Use and Care Manual

ManualsBrandsQwork ManualsFire Pits30 in. x 30 in. x 25 in. Sturdy Steel Slat Top Square Gas Fire Pit in Black

DANGER · FLAMMABLE GAS UNDER PRESSURE.

LEAKING LP-GAS MAY CAUSE A FIRE OR EXPLOSION IF IGNITED

CAUSING SERIOUS BODILY INJURY OR DEATH.

CONTACT LP GAS SUPPLIER FOR REPAIRS, OR DISPOSAL OF THIS

CYLINDER OR UNUSED LP-GAS.

WARNING · FOR OUTDOOR USE ONLY.*

DO NOT USE OR STORE CYLINDER IN A BUILDING,

GARAGE OR ENCLOSED AREA.

WARNING:

Know the odor of LP-gas. If you hear, see or smell

leaking LP-gas, immediately get everyone away

from the cylinder and call the Fire Department.

Do not attempt repairs.

Caution your LP-gas supplier to:

Be certain cylinder is purged of trapped air prior

to first filling.

Be certain not to over fill the cylinder.

Be certain cylinder requalification date is checked.

LP-gas is heavier than air and may settle in low

places when dissipating.

Contact with the liquid contents of cylinder will

cause freeze burns to the skin.

Do not allow children to tamper or play with cylinder.

When not connected for use, keep cylinder valve

turned off. Self contained appliances shall be limited

to a cylinder of 30 lb capacity or less.

Do not use, store or transport cylinder where it would

be exposed to high temperatures. Relief valve may

open allowing a large amount of flammable gas to

escape.

When transporting, keep cylinder secured in

an upright position which cylinder valve turned off.

DO NOT REMOVE, DEFACE, OR OBLITERATE THIS LABEL

*EXCEPT AS AUTHORIZED BY ANSI/NFPA 58.

DANGER. Do not store a spare LP cylinder under or near a barbecue grill, or other

heat sources. NEVER fill an LP cylinder beyond 80% full: a fire causing death or

serious injury may occour.

WHEN CONNECTING FOR USE:

Use only in compliance with appliable codes.

Read and follow manufacturer’s instructions.

Consult manufacturer’s instructions

concerning the cylinder connection provided

with your appliance.

Be sure regulator vent is not pointing up.

Turn off all valves on the appliance.

Do not check for gas leaks with a match or

open flame. Apply soapy water at areas

marked ”X”. Open cylinder valve. If bubble

appears, close valve and have LP-gas

service person make needed repairs. Also,

check appliance valves and connections to

make sure they do not leak before lighting

appliance.

Light appliance(s) following manufacturer’s

instructions.

When appliance is not is use, keep the

cylinder valve closed.

Cylinder

Pressure relief valve

Cylinder valve hand wheel

Point of connection

Liquid level indicator

(optional)

Please keep this instruction manual for future reference

WARNING:

Assembly Instructions

30” SLAT TOP GAS FIRE PIT TABLE

Model #: GFT-31269

Item #: UI-GFT-31269-BK

READ INSTRUCTION MANUAL BEFORE ATTEMPTING ASSEMBLE OR

OPERATE THIS PRODUCT.

Keep the screws and parts out of reach of children.

(Made in China)

Summary of content (15 pages)

