KitchenAid FREESTANDING For questions ® OUTDOOR GRILL about features, operation/performance, parts, accessories or service, call: 1-877-373-2301 or visit our website at www.Kitchenaidgrills.com P ASADOR Para consultas respecto AUTONOMO a caracteristicas, funcionamiento, rendimiento, piezas, accesorJos o servJcJo t@cnJco, Ilame al: 1-877-373-2301 o vJsJte nuestro sJtio de Jnternet en www.Kitchenaidgrills.com COMFFOIR POUR GRIL D'EXTERIEUR AUTOPORTANT .............
TABLE OF CONTENTS OUTDOOR GRILL SAFETY ................................................................. 3 OUTDOOR GRILL USE ....................................................................... 20 Grill ..................................................................... 20 Using Your Infrared Searing Burner 22 INSTALLATION REQUIREMENTS .................................................... Tools and Parts ......................................................................................
OUTDOOR GRILL SAFETY Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others. All safety messages will follow the safety alert symbol and either the word "DANGER" or "WARNING.
iMPORTANT SAFETY iNSTRUCTiONS WARNING: To reduce the risk of fire, electrical shock, injury to persons, or damage when using the outdoor cooking gas appliance, follow basic precautions, including the following: [] Do not install portable or built-in outdoor cooking gas appliances in or on a recreational vehicle, portable trailer, boat or in any other moving installation.
INSTALLATION Gather the required tools and parts before starting installation. follow the instructions provided with any tools listed here. REQUIREMENTS Read and Tools Needed • Tape measure • Pipe wrench • Small, flat-blade screwdriver • • #2 and #3 Phillips screwdriver Scissors or cutting pliers (to remove tiedowns) • Level • Noncorrosive solution • Wrench or pliers leak- detection Explosion Hazard Do not store fuel tank in a garage or indoors.
iii:_'_i>_iiiii_•:_:_ii_;:_iiil iiiiii?_i_i,ili_iiiiii_i_i_i_•_i_, iiiil),_•i:?_iiii_iiiii,_ii_,_ii_,_iii ¸_(i_iii_'i!!i_ ii:!)_,_;:!_i:i_,!,!!_ii_•i:_ii_i_ii%_ Fire Hazard Do not install grill on or near combustible materials. Doing so can result in death or fire. The enclosure for the built-in outdoor grill is to be a minimum of 11" (28.0 cm) high x 23" (58.4 cm) deep x 36" (91.4 cm) wide.
Theillustration below includes cutout dimensions andminimum spacing requirements. Theillustration isforreference. Thedesign ofyourcabinet layout canbepersonalized, butthedimensions forthecutouts andminimum spacing must befollowed. Center orsupport sur[Sces must belevel. Theinstallation ofthisgrillmust con_brm withlocalcodes or,intheabsence oflocalcodes, witheither theNational FuelGas Code, ANSIZ223.1/ NPFA 54,Natural Gas andPropane Installation Code, CSAB149.1, orPropane Storage andHandling Code, B149.2.
Toensure thatthegrilloperates properly, itisrecommended thatthe island have ventilation onall4sides asshown inthefollowing illustration. Theventilation holes should beasdiagramed toensure adequate ventilation foryourgrillandisland. Natural Gas Conversion Natural Gas Pressure Regulator Location Measurements shown are for attaching the Natural gas pressure regulator to the enclosure. 20 in. 2 (129.0 cm 2) rain. ventilation both sides f/2" 10 in. 2 (64.5 crn2) vain. ventilation both sides \ "--,,2_/;'
Refer tothemodel/serial rating plate forinibrmation onthetype ofgasthatcanbeused. If thisinibrmation does notagree with thetypeofgasavailable, check withyourlocalgassupplier. Any brand of 20 lb LP gas fuel tank is acceptable for use with the grill provided they are compatible with the grill's retenion means (tank tray included). Gas Conversion: The grill is also design-certified by CSA International for local LP gas supply or lbr Natural gas with appropriate conversion.
