Full Product Manual

ManualsBrandsModeno ManualsFire Pits50 in. Eco-Stone Firey Rock Fire Pit

1/18

DANGER

WARNING

For outdoor use only. DO NOT use

for cooking. DO NOT use under any

overhead enclosure.

IMPORTANT

SAVE THESE

INSTRUCTIONS

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. If odor continues, keep away

from the appliance and

immediately call your gas supplier

or fire department.

Do not store or use gasoline or other

flammable vapors and liquids in the

vicinity of this or any other appliance.

This unit is not for use with

propane. Use only with Natural

gas.

WARNING

If the information in this manual is not

follow exactly, a ﬁre or explosion may

result causing property damage

personal injury or loss of life

Read the installation, o

eration

and maintenance instructions

thoroughly before installing or

servicing this equipment.

Installation and service must be

performed by a qualiﬁed installer,

service agency or gas supplier.

Improper installation, adjustment,

alteration, service or maintenance can

cause injury or property damage.

Save these instructions for future

reference. If you are assembling

this unit for someone else, give

this manual to him or her to read

and save for future

reference.

OFE102-NP

Burning Rock owner’s manual

Summary of content (18 pages)

PAGE 1
OFE102-NP Burning Rock owner’s manual ! IMPORTANT SAVE THESE INSTRUCTIONS WARNING For outdoor use only. DO NOT use for cooking. DO NOT use under any overhead enclosure. WARNING ! If the information in this manual is not follow exactly, a ﬁre or explosion may result causing property damage, personal injury or loss of life ! Read the installation, operation and maintenance instructions thoroughly before installing or servicing this equipment.
PAGE 2
Table of Contents Important Safety Information 3 Natural Gas Warnings 5 Parts List 7 Pre-use Instructions 8 Lighting Instructions 12 Care and Cleaning 13 Gas Component Connection Checks 14 Troubleshooting 16 Warranty 18 DANGER CARBON MONOXIDE HAZARD This appliance can produce carbon monoxide which has no odor. Using it in an enclosed space can kill you. Never use this appliance in an enclosed space such as camper, tent, car or home.
PAGE 3
IMPORTANT SAFETY INFORMATION WARNING FIRE TABLE IS FOR OUTDOOR USE ONLY ! IF YOU SMELL GAS:  Shut off gas supply to the fire table.  Extinguish any open flame.  Do not try lighting any appliance.  Do not touch any electrical switch, do not use any phone in your building.  Immediately call your gas supplier from a neighbor’s phone.  If you cannot reach your gas supplier, call the fire department.
PAGE 4
IMPORTANT SAFETY INFORMATION (Continued) • DO NOT store or use gasoline or other ﬂammable vapors and liquids within 25 feet (7.62m) of this or any other appliance. • DO NOT store any combustible materials in the base enclosure. • DO NOT use in an explosive atmosphere. Keep gas ﬁre table area clear and free from combustible materials, gasoline and other ﬂammable vapors and liquids. • This outdoor ﬁre table is NOT to be operated by children.
PAGE 5
IMPORTANT SAFETY INFORMATION (Continued) • Before each use, remove the lava rocks. Examine the burner and its components. If dirty, clean with a soft brush and soapy water solution. Also examine the area around the burner. Any dirt or foreign material, such as spider webs or nests in this area should be removed. If it is evident that the burner is damaged, the ﬁre table must not be used. The burner assembly cannot be replaced. Please contact Elementi at 909-985-553 for technical support.
PAGE 6
NATURAL GAS DANGERS AND WARNINGS (Continued) Never store or use gasoline or other volatile substance in the vicinity of this ﬁre table. Natural Gas Connection Connect a manual shut-off valve to gas supply line. Apply sealing compound or pipe thread tape of the type resistant to the action of natural gas on all male pipe threads. Connect the end, with the quick release connector, or the natural gas hose to manual shut-off valve at the gas supply.
PAGE 7
PARTS LIST 1 Fire Table 1 2 Natural Gas Hose and Quick Disconnect 1 3 Lava Rock 1 3 1 2 7/18
PAGE 8
1 2 Install the AAA battery as shown in the diagram below. Battery included. Place lava rock by hand. DO NOT dump bag out in to the tray to avoid clogging the burner with dust. Position the lava rock (10kgs) to a level about 1” above the t op of the burner. Make sure that you do not block the igniter box with lava rock to ensure proper ignition.
