itche FREESTANDING For questions OUTDOOR GRILL about features, operation/performance, parts, accessories or service, call: 1=877=373=2301 or visit our website at www.Kitchenaidgrills.com P ASADOR Para consultas respecto ALrFONOMO PARA EXTERIOR a caracteristicas, funcionamiento, rendimiento, piezas, accesorios o servicio t_cnico, Ilame al: 1-877-373-2301 o visite nuestro sitio de internet en www.Kitchenaidgrills.
TABLE OF CONTENTS OUTDOOR GRILL SAFETY ................................................................. 3 INSTALLATION REQUIREMENTS .................................................... Tools and Parts ........................................................................................ 5 5 Location Requkements ............................................................................ Product Dimensions .................................................................................
OUTDOOR GRILL SAFETY Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others. All safety messages will follow the safety alert symbol and either the word "DANGER" or "WARNING.
iMPORTANT SAFETY iNSTRUCTiONS WARNING: To reduce the risk of fire, electrical shock, injury to persons, or damage when using the outdoor cooking gas appliance, follow basic precautions, including the following: [] Do not install portable or built-in outdoor cooking gas appliances in or on a recreational vehicle, portable trailer, boat or in any other moving installation.
INSTALLATIONREQUIREMENTS ,OCI {/} £©C/),/70/1107(_ Gather the required tools and parts before starting installation. Read and follow the instructions provided with any tools listed here. Tools Needed • 'I@e measure • Small, flat-blade • #2 and #3 Phillips screw driver • Level • Wrench orpliers screw driver • Pipe wrench • Scissors orcutting pliers (to remove tiedowns) • Noncorrosive leakdetection solution Do not store grill with fuel tank in a garage or indoors.
iiii>_o(iiii_i_:::_3i ¸iii)_ii_i_i_i_ii_iiiie_Jii:ii_i_!!_;iiio_iiiiiiii_i_!_; iii}:iii¢_ii!iit-! _i_i_i_i:_i_i_ ()_i_i_iiii)_iiiiiiioo_i_i_i: (ii_iiiii_iii _iiiii}i! i!i!L_iiii_i_i_i_i:::}lioi!!i_i_i_i_i!_i Fire Hazard Do not install grill on or near combustible materials, Doing so can result in death or fire, The enclosure for the built-in outdoor grill is to be a mininqunq of l l" (28.0 cm) high x 23" (58.4 cm) deep x 30" (76.
The illustration bel ow includes cutout dimensions and minimum spacing requirements. The illustration is for reference. The design of your cabinet layout can be personalized, but the dimensions for the cutouts and minimum spacing must be followed. Center or support surfaces must be level. The installation of this grill must conform with local codes or, in the absence of local codes, with either the National Fuel G as Code, ANSI Z223. I/NPI:A 54, Natural Gas and Propane Installation Code, CSA B 149.
]bensure thatthegrilloperates properly, it isrecommended thattheisland have ventilation onall4sides asshown inthe following illustration. Theventilation holes should beas diagrammed toensure adequate ventilation foryourgrilland island. Natural Gas Conversion Natural Gas Pressure Regulator Location Measurements shown are for attaching the Natrual gas pressure regulator to the enclosure. 20 in. 2 (129.0 cm 2) min. ventilation both sides 5" (12.7 cm) max. 11/,'' (3.0 cm) 10 in. 2 (64.5 cm 2) min.
Refer tothemodel/serial rating plate forinfonnation onthetype ofgasthatcallbeused. If thisinformation does notagree with thetypeofgasavailable, check withyourlocalgassupplier. Any brand provided ............................................... r No attempt shall be made to convert the grill from the gas specified on the model/serial rating plate for use with a different gas type without consulting the serving gas supplier. The conversion kit supplied with the grill must be used.
REPLACEMENT O7 06 15 55 'I 3 I0 PARTS
Part Part(description) Number Warranty Coverage Quantity _HHHHHHHHHHHHHHHHHHHHHHHHHHHHHHHHHHHHHHH_HHHHHHHHHHHH 01 Main lid 3 l 02 Main lid screw with screw 3 2 cover module 32 Rotisserie gas valve l l 03 Temperature gauge housing 3 l 33 Main gas valve l 4 04 Temperature gauge l l 34 Igniter junction wire l l 05 Main lid handle seat with heat insulating spacer, left l l 35 Front baffle 3 l 06 Main lid handle seat with heat insulating spacer, right l l 36 Grease
INS INSTRUCTIONS Install 20 lb LP Gas Fuel Tank Tray Excessive The tank tray should be secured accessed and will allow the gas connect to the 20 lb LP gas fuel the gas pressure regulator/hose Weight Hazard Use two or more people to move and install grill. 1. Place the tank tray in a location that can be secured using 4 screws (supplied) through the pmdrilled holes. 2. Use 4 screws to secure Failure to do so can result in back or other injury. 1. Remove base. all packaging 2.
