INTELLIGENT THINKING Models R-22AMM R-23AM COMMERCIAL MICROWAVE OVEN OPERATION MANUAL OPERATION MANUAL This operation manual contains important information which you should read corefully before using your microwave oven. IMPORTANT:There may be a serious risk to health if this operation manual is not followed or if the oven is modified so that it operates with the door open. SUK R22AMM O/M COVER 3 08.5.
O VEN Ceramic floor (Not removable) Door hinges Holes for safety door latches Oven door with window Oven light Splash cover Door handle Door safety latches Door seals and sealing surfaces Air intake opening Air intake filter Screw for mounting plate Mounting plate Power supply cord Removable cover to access oven light buIb Air vent openings ACCESSORIES: Check to make sure the following accessories are supplied: • Operation manual • Caution sheet (Special lnstructions and Warnings: part number
ONTROL PANEL DISPLAY AND INDICATORS 1 Cook indicator: This indicator shows cooking in progress. 2 TIME display: Lighted digital display 3 POWER LEVEL display: Percentage of microwave power is indicated. POWER 2 1 3 % ON HIGH 4 MEDIUM 5 MED LOW 6 DEFROST 7 TIME CONTROL 8 OPERATING BUTTONS 4 HIGH (100 %) MICROWAVE 5 MEDIUM (50 %) POWER LEVEL 6 MED LOW (20 %) buttons 7 DEFROST (10 %) 8 TIME CONTROL: Rotate the control to enter cooking time 9 START button START 9 2 SUK R22AMM O/M 01-8 2 08.
C ONTENTS Oven Features with Control Panel .......................................................................... 1 - 2 Contents ................................................................................................................. 3 Important Safety Instructions .................................................................................. 4 Installation ...............................................................................................................
I MPORTANT SAFETY INSTRUCTIONS IMPORTANT: PLEASE READ CAREFULLY AND KEEP FOR FUTURE REFERENCE. Oven Use: • The oven is for food preparation only. Never operate when empty. • Do not leave or store anything inside the oven when not in use. • Never attempt to use the oven with the door open. It is important not to tamper with the door safety latches. This may result in exposure to microwave energy.
The socket must be readily accessible so that it can be easily unplugged in an emergency. 7 Do not use the oven outdoors. 8 Two ovens can be installed together by placing one on top of another. Follow these instructions. 8-1) Place the oven A and position the oven B on top of the oven A as shown in the figure A. 8-2) Remove the single screw (a) holding the mounting plate A to the rear cabinet of the oven A. And remove the mounting plate A.
B EFORE OPERATION • • • When you first connect the microwave oven to an elec. trical socket, the digital display will show You can input the buttons and timer control only when the door is closed. Oven lamp and fan motor work for 1minute whenever the door is opened or after cooking. • • • The programme is cancelled when any buttons or timer control are not pressed for more than 3 minutes during programming. To cancel the programme during cooking, open and close the door twice.
NOTE FOR MANUAL COOKING 1. It is not necessary to touch MICROWAVE POWER LEVEL button for 100%. 2. During cooking mode, the oven stops when the door is opened, and the programme is cancelled if any buttons or timer control are not touched within 1 minute after the door is opened. 3. The remaining cooking time is cancelled when the door is closed and opened during stop mode. 4. If you rotate the control counterclockwise, the cooking time will decrease from 30 minutes by degrees.
OTHER CONVENIENT FEATURES REPEAT COOK Your oven can memorize the last cooking time in each power level. If you use this function, you have no need to enter the cooking time. Example: If you want to use this function at 100%. (The last cooking time is 10 minutes.). Step 1 Select desired power level (HIGH). HIGH DISPLAY Step 2 Press START pad once to start cooking. Check the last programme START DISPLAY POWER % ON The display will start to count down to zero.
C OOKING ADVICE WARNING - Always attend the oven when in use. Carefully follow the SHARP Operation Manual at all times. If you exceed recommended cooking times and/or use power levels that are too high, food may overheat, burn, and in extreme circumstances, catch fire and damage the oven. The microwave power level will default to 100% unless you press the POWER LEVEL button for the desired setting. Take care • when heating foods with high sugar or fat content, e.
! Face & Hands: Always use oven gloves to remove food or cookware from the oven. Stand back when opening the oven door to allow heat or steam to disperse. When removing covers (such as cling-film), opening roasting bags or popcorn packaging, direct steam away from face and hands. Check the temperature of food and drink and stir (before serving). Take special care when serving food to babies, children or the elderly.