PAGE 9
Connecting your Fire Table to the Natural Gas Source A professionally installed shut-off valve between the supply piping and the socket 3 is recommended by the National Fuel Gas Code. Socket connection must be made outdoors. House Natural Gas Piping Connecting the Socket Coat the gas supply pipe nipple with gas resistant pipe compound or approved Teflon PTFE tape. Screw socket onto gas supply pipe (house gas source) as shown to the right, and wrench tighten.
PAGE 10
5 Using the Quick Connect Socket Pull back the sleeve on the quick disconnect socket and insert the unattached end of the gas hose into the socket. Release the sleeve and continue pushing the hose into the socket until the sleeve snaps into the locked position. After making all connections, perform a leak test as described on page 12 of this manual.
PAGE 11
PRE-USE INSTRUCTIONS 6 WARNING Before using this outdoor fire table, make sure you have read, understand and are following all information provided in the Important Safety Information section of this manual. Failure to follow those instructions can cause death, serious injury or property damage. Prior to each gas fire table operation, check the hose and valve for evidence of excessive abrasion or wear through the visual check hole on the side of the base.
PAGE 12
LIGHTING INSTRUCTIONS Using the Igniter 1. Read and understand all operating instructions before lighting. Ensure that all protective film has been removed from stainless burn tray prior to lighting. 2. Burner control knob must be in the “OFF” position. 3. Connect natural gas source (see above pages). 4. Open the natural gas supply to the unit. 5. Push and hold igniter but t urn to create sparks. 6.
PAGE 13
Inspecting CARE AND CLEANING This outdoor fire table must be inspected regularly to ensure that the product is safe to use and to extend product life. WARNING DO NOT INSPECT THIS OUTDOOR FIRE TABLE UNTIL THE FIRE IS COMPLETELY OUT 1. 2. 3. 4. 5. 6. Check the burner to make sure it is securely in place. Check the venturi tube to make sure it is clear and free of inserts, spider nests and other debris. Check all gas connections for leaks. Check ignition system to insure proper sparking.
PAGE 14
GAS COMPONENT CONNECTION CHECKS If the burner will not light or stay lit, please perform the following checks. 1. Make sure the electrode wire is correctly connected. Both elect rode wires must be fully inserted in to the igniter box. 2. Make sure that the pilot housing is unobstructed.
PAGE 15
GAS COMPONENT CONNECTION CHECKS Thermocouple Igniter Pin 3. Make sure that the igniter pin and thermocouple are correctly positioned. - The igniter pin should be pointed straight to the thermocouple. - The thermocouple should be positioned 5mm away from the burner tube. Valve Thermocouple Wire Thermocouple Wire Wire should be in line with valve Igniter Box Valve 4. Make sure that the thermocouple wire is correctly positioned. The thermocouple wire should be in line with the valve. 5.
PAGE 16
TROUBLESHOOTING Problem: Burner will not light using igniter Possible Cause 1: Electrode and burners are wet. - Wipe dry with cloth. Possible Cause 2: Igniter battery is dead. - Check or replace the AAA battery in the igniter. Possible Cause 3: Igniter Pin cracked or broken - sparks at crack - Call Elementi at 909-985-5553 for technical supporting. Possible Cause 4: Wire loose or disconnected. - Reference page 14, step 1, reconnect wire.
PAGE 17
TROUBLESHOOTING Problem: Sudden drop in gas ﬂow, or a reduced ﬂame height Possible Cause 1: Out of gas. - Call your local gas company. Possible Cause 2: Excess ﬂow safety device may have been activated. - Turn control knob to “OFF”, wait 30 seconds and light outdoor ﬁre table. If flames are still too low reset the excessive flow safety device by rutning off the control knob and the gas supply. Disconnect the quick disconnect socket. Turn the burner control knob to “HIGH”. Wait 1 minute.
PAGE 18
WARRANTY Ocean Rock USA LLC doing business as Elementi, warrants Elementi fire features and accessories to be free from defects in parts and workmanship under normal use and service for a period of 1 year from the date of purchase. In the event of such defects Elementi will, at its option, repair or replace the defective product. The foregoing is at the discretion of Elementi.