Installation Instructions Sabbath Mode Product Kit ZSAB1 For Use With Monogram Built-In Refrigerators: 36", 42" & 48" Side-by-Side “R” Models (Manufactured On or After February 2004) and “X” Models 36" Bottom-Freezer “R” Models (Manufactured On or After April 2004) and “X” Models 36" All-Refrigerator/ All-Freezer “X” Models
Safety Instructions WARNING – • FOR PERSONAL SAFETY: Remove house fuse or open circuit breaker before beginning installation. READ CAREFULLY. KEEP THESE INSTRUCTIONS. ATTENTION – FOR YOUR SAFETY SÉCURITÉ : Enlever le fusible du circuit ou déclencher le disjoncteur avant de commencer l’installation. Read and observe all CAUTION and WARNINGS shown throughout these instructions. While performing installations described in this booklet, gloves, safety glasses or goggles should be worn.
Introduction ABOUT THE SABBATH MODE This feature was designed for use on the Jewish Sabbath and Holidays. The Sabbath Mode feature makes it possible for observant Jews to refrigerate and freeze food during the duration of the holiday. When set, the Sabbath Mode feature will override typical reactions to actions in your refrigerator. While in Sabbath Mode your refrigerator will still operate normally, but the refrigerator will not respond to your actions.
Introduction USING THE SABBATH SWITCH • To activate the Sabbath Mode feature, raise the top grille panel and set the Sabbath Mode switch to the ON position. • When the refrigerator is in Sabbath mode, a green LED light will be visible. On Side-by-Side Refrigerators, the green light will be visible between the top grille panel and the refrigerator door. On Bottom-Freezer Refrigerators, the green light may not be visible with the top grille panel closed.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX Side-by-Side Refrigerators “R” Models Only If your Side-by-Side refrigerator is an “X” model, go to page 8. MOUNT SWITCHBOX • FOR PERSONAL SAFETY: Unplug the refrigerator, remove house fuse or open circuit breaker before beginning installation. • Open the grille panel. • Place a sheet or towel over the top of the fresh food and freezer doors to prevent accidentally scratching the door panels.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX Side-by-Side Refrigerators “R” Models Only (cont.) MAKING ELECTRICAL CONNECTIONS • Locate the Refrigerator’s AC Input and Output connectors to the upper right of the evaporator housing. • Disconnect the refrigerator’s AC Input and Output connectors from each other. NOTE: If possible, try to avoid exposing the wires attached to the refrigerator’s AC connectors. • Connect the switchbox AC Input connector to the refrigerator’s AC Input connector.
Installation Instructions MAKING ELECTRICAL CONNECTIONS (cont.) Refrigerator DC Connectors • Connect the switchbox DC Input connector to the refrigerator’s DC Input connector. • Connect the switchbox DC Output connector to the refrigerator’s DC Output connector. Kit DC Input Connector (2 holes) Kit DC Output Connector (2 prongs) Kit DC Connectors • Route the switchbox wires through the wire straps already attached to the evaporator housing.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX Side-by-Side Refrigerators “X” Models Only If your Side-by-Side refrigerator is an “R” model, go to page 5. MOUNT SWITCHBOX • FOR PERSONAL SAFETY: Unplug the refrigerator, remove house fuse or open circuit breaker before beginning installation. • Open the grille panel. • Place a sheet or towel over the top of the fresh food and freezer doors to prevent accidentally scratching the door panels. • Remove the water filter.
Installation Instructions MAKING ELECTRICAL CONNECTIONS • Locate the Refrigerator’s AC Input and Output connectors to the upper right of the evaporator housing. • Disconnect the refrigerator’s AC Input and Output connectors from each other. NOTE: If possible, try to avoid exposing the wires attached to the refrigerator’s AC connectors. • Connect the switchbox AC Input connector to the refrigerator’s AC Input connector. • Connect the switchbox AC Output connector to the refrigerator’s AC Output connector.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX Side-by-Side Refrigerators “X” Models Only (cont.) MAKING ELECTRICAL CONNECTIONS (cont.) • Replace the water filter bracket and water filter. • Place the switchbox against the evaporator housing to the left of the main control board cover (on 36" and 42" models) or to the right of the main control board cover (on 48" models). Make sure the green LED light on the side of the switchbox is pointing DOWN.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX Bottom-Freezer Refrigerators “R” Models Only If your Bottom-Freezer refrigerator is an “X” model, go to page 14. MOUNT SWITCHBOX • FOR PERSONAL SAFETY: Unplug the refrigerator, remove house fuse or open circuit breaker before beginning installation. • Open the grille panel. • Place a sheet or towel over the top of the fresh food door to prevent accidentally scratching the door panel.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX Bottom-Freezer Refrigerators “R” Models Only (cont.) MAKING ELECTRICAL CONNECTIONS (cont.) • Connect the switchbox AC Input connector to the refrigerator’s AC Input connector. • Connect the switchbox AC Output connector to the refrigerator’s AC Output connector.
