Outdoor Distinctions 303 W. Carmel Drive Carmel, IN 46032 844.345.2424 www.outdoordistinctions.
English Installation Instructions Free-Standing Harmony Pergola (18 x 10, 18 x 12, 18 x 14, 18 x 16, 18 x 18, 18 x 20) Congratulations on your purchase of the Free-Standing Harmony Pergola. Before you begin, please refer to the parts list to ensure all materials needed for assembly have been received. Parts Included with this Product Item Quantity A. & B. Description A. 4 Stainless Steel Wing Bracket B. 4 Stainless Steel Cover Plate C. 48 2.5” Stainless Steel Philips Screw D.
English Installation Instructions Free-Standing Harmony Pergola General Information Your Outdoor Distinctions Pergola has been designed for installation on a cement slab, cement piers, or in ground using wood post supports. If installing on a wooden deck ensure the deck has additional supports below the deck surface. All installation methods require the installer to supply four 4" x 4" wood support posts in proper lengths and if pier or slab mounted, four metal fasteners with hardware.
English Installation Instructions Free-Standing Harmony Pergola 12”- 19”+ Step 2.A. - Foundation for 4 x 4 Wood Support (Concrete Pier) 4” 24” - 36” 1. Using a post hole digging tool, dig a hole 12" in diameter approximately 24"- 36" deep. Place a 12" sonatube into the hole for the concrete pier. 2. For a finished look, build a frame around the top of the hole 12” 19”+ wide creating a pad to set the Column (I) and Base Cap (L) on. 12”- 19”+ 12” Item 1 3.
English Installation Instructions Free-Standing Harmony Pergola 12”- 19”+ Step 2.B. - High Wind Load Installation 4” 24” - 36” 12” Item 1 1. Using a post hole digging tool, dig a hole 12" in diameter approximately 24"- 36" deep. Place a 12" sonatube into the hole. 12”- 19”+ 2. For a finished look, build a frame around the top of the hole 12” - 19”+ wide creating a pad to set the Column (I) and Base Cap (L) on. 3. Level the pier platforms using string line, wood pegs and a string level. Item 2 4.
English Installation Instructions Free-Standing Harmony Pergola Step 3 - Column Assembly 1. With the 4 x 4 post secured to the foundation, measure Column (I). Add 1/8” to 1/4” to column measurement and mark a line on the 4 x 4 post. Remove excess 4 x 4 length at the top with a saw. 2. Carefully slide Column Spacer (M) over 4 x 4 post and position at the base of the 4 x 4. M. Item 2 I. L. 3. Align the groves on the Cover Plate (B) with the Wing Bracket (A) arm extensions that fit over the 4 x 4 post.
English Installation Instructions Free-Standing Harmony Pergola (18 x 10, 18 x 12, 18 x 14, 18 x 16, 18 x 18, 18 x 20) Step 4 - Roof Assembly 1. Place first Notched Beam (G) onto Cover Plates (B) and adjust accordingly with Wing Brackets (A). Drill 2 pilot holes through top of Wing Bracket (A) as a guide into Notched Beam (G) using 3/16 drill bit.
English Pergola and Arbor Use and Care Instructions Use and Care Your Pergola / Arbor will provide years of maintenance free use under normal conditions. The materials used will withstand many years of normal weathering with no additional finishing required. However, dirt and acids from rain may discolor or dirty the finish. Clean using STET mild detergents is recommended.
English Product Warranty Pergola and Arbor Products Original Owners Limited Warranty for Outdoor Distinctions, LLC Pergola/Arbor Products COVERED BY THIS LIMITED WARRANTY: Outdoor Distinctions, LLC (hereinafter Outdoor Distinctions) warrants to the original purchaser and not any other purchaser, or subsequent owner, that its Pergola/Arbor Product (“Product”) is free from defects in material and workmanship including severe splitting, rusting, and corrosion resulting in a loss of Product’s structural integr
English Product Warranty Pergola and Arbor Products COVERED BY THIS LIMITED WARRANTY: (Continued) IN NO EVENT SHALL OUTDOOR DISTINCTIONS BE LIABLE FOR ANY CONSEQUENTIAL, SPECIAL, OR INCIDENTAL DAMAGES ARISING OUT OF OR CONNECTED WITH THE PURCHASE OR USE OF THIS PRODUCT OR FOR ANY BREACH OF THIS LIMITED WARRANTY. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS SO THE ABOVE PROVISION MAY NOT APPLY TO YOU.
English WARNING Statement Pergola and Arbor Products The following Warning Statements must be reviewed and followed to avoid injury or property damage. Save these instructions for future reference. If you are installing and assembling this unit for someone else, give these instructions to them to read and save for future reference. Improper installation, adjustment, alteration service or maintenance can cause injury or property damage.
