Datasheet

ManualsBrandsRND Power Manuals9VPrimary Battery, Alkaline, E, 9V, Ultra Power, Pack of 10 pieces

1. Scope:

This specification is applicable to RND 305-00003.

2. Law & Regulation Compliances:

This product complies with EU’s battery directive (2013/56/EU).

Packaging materials comply with EU’s directive on packaging materials and waste (94/62/EC)

3. General:

3.1 Type designation

IEC/ JIS 6LR61

ANSI 1604A

Common 9V

3.2 Chemical system: Zn/KOH-H

O/MnO

3.3 Nominal voltage: 9.0 V

3.4 Weight: Approximate 44.0 g

3.5 Dimension (mm)

The dimensions shall be in accordance with the below figures both prior to and after service output test.

Measuring equipment shall be with an accuracy ±0.05mm at least.

3.6 Capacity: Approximate 500mAh (35mA, 24h/d, 20℃, e.v.= 5.4V)

3.7 Operation temperature : -18℃~50℃

Recommend storage temperature : Not exceed 30℃

3.8 Heavy Metal Contents: Hg ≤1 ppm, Cd≤20ppm, Pb≤40ppm

min

max

46.5

48.5

46.4

12.45

12.95

24.5

26.5

15.5

17.5

Primary Alkaline Battery

9 V 6LR61/E-Block Pack of 10 pieces

Distrelec Schweiz AG, Grabenstrasse 6, 8606 Nänikon, Switzerland, T +41 44 944 99 11, info@distrelec.com, distrelec.com

Summary of content (6 pages)

PAGE 1
Primary Alkaline Battery 9 V 6LR61/E-Block Pack of 10 pieces 1. Scope: This specification is applicable to RND 305-00003. 2. Law & Regulation Compliances: This product complies with EU’s battery directive (2013/56/EU). Packaging materials comply with EU’s directive on packaging materials and waste (94/62/EC) 3. General: 3.1 Type designation IEC/ JIS ANSI Common 6LR61 1604A 9V 3.2 Chemical system: Zn/KOH-H2O/MnO2 3.3 Nominal voltage: 9.0 V 3.4 Weight: Approximate 44.0 g 3.
PAGE 2
4. Electrical Characteristics Unless otherwise stated, all measurements are to be performed at a Standard Environment of 20 ± 2°C 55 ± 20% RH. All samples are normalized for 8 hours at least at the above environment prior to measurement. The digital voltmeter (DCM) is with the precision of 1mV (internal resistance not less than 1 Megohm). The load resistance of the total circuit is accurate within ±0.5% of the specified value. 4.1 Open circuit voltage and closed circuit voltage (Load resistance 180Ω, 0.
PAGE 3
4) MAD：minimum average duration--our guarantee discharge value. 5)Normal：normal data, it's our normal daily value, battereis dicharge value are on this as base to be upper or lower. 5. Leakage Resistance 5.1 Over discharge leakage test Test conditions: 20±2℃ & RH 55±20%, 35mA continuous discharge 48h. Number of test samples: 9 batteries Requirement: No visible leakage; No explosion. 5.2 High temperature leakage test Test conditions: store 20 days under 60±2℃, then store 4~24h under standard environment.
PAGE 4
The printing on each cell label is legible and permanent. Label defects, if any, shall conform to mutually agreed upon limit samples. 9.2 It is recommended that packaging for shipment and sales according with Packaging Specification of Pairdeer alkaline cell. For example, 1pc battery in a blister, 30 blisters in a display box, 4*2*1 display boxes in a final outer carton, and 4*2*4 outer cartons on a pallet. Flow chart as follows: 9.
PAGE 5
Distrelec Schweiz AG, Grabenstrasse 6, 8606 Nänikon, Switzerland, T +41 44 944 99 11, info@distrelec.com, distrelec.
PAGE 6
10. Component / Information of Ingredients Chemical Nature: MATERIALS Manganese Dioxide (MnO2) Zinc Powder (Zn) Alkaline zinc-manganese dioxide batteries APPROXIMATE PERCENT OF CAS NO. MATERIALS TOTAL WEIGHT (%) APPROXIMATE PERCENT OF TOTAL WEIGHT (%) CAS NO. ~34.0 1313-13-9 Brass ~4.3 12597-71-6 ~13.0 7440-66-6 Fe ~28.0 7439-89-6 Water (H2O) ~6.1 7732-18-5 Ni-plating ~0.3 7440-02-0 Potassium Hydroxide (KOH) ~1.5 1310-58-3 Bi ~0.0027 7440-69-9 Carbon ~1.96 7782-42-5 In ~0.