service clearance minmum Illustration 1.6.2 Illustration 1.6.
2. Use brass pipes or copper pipe only.Do not use black and galvanized or PVC pipes. Connect pressure reducing valve with pressure gauge, water filter, shut-off valve, flxe-hose between hot water or cold water pipes and generator. See page 10 illustration 1.2 and page 11 illustration1.4. ATTENTION! 1.The inlet water should not exceed 160F°. 2. The shut off valve should be installed in a place where it is easily accessible. 3.
Page 15
Supply Black Black Black Red Red Red Red Red Black White Red Red Red Red Black Black Red Terminal Block Yellow/Green Black To Control Panel Yellow Drain water valve Red Fill water valve Red Supply Water Level Senor Red(ShortPin) Black(LongPin) Yellow(MiddlePin) Black Red Red Red White Red Red Red Red Black Black Red Terminal Block Yellow/Green Black To Control Panel Yellow Drain water valve Red Fill water valve Black Water Level Senor Red(ShortPin) Black(LongPin) Yellow(Mid
Supply To Control Panel Red Red Red Red Red Red Red Red Red Black Red Supply To Control Panel Red Red Red Red Red Red Red Black Red Red Terminal Block Yellow/Green Black Black Black Black White Yellow Drain water valve Red Black Black Red Fill water valve Black Red Water Level Senor Red(ShortPin) Black(LongPin) Yellow(MiddlePin) Black Black Black Black Black Black White Yellow Red Drain water valve Fill water valve Black Red Terminal Block Yellow/Green Red Water Level
Page 18
Page 19
Page 20
REMARKS: The control panel comes with internal TEMP sensor, but external TEMP sensor is optional, when control panel is installed inside steam room,Internal TEMP sensor is ok. when control panel is installed outside steam room, external Page 21 TEMP sensor is necessary.
AROMA PUMP Page 22
Page 23
Page 24
Outside secondary On/Off Control Page 25
outside secondary On/Off control outside secondary On/Off control secondary control Page 26
Page 27
Page 28
9 Page 29
Page 30
APP MANUAL FOR STEAM GENERATOR With the addition of the WF50 WIFI box, the steam generator be controlled remotely via our APP on your mobile. Please note that you will need an existing wireless router. ATTENTION: WIFI box is compatible with SS-BCT01BK control panel only, APP instructions part is only for user who purchased the WiFi box. 1.DOWNLOAD APP ON MOBILE A. For Android phone, Scan QR to install APP. B.
2.USER REGISTRATION AND SIGN IN Click APP logo“Smart Life” to enter into login interface as picture shown, if it’s first time login, need to register new user account as guide. Register a new user account Click sign up if you have user account already 3.Adding your steam generator to the APP List On the first time use, you have to add your steam generator to the device list.
Operations are needed as follows before inputting the password and clicking the Next" button. 1. Power on the control panel and proceed steps as follows in the first 5 minutes. 2.Touch the icon to enter the setting interface as displayed in picture. 3. Move the arrow to “factory settings”. 4. Keep pressing button “OK” for 2seconds, you will hear a “ BEE” sound, the system is now in the WIFI matching state, you can see LED on WIFI box flashing.
4.OPERATION INTERFACE OF STEAM GENERATOR Exit the APP interface Change the title name Steam working time Steam TEMP.
5.FUNCTION A.Steam temperature Setting Scroll up or down to set steam TEMP and click“confirm” Steam function on, Click“Tempe_Set” Click steam button B.
C.Appointment Setting Scroll up or down to set steam working time. Click Monday to Sunday to set working mode Click“Confirm”to sure setting and quit the interface Click“Appointment” D.Chroma Light Open the steam and chroma light at same time, press relative color icon to set light color we want. When we choose the chroma light icon, light change color automatically.
E.Normal Light and Aroma Steam function on, click on the "light" button switch on/off the normal light. When steam function on, click aroma button to switch on/off the aroma function. F.Setting 1. Auto. clean function When steam function off, click the “Automatic wash” to start cleaning function. 2.Temperature unit switch Click temperature scale switch, the temperature unit can be switched between Celsius and Fahrenheit. 3.
H.Share device and remove device Click“Shared devices” Click to remove device Click“Add sharing” To enter interface Enter the user account who you would like to share the device with him. But this user account should be registered on “smart life ”APP.
The steam generator automatically performs a water discharge operation after each use.
Page 40
Blue L1 L2 Brown Page 41
WIRING CONNECTION DRAWING OF DUAL STEAM GENERATORS Bl ue B rown L1 L2 Page 42
Page 43
Page 44
SIZING CHART OF STEAM GENERATOR
SIZING CHART OF DUAL STEAM GENERATORS 265-370 15kw(total) 300-423 16.5kw(total) 350-460 18kw(total) 360-500 19.5kw(total) 380-530 21kw(total) 406-565 22.