FIREMASTER IV "MillenniumThree" radio shooting system User’s manual 5.0 BPK-48A EMERGENCY BATTERY PACK 5.
FIREMASTER IV "MillenniumThree" radio shooting system User’s manual 1. IP67 Ultra-High Impact Copolymer Polypropylene case. 34 x 29.5 x 15.2 cm 2. Double-step latches 3. Stainless steel reinforced padlock protector 4. Waterproof 7-pole DIN connector for external emergency battery.
FIREMASTER IV "MillenniumThree" radio shooting system User’s manual 14. OPTIONAL CONNECTOR for the EXTERNAL Battery Pack. 7-pole DIN connector male. Normally this connector IS NOT MOUNTED on the front-panel of the BPK-48A units: it is placed outside on the CASE front (see case diagram, point 4). 15. Insulated bipolar receptacle for the mains supply cable. WARNING: the Unit is NOT PROVIDED WITH A GROUND CONNECTION (this condition is marked with the specific symbol).
FIREMASTER IV "MillenniumThree" radio shooting system User’s manual 5.2 GENERAL DESCRIPTION The Emergency Battery Pack BPK-48A is an autonomous Unit containing the following elements: - TWO Batteries for the fire lines: 12V 1,2Ah. Lead-acid type, sealed with gel-immobilized electrolyte. - ONE Battery for the System supply: 12V 5,7Ah. Lead-acid type, sealed with gel-immobilized electrolyte. - Universal Line power supply (110 - 240Va.c 50-60Hz for the re-charge system.
FIREMASTER IV "MillenniumThree" radio shooting system User’s manual 5.3 OPERATION DESCRIPTION 5.3.1 TEST The INTERNAL BATTERIES of the BPK-48A are tested by the circuits of the RX48 Unit when the connection is made. The BPK-48A doesn’t have any internal circuit to detect the charge status of its batteries: it will be User’s care to maintain always WELL CHARGED the batteries of the BPK48A unit or to connecting it time to time (when not in use) to a RX48 Unit to monitor the residual battery charge. 5.3.
FIREMASTER IV "MillenniumThree" radio shooting system User’s manual 5.3.4 CHARGE The BPK-48A Battery Pack must be first connected to the mains with the line cord: the blue LINE LED will turn immediately ON and the TEST OK/FAULT yellow LED will start to blink. The BATTERY#1 (SYSTEM) LED will turn ON (green): during 10 seconds the battery is tested (the corresponding green LED is steady).
FIREMASTER IV "MillenniumThree" radio shooting system User’s manual 5.3.5 ERROR CONDITIONS LISTING The table below resumes all the possible error conditions and the way they are indicated by the LED lamps on the front-panel of the Battery Pack. The same information is printed on the front-panel itself.
FIREMASTER IV "MillenniumThree" radio shooting system User’s manual 5.4 BATTERIES All batteries used by the FIREMASTER IV "Millennium Tree" SYSTEM, are of SEALED lead-acid type with GEL solid electrolyte. These are very reliable batteries requiring very little precautions and need PRACTICALLY NO SERVICE.
FIREMASTER IV "MillenniumThree" radio shooting system User’s manual passed, OK: the battery was just discharged and can be still used. If otherwise the battery still exhibits an excessive voltage reduction under load, then it MUST BE IMPERATIVELY DISCARDED AND REPLACED WITH A NEW ONE. NOTE: all batteries installed inside the RX48 Units, are AUTOMATICALLY TESTED with the above method. 7) The MEAN LIFE of a lead-acid battery is ABOUT 2 YEARS or 500 charging cycles (whichever is less).
FIREMASTER IV "MillenniumThree" radio shooting system User’s manual 5.
FIREMASTER IV "MillenniumThree" radio shooting system User’s manual BPK-48A – INTERNAL VIEW – BATTERY REPLACEMENT When it is necessary to access the internal batteries for a check or replacement, proceed as follows: 1) If not already done, SWITCH OFF the Unit (Remote or Base). 2) Unscrew the top panel. 3) Remove VERY CAREFULLY the top panel. Disconnect the antenna coaxial cable and the external battery connection.
FIREMASTER IV "MillenniumThree" radio shooting system - - User’s manual TRANSMITTER (TX5000): ONE 12V 5,7Ah battery series dryfit A300 SERIAL 07 191432 00 (optionally it can be used the same type series A200 SERIAL 07 191432 00) RICEIVERS (RX48): - ONE SYSTEM BATTERY 12V 5,7Ah series dryfit A300 SERIAL 07 191432 00 (optionally it can be used the same type series A200 SERIAL 07 191432 00) - TWO LINE (FIRE) BATTERIES 12V 1,1Ah seris dryfit A300 SERIAL 07 191185 00 (optionally it can be used the same type