REPLACEMENT 01 3i 10 PARTS
Part Number Part (description) Warran_ Coverage Quantity Part Number Part 01 Main 3 1 34 02 Main lid screw with screw cover 3 2 03 Temperature gauge 3 1 04 Temperature gauge 1 1 05 Main 1 1 1 1 3 1 1 1 lid lid handle heat insulating 06 Main seat with spacer, lid handle heat insulating 07 Main 08 Rotisserie wire spacer, burner Rear baffle 10 Rotisserie 11 left seat with lid handle 09 housing right tube igniter (description) Warranty Coverage Quanti_
INSTALLATION INSTRUCTIONS Install 20 lb LP Gas Fuel Tank Tray The tank tray should accessed connect Excessive Weight Hazard be secured to a fixed location and will allow the gas pressure to the 20 lb LP gas fuel tank without the gas pressure regulator/hose that can be easily regulator/hose kinking assembly or putting to strain on assembly• Use two or more people to move and install grill. Failure to do so can result in back or other injury. 1.
Grease Cup Bracket Installation Place grill into outdoor enclosure, but leave enough room in the back to 1. connect to the gas supply. Loosen and remove cup bracket. on the grease ///// LP Gas Installation 1. the 4 screws preassembled /. Cheek that the LP gas pressure regulator/hose assembly is positioned under the grill (as shown in the following illustration) and is not pinched or kinked.
NOTE: If grill is to be converted the "Gas Conversions" section. to Natural gas, follow instructions in 20 lb LP Gas Fuel Tank To Connect the 20 lb LP Gas Fuel Tank: 1. Check that the 20 lb LP gas fuel tank is in the "Oft "' position. turn the valve clockwise until it stops. 2. Check that the 20 lb LP gas fuel tank valve has the proper external male thread connections per ANSI Z21.81. 3. Check 4. Remove pressure 5.
GAS CONVERSIONS 5. Gas Connection to Natural Gas Use an adjustable wrench to remove the LP gas pressure hose assembly from the 90 ° brass adapter. regulator/ A Explosion Hazard Use a new CSA International gas supply line. install a shut-off Securely Failure tighten "outdoor" valve. ail gas connections. to do so can result This installation approved must conform C in death, explosion, with local codes or fire. and ordinances. Copies of the standards listed above may be obtained .4.
3. Connect the quick connector on the other end of the 10' (3.0 m) PVC flexible gas supply hose to the rigid Natural gas supply pipe (B). Change Grill Main Burner Valve Orifices 1. Remove the grates and flame tamers. 2. Remove the screw and clip that hold the burner in place. Set the screw and clip aside. Remove the burner from the grill by lifting the burner out. A B A. Brass connector B. Quick connector 3.
2_ Remove the access cover at the back of the grill by removing the 6 screws at the back of firebox. 5_ Take out the orifice support, and then use a 6 mm socket and wrench or 6 mm nut driver to remove the LP orifice at the end of the supply pipe. Replace with Natural gas orifice. A \ \ \ \ \ A A. Orificesupport B. Orifice _. 3_ _CCeSS CO12eF Using a Phillips screwdriver, remove the screw holding the spider guard to the burner. 6. Reinstall the spider guard, access cover, and wind baffle.
3. Remove theinfrared searing main burner fromfirebox. Record Conversion The model/serial number plate is located on the right-hand side of the grill. With a permanent marker, check the box next to "Natural gas" and mark through "LR" In the last page of the Use and Care Guide, write "Converted to Natural Gas." Also record the conversion date and the technician/company that performed the conversion.
5. Remove the screw and clip that hold the burner in place. Remove gas burner from the grill. A Low Flame Adjustment If flame goes out on the "LO" setting, the low flame setting must be adjusted. 1. 2. Turn off the valve and wait until grill and burners are cool. Remove grill grates and flame tamers. 3. Light grill using information in the "Outdoor Grill Use" section. 4. Turn burner to its lowest setting and remove knob. 5.
OUTDOOR GRILL USE This manual covers several different models. The grill you have purchased may have some or all of the features listed. The locations and appearances of the features shown here may not match those of your model, Control Panel I A B A. Left grill burner B. Left center C. Right center grill control knob burner control grill burner control C D D. Right grill burner E.
Prepare the Gas Supply 1. Manually Open the hood completely. Do not light burners with the hood closed. Lighting the Main Grill 1. Do not lean over the grill. 2. Remove the manual lighting extension (see following illustration) and attach a match to the split ring. Turn the Gas Supply On 1. J For outdoor grills using a 20 lb LP gas fuel tank: Slowly open the tank valve. NOTE: If flow limiting device activates, your grill may not light.