ADVICE FOR DEFROSTING Meat joints Place in a flan dish, turn over at least 4-5 times during defrosting, shield any warm areas with small, flat pieces of foil. After defrosting, wrap in foil and allow meat to stand for 1-2 hours, until thoroughly defrosted. Poultry Place in a flan dish, turn over at least 3-4 times during defrosting, shield any warm areas with small, pieces of foil. After defrosting, wrap in foil and allow poultry to stand for 1-2 hours, until thoroughly defrosted.
ADVICE FOR REHEATING ! WARNINGS: Oil & Fat: Never heat oil or fat for deep frying as this may lead to overheating and fire. Stand back when opening the oven door to allow heat or steam to disperse. When removing covers (such as cling-film), opening roasting bags or popcorn packaging, direct steam away from face and hands. Never heat liquids in narrow-necked containers, as this could result in the contents erupting from the container and may cause burns.
D EFROSTING CHART MANUAL DEFROSTING FOOD Beef, Lamb & Pork Joints (uncooked) DEFROSTING TIME MICROWAVE R-23AM R-22AMM POWER LEVEL 8 mins 13-14 mins /450g (1lb) DEFROST (10%) METHOD 1. Place on a large plate. 2. Turn over 4-5 times during defrosting. NOTE: If necessary, small pieces of aluminium foil can be used to shield small areas of meat which may become warm during defrosting. 3. After defrosting, wrap in foil and leave to stand for 1-2 hours or until thoroughly defrosted.
D EFROSTING CHART FOOD DEFROSTING TIME MICROWAVE R-23AM R-22AMM POWER LEVEL METHOD Bread Sliced 4-5 mins 4-6 mins /800g (13/4lb) loaf MED LOW (20%) 1. Arrange and separate slices on the turntable. 2. Turn over, separate and re-arrange twice during defrosting. Remove defrosted slices each time. 3. After defrosting, cover with foil for 5-10 minutes or until thoroughly defrosted. Bread Buns 1-2 mins 2-3 mins for 6 buns DEFROST (10%) 1. Place on turntable. 2.
C OOKING CHART FOOD COOKING TIME R-23AM Beef: Medium (Topside, Silverside) Chilled (50C) R-22AMM MICROWAVE POWERLEVEL METHOD 1. Place fat side down in a flan dish. 2. Turn over halfway through cooking and remove juice. 3. After cooking, wrap in foil and leave to stand for 8 minutes before serving. 8-9 mins 12-14 mins /450g (1lb) MEDIUM (50%) Lamb, medium 8-9 mins 12-14 mins (fillet, shoulder, /450g (1lb) leg) Chilled (50C) MEDIUM (50%) As above.
C OOKING CHART FOOD COOKING TIME R-23AM Rice/Pasta Room (200C) R-22AMM 11-12 mins 12-14 mins for 200g (7oz) MICROWAVE POWERLEVEL MEDIUM (50%) METHOD 1. Place Rice/Pasta in a 2.5 litre casserole dish. 2. Add three times the volume of boiling water to quantity of rice. Do not cover. 3. Stir 3 times during cooking. 4. Stand for 2-3 minutes before rinsing in boiling water and serving. HIGH (100%) 1. Pierce each potato in several places. 2. Place on the edge of the turntable. 3.
C OOKING CHART FOOD COOKING TIME R-23AM R-22AMM MICROWAVE POWERLEVEL METHOD New potatoes Room 200C 4 mins 6-7 mins for 450g (1lb) HIGH (100%) Mushrooms (fresh) Room 200C 1 min 2 mins for 225g (8oz) MEDIUM (50%) 1. Chop or leave whole as desired. 2. Place in dish, cover with microwave cling film and pierce in 4-5 places. 3. Stir halfway through cooking. Tomatoes (fresh) Room 200C 1 min 2 mins for 225g (8oz) MEDIUM (50%) 1. Slice or quarter as desired.