PAGE 1
Model #: GFT-31269 Item #: UI-GFT-31269-BK Assembly Instructions 30” SLAT TOP GAS FIRE PIT TABLE DANGER · FLAMMABLE GAS UNDER PRESSURE. LEAKING LP-GAS MAY CAUSE A FIRE OR EXPLOSION IF IGNITED CAUSING SERIOUS BODILY INJURY OR DEATH. CONTACT LP GAS SUPPLIER FOR REPAIRS, OR DISPOSAL OF THIS CYLINDER OR UNUSED LP-GAS. WARNING · FOR OUTDOOR USE ONLY.* DO NOT USE OR STORE CYLINDER IN A BUILDING, GARAGE OR ENCLOSED AREA. WARNING: WHEN CONNECTING FOR USE: · · · Use only in compliance with appliable codes.
PAGE 2
Table of Contents Assembly..………………………………………....…7-10 Operating Instructions .........................................11-13 Maintenance...........................................................14 Care and Cleaning ................................................14 Troubleshooting ....................................................15 Table of Contents ..........................................................2 Safety Information...........................................................2-4 Warranty........
PAGE 3
Safety Information (continued) WARNING: You must provide propane gas and propane cylinder. Use a standard 20 lb. propane cylinder only. Use this heater only with a propane vapor withdrawal supply system. See Chapter 5 of the Standard for Storage and Handling of Liquefied Petroleum Gas, ANS/NFPA 58. Your local library or fire department should have this book. The pressure regulator and hose assembly supplied with the appliance must be used.
PAGE 4
Safety Information (continued) WARNING: Solid fuels shall not be burned in this appliance. The installation must conform with local codes or, in the absence of local codes, ANSIZ223. 1/NFPA54, NFPA58 Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2.
PAGE 5
Pre-Assembly PLANNING ASSEMBLY Carefully remove all pieces from the carton and make sure that you have all parts (refer to the hardware and package contents list). If you are missing parts, please contact after-services for further assistance. YOUR OWNER’S MANUAL Keep and store this Owner’s Manual for future reference. It contains important instructions and procedures for safety and maintenance. NOTE: Please read and understand the entire manual before you assemble, operate, or install the fire pit.
PAGE 6
Package Contents E F G H D H C A I B L M K J Part A B C D E Quantity Part Back Leg D 1 1 1 1 Metal Lid 1 H I J K L M Description Front Leg A Front Leg B Back Leg C F Lava Rock 1 G Table Top with Burner 1 6 Description Quantity Cover 2 1 1 1 1 Door Knob 1 Side Panel Side Panel with Window Door Panel Gas Tank Support
PAGE 7
Assembly 1 Assembling the legs D □ Place Table Top with Burner (G) upside down on a flat, protected surface. Attach the Legs (A,B,C,D) to the Table Top with Burner (G) using eight (8) M6 x 10 mm Bolts (AA). □ Do not tighten the bolts at this step. C A B AA G 2 Assembling the side panels □ Attach each Side Panel (H) to the Legs (A,D,C) using eight (8) M6 x 10 mm bolts (AA). □ Do not tighten the bolts at this step.
PAGE 8
Assembly (continued) the side panel with 3 Assembling window C □ Attach the Side Panel with Window (I) to the Legs (B,C) using four (4) M6 x10 mm bolts (AA). □ Attach control panel to Side Panel with Window (I) using four (4) M5*10mm bolts (BB) and four (4) M5 nut. □ Do not tighten the bolts at this step. I B AA CC BB 4 D Assembling the gas tank support C □ Attach Gas Tank Support (K) to the Legs (A,B,C,D) using four (4) M6 x 10 mm bolts (AA).
PAGE 9
Assembly (continued) 5 Assembling the door □ Attach Door Knob (M) to Door Panel (J) using one (1) M6*25 mm bolts (EE). Please fully tighten all bolts at this time. □ Orient the unit so that Table Top with Burner (G) is facing up. □ Slide the hinge of Door Panel (J) on to the Front Leg (A). EE M J G A 6 Place the lava rock □ Place the Lava Rock (F) into the fire bowl. Ensure lava rock is not placed on the ignition portion of the burner. Place the Metal Lid (E) over the top.
PAGE 10
Assembly (continued) 7 Assembling the cylinder □ Put the cylinder into the Gas Tank Support (K), and secure the cyliner by tightening the screw in the gas tank support. Connect the hose and regulator to the cylinder. NOTE: The propane cylinder is sold separately. Use a standard 20 lb. propane cylinder only. Put the hose away from the bowl base during connect the propane cylinder. 8 Installing the AAA battery □ Open the igniter and place the AAA battery (DD) into the igniter. Then tighten clockwise.
PAGE 11
Operating WARNING: Never use this appliance for other than the intended use. DO NOT use this appliance to prepare food. Initial Lighting: When lit for the first time, the appliance emits a slight odor. This is a normal temporary condition caused by the “burn-in ” of internal paints and lubricants used i n the manufacturing process and does not occur again. Simply run the main burner on high for approximately one-half hour.
PAGE 12
Operating (continued) LEAK TESTING OPERATION WARNING: A leak test must be performed annually or if a part of the gas system is replaced. WARNING: Never use an open flame to check for gas leaks. Be certain no sparks or open flames are in the area while you check for leaks. Sparks or open flames will result in a fire or explosion, damage to property, serious bodily injury, or death. LEAK TESTING: 1, Make 2-3 oz. of leak detection solution by mixing one part liquid dishwashing soap with three parts water.
PAGE 13
Operating (continued) LIGHTING CAUTION: Keep the outdoor gas appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids. CAUTION: Do NOT obstruct the flow of combustion and ventilation air. CAUTION: Check and clean burner/venturi tubes for insects and insect nests. A clogged tube can lead to a fire. 1. Make sure all labels, packaging and protective films have been removed from the outdoor fire pit. 2. Control knob must be in the “OFF” position (Figure 1). 3.
PAGE 14
Maintenance Storage between uses: □ Turn the control knob to “OFF” position. □ Disconnect LP source. □ Store heater upright in an area sheltered from direct contact with inclement weather (such as rain, sleet, hail, snow, dust and debris). □ If desired, cover heater to protect exterior surfaces and to help prevent build up in air passages. NOTE: Wait until heater is cool before covering. Storage during periods of extended inactivity or when transporting: □ Turn the control knob to “OFF” position.
PAGE 15
Troubleshooting PROBLEM PROBLEM CAUSE SOLUTION The flame and heat are low when the valve is turned to high. The propane lighting procedure was not followed correctly. Ensure lighting procedure is followed carefully. The valve must be in the off position when the tank valve is turned on. Turn the tank on slowly to allow pressure to equalize. See Lighting Instructions in the Operating section. Burners burn with yellow flame, accompanied by the smell of gas.