4. Gently hold the lit match close to the infrared searing burner. { i%_ _ _..... _ " ___u'+: __i:__°_ __.... >,,_,, _ i¢_, Infrared grillingproduces intense heat which quickly sears themeat. Searing locks inflavorand juices whileallowing theouter surt:ace to absorb smoke andfoodaroma thatisproduced asgrease anddrippings arevaporized bytheburner. Theresult isacrisp, flavorful outside witha tender, juicyinside. • Preheat theinfrared sear burner for5minutes.
Manually Lighting theRotisserie Burner 1. Do not lean over the grill. 2. Remove the manual lighting extension (see following illustration) and attach a match to the split ring. Food Poisoning Hazard Do not let food sit for more than one hour before or after cooking. Doing so can result in food poisoning or sickness. j-/" 3. Strike the match to light it. 4. Gently hold the lit match close to the rotisserie burner.
ROTISSERIE CHART Use a portable Turn off rotisserie than desired minutes • meat thermometer bumer internal before to check intemal when meat thermometer temperature. Continue rotating, doneness reads 5°E/3°C hood closed, lower for 10 Food by weather 4-6 lbs Rib Eye Sirloin Tip Rib, boneless (1.5-2.
• Knobs have High, Medium • Heat settings • Grilling indicated and Low settings for flame adjustment. • When 2 temperatures are listed, for example: Medium to MediumLow, start with the first and adjust based on cooking progress. • Cooking times may vary from chart times depending fuel, Natural or LP gas. are approximate. times are affected FOOD by weather conditions. COOKING BURNER METHOD/ INTERNAL TEMP.
FOOD COOKING BURNER METHOD/ INTERNAL TEMP. SETTING TIME (total SPECIAL INSTRUCTIONS minutes) Fish and Seafood Fillets, Steaks, Chunks Halibut, Salmon, Swordfish, 8 oz (0.25 kg) DIRECT Medium 4-6 per V:" (1.3 cm) thickness of fish Whole, DIRECT 5-7 per side Catfish, Rainbow Trout, 8-11 oz (0.250.34 kg) Shellfish, Scallops, Grill, turning once. Brush grill with oil to keep fish from sticking. Remove when inside is opaque and flaky with skin easily removed.
OUTDOOR GRILL CARE For baked-on soil, prepare a solution of 1 cup (250 mL) ammonia to 1 gal. (3.75 L) water. Soak grates for 20 minutes, then rinse with water and dry completely. If igniters 1. stop sparking, Unscrew the battery igniter button should be replaced. cap counterclockwise to remove. WARMING SHELF Cleaning Method: /7/ " A Remove battery 3. Replace negative with a new alkaline end in first. 4.
2_ Remove the screw and clip that hold the burner in place. Remove gas burner from the grill. INFRARED SEARING BURNER Cleaning Method: 1. 2. Light the infrared searing burner. See the "Using Your Inl_ared Searing Burner" section. Close the grill hood. 3. Leave the burner on high for approximately 4. Turn knob to OFF and let cool completely. 5. Remove the grill grate and brush off ash particles from the sear burner cover plate. 6. Replace the grill grate. GREASE 30 minutes.
flare-ups Excessive TROUBLESHOOTING • Is there excessive Keep flame Grill will not light Keep the hood up when grilling • Is the 20 lb LP gas fuel tank valve turned Turn the 20 lb LP gas fuel tank on. • Is the grill properly connected to the gas supply? Contact a trained repair specialist or see Installation • • fat in the food being on low or turn one bumer off'? Move food to the warming To avoid damage Instructions. Is there gas in the 20 lb LP gas fuel tank? Check the gas level.
LIMITED WARRANTY Nexgrill warrants to the original consumer-purchaser only that this product (Model #740-078!) shall be free from detects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require photographic evidence of damage, or that detective parts be returned, postage and or freight pre-paid by the consumer, for review and examination.
Neither dealers northeretail establishment selling thisproduct hasanyauthority tomake anyadditional warranties ortopromise remedies inaddition toorinconsistent withthose stated above. Manufacturer's maximum liability, inanyevent, shallnotexceed thedocumented purchase priceofthe product paidbytheoriginal consumer. Thiswarranty onlyapplies tounitspurchased fromanauthorized retailer andorre-seller.