R EHEATING CHART FOOD TEMP QUANTITY METHOD REHEATING TIME ON HIGH (100%) R-23AM R-22AMM BREAKFAST Porridge Chilled 125g (5oz) Place in a bowl, uncovered 35 sec 1 min Scrambled Egg Chilled 125g (5oz) Place on a plate, uncovered 30 sec 50 sec Scrambled Egg with bacon or sausage Chilled 175g (6oz) As above 50 sec 1 min 20 sec Bacon Chilled 4 rashers As above 25 sec 45 sec Sausages - thick Chilled 4 As above 35 sec 55 sec Sausages - thin Chilled 8 As above 35 sec 55 sec
R EHEATING CHART FOOD TEMP QUANTITY METHOD REHEATING TIME ON HIGH (100%) R-23AM R-22AMM PREPARED DISHES Spaghetti Bolognese Chilled 300g (11oz) Place on a plate, cover with cling film 1 min 15 sec 2 mins 15 sec Chicken in a sauce Chilled 300g (11oz) As above 2 mins 30 sec 3 mins 15 sec Beef Stroganoff & Rice Chilled 375g (13oz) As above 2 mins 30 sec 2 mins 40 sec BBQ Ribs Chilled 375g (13oz) As above 2 mins Rice/Pasta Chilled 225g (8oz) As above 45 sec 1 min 30 sec 3 mins SAV
R EHEATING CHART FOOD TEMP QUANTITY METHOD REHEATING TIME ON HIGH (100%) R-23AM R-22AMM CANNED FOODS Baked Beans Room 450g (1lb) Place in a bowl, cover with cling film, stir halfway through cooking 1 min 30 sec 2 mins 10 sec Sausage & Beans Room 450g (1lb) As above 2 mins 10 sec 3 mins Soup - thick/thin Room 425g (15oz) As above 1 min 50 sec 2 mins 30 sec Hot Dogs Room 425g (15oz) Place in a bowl, cover with cling film 1 min 45 sec 2 mins 30 sec Peas Room 550g (1lb 4oz) Place in
R EHEATING CHART FOOD TEMP QUANTITY METHOD REHEATING TIME ON HIGH (100%) R-23AM R-22AMM MEAT PORTIONS Chicken Portions Leg Breast Chilled Chilled 1 (300g)(11oz) 1 (400g)(14oz) 1 min 1 min 30 sec Place on a plate, cover with cling film Place on a plate, cover with cling film 1 min 30 sec 2 mins Lamb Chops Chilled 3 (225g)(8oz) Place on a plate, cover with cling film 1 min 30 sec Pork Chop Chilled 1 (125g)(5oz) Place on a plate, cover with cling film Sliced Meat with Gravy Chilled 1 (225g)
A35557, SUK R-23AM O/M C LEANING & MAINTENANCE WARNING • Never use spray cleaners, oven keys or abrasive scourers as these damage the surface of the oven. • Do not remove the ceramic floor from the oven. • Do not use commercial oven cleaners, abrasive or harsh cleaners or scouring pads on any part of your microwave oven. • Do not sprinkle water onto the oven directly. It may cause electric shock, leakage of electricity or damage of the oven.
A35557, SUK R-23AM O/M OVEN INTERIOR Clean the microwave oven cavity, at the end of each day with a damp soft cloth for hygienic reasons. For heavier soil, use mild soap applied with a soft damp cloth wipe clean ensuring all mild soap is removed. Make sure that mild soap or water does not penetrate through the small vents in the walls which may cause damage to the oven. Take care not to let soapy water drip through the small holes in the oven walls.
A35557, SUK R-23AM O/M T ROUBLESHOOTING If you answer "NO" to any question first check that the oven is plugged in properly and the fuse has not blown, if there is no fault with either, check against the troubleshooting chart below. If you think the oven is not working properly there are some simple checks which you can carry out yourself before you call for an engineer. This will help prevent unnecessary service calls if the fault is something simple.
A35557, SUK R-23AM O/M T O REPLACE THE MAINS PLUG The wires in the mains cable are colour coded as shown opposite: As the colours of the cores in the mains lead of your oven may not correspond with the coloured marking identifying the terminals in your plug, connect the wires as shown: Make sure the terminal screws are tight and the cable is held securely by the cable grip where it enters the plug.
A35557, SUK R-23AM O/M SPECIFICATIONS: R-22AMM AC Line voltage AC Power required Output power R-23AM Single phase 230-240V, 50Hz 2.4kW 2.9kW 1500W(IEC 60705) 1900W (IEC 60705) Microwave frequency 2450MHz* (Group 2 / Class B) Outside dimensions 510(W) x 335(H) x 470(D) mm (Single) 510(W) x 670(H) x 470(D) mm (Two ovens stacked) Cavity dimensions 330(W) x 180(H) x 330(D) mm Oven capacity 0.7 cu.ft (20 litres) Cooking uniformity Rotary antenna system Weight Approx.
A. Information on Disposal for Users (private households) 1. In the European Union Attention: If you want to dispose of this equipment, please do not use the ordinary dust bin! Used electrical and electronic equipment must be treated separately and in accordance with legislation that requires proper treatment, recovery and recycling of used electrical and electronic equipment.