Installation Instructions MAKING ELECTRICAL CONNECTIONS (cont.) • Route the wires for the AC connectors over the water filter. Route the wires for the DC connectors under the door trim. If necessary, use the wire ties included with the kit to dress the wires. Water Filter NOTE: Make sure the door hinge does not pinch the wires hanging down from the switchbox when closing the door. • Cover any exposed wiring on the refrigerator connectors with UL approved electrical tape.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX Bottom-Freezer Refrigerators “X” Models Only If your Bottom-Freezer refrigerator is an “R” model, go to page 11. MOUNT SWITCHBOX • FOR PERSONAL SAFETY: Unplug the refrigerator, remove house fuse or open circuit breaker before beginning installation. • Open the grille panel. • Place a sheet or towel over the top of the fresh food door to prevent accidentally scratching the door panel.
Installation Instructions MAKING ELECTRICAL CONNECTIONS Kit AC Connectors • Connect the switchbox AC Input connector to the refrigerator’s AC Input connector. • Connect the switchbox AC Output connector to the refrigerator’s AC Output connector. Kit AC Output Connector (3 prongs) Refrigerator AC Connectors Kit AC Input Connector (3 holes) • Locate the refrigerator’s DC Input and Output connectors to the left of the compressor. • Disconnect the refrigerator’s DC Input and Output from each other.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX Bottom-Freezer Refrigerators “X” Models Only (cont.) MAKING ELECTRICAL CONNECTIONS (cont.) • Route the wires for the AC connectors over the water filter. Route the wires for the DC connectors under the door trim. If necessary, use the wire ties included with the kit to dress the wires. NOTE: Make sure the door hinge does not pinch the wires hanging down from the switchbox when closing the door.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX All-Refrigerators and All-Freezers “X” Models Only REMOVE GRILLES IN ALL-REFRIGERATOR • FOR PERSONAL SAFETY: Unplug the refrigerator, remove house fuse or open circuit breaker before beginning installation. • Open the grille panel. • Place a sheet or towel over the top of the fresh food door to prevent accidentally scratching the door panel. • Use a 1/4" hex driver and remove the 2 screws at the bottom of the grille.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX All-Refrigerators and All-Freezers “X” Models Only INSTALL SWITCHBOX TO BRACKET • Use a flat screwdriver to pry up the tabs on the front bracket you have removed. • Use needle nose pliers to straighten these tabs. • Attach the Sabbath Mode Switchbox to these bracket tabs using the screws provided. • ALL-FREEZER MODELS: Reinstall the second portion of the bracket that was removed earlier.
Installation Instructions MAKING ELECTRICAL CONNECTIONS (cont.) • Connect the switchbox AC Input connector to the refrigerator’s AC Input connector. • Connect the switchbox AC Output connector to the refrigerator’s AC Output connector. Kit AC Connectors Kit AC Output Connector (3 prongs) Kit AC Input Connector (3 holes) Refrigerator AC Connectors • Locate the refrigerator’s DC Input and Output connectors to the left of the compressor. • Disconnect the refrigerator’s DC Input and Output from each other.
Installation Instructions INSTALLING SABBATH MODE SWITCHBOX All-Refrigerators and All-Freezers “X” Models Only INSTALL SWITCHBOX AND BRACKET • Reinstall the bracket(s) using screws removed earlier. Make sure the wires go OVER the bracket and out of the way before installing. NOTE: Make sure the door hinge does not pinch the wires hanging down from the switchbox when closing the door. • Cover any exposed wiring on the refrigerator connectors with UL approved electrical tape.
Consumer Information FREQUENTLY ASKED QUESTIONS • How long can I run my refrigerator in Sabbath Mode? We recommend against running the refrigerator for longer than 4 days at a time in Sabbath mode, as the overall cooling capability of the refrigerator may be affected. • Can I use Sabbath Mode in a hot or humid environment? Yes. • Why do Quick Chill and Express Chill not work while the refrigerator is in Sabbath Mode? The Quick Chill and Express Chill features are disabled during Sabbath Mode.
Notes 22
Notes 23
Consumer Information WARRANTY Staple sales slip or canceled check here. Proof of original purchase date is needed to obtain service under warranty. WHAT IS COVERED From the Date of the Original Purchase • FULL TWO-YEAR WARRANTY For two years from date of original purchase, we will provide, free of charge, parts and service labor in your home to repair or replace any part of the Sabbath Mode Product Kit that fails because of a manufacturing defect.