Grease Cup Bracket Installation ! _ii i_i_ :_!!_; _iiil :_i_ii iii !iii _iill iiiiill _i_i ¸_iiiii iiii li̧ Place grill into outdoor connect enclosure, but leave enough room in the back to 1. Loosen and remove the 4 screws preassembled cup bracket. on the grease to the gas supply. // // // // // LP Gas Installation 1. Check that the LP gas pressure regulator/hose assembly is positioned under the grill (as shown in the following illustration) and is not pinched or kinked. 2.
NOTE: If grill is to be converted the "Gas Conversions" section. 20 lb LP Gas Fuel to Natural gas, follow instructions in Tank To Connect the 20 lb LP Gas Fuel Tank: 1. Check that the 20 lb LP gas fuel tank is in the "Off" position. turn the valve clockwise until it stops. 2. Check that the 20 lb LP gas fuel tank valve has the proper extemM male thread connections per ANSI Z21.81. 3. Check 4. Remove pressure 5.
GAS CONVERSIONS 5. Gas Connection to Natural Gas Use an adjustable wrench to remove the LP gas pressure regulator/ hose assembly from the 90° brass adapter. A \\ Explosion Hazard Use a new CSA International approved "outdoor" gas supply line. install a shut-off valve. Securely tighten all gas connections. Failure to do so can result in death, explosion, or fire. This installation must conform with local codes and ordinances.
3. Connect the quick connector on the other end of the l0 fl (3.0 m) PVC flexible gas supply hose to the rigid Natural gas supply pipe (B). ,.... A. Mai_7 bu/vTer orifice IMPOR'IANT: Check that the orifice is properly installed inside of the gas valve. B. Quick comTector 4. Change Grill Main Burner Valve Orifices 1. P,emove the grates and flame tamers. 2. P,emove the screw and clip that hold the burner in place. Set the screw and clip aside.
2, Remove the access cover at the back of the grill by removing screws at the back of firebox. the 6 5. Take out the orifice support, and then use a 6 mm socket and wrench or 6 mm nut driver to remove the LP orifice at the end of the supply pipe. Replace with NaturM gas orifice. A \ \ A. Orifice s'upport B. Orifice IMPORTANT: the supply 3, Using a Phillips guard to the burner. screwdriver, / remove the screw holding Check that the orifice is properly installed inside of pipe.
Theburners aretested andtZactory-set formost efficient operation. However, variations ingassupply andother conditions maymake minor adjustments toairshutter orlowflame setting necessary. It isrecommended thataqualified person make burner adjustments. NOTE: Therotisserie burner cannot beadjusted. If flame is noisy or lifts away from burner (too much air), turn air shutter adjustment screw clockwise. A Checking and adjusting the grill burner flames requires removing the grates and flame tamers. Burner ...
OUTDOOR GRILL USE This manual covers several different models. The grill you have purchased may have some or all of the features listed. The locations and appearances of the features shown here may not match those of your model. Control Panel I A A. L@ grill I I I I B C D E burster co_71ro/ k_7oh B. LeO testier (7. R_ghl testier grill burner co_m'ol grill burster co_m'ol D. Rolivv#ri# km)b E.
Manually Lighting theMainGrill 1. Donotleanoverthegrill. 2. Remove themanual lighting extension (see following illustration) andattach amatch tothesplitring. TurntheGasSupply On 1. Foroutdoor grillsusing a20lbLPgasfueltank: Slowly open thetankvalve. NOTE:If flowlimiting device activates, yourgrillmaynotlight.If yourgrilldoes light,theflames willbelowandwillnotheat properly. Turntankvalve andallcontrol knobs offandwait30 seconds.
5. ARotisserie kitcanbepurchased asanaccessory forthegrill.See "Accessories" inthe"Assistance" section. 'lbavoid damage tothewanning rack, remove fromgrillwhen using the rotisserie burner. Donotusethemainburners when therotisserie burner isinuse. Push in and turn the control knob to IGNITE/ON. Hold this knob in for 10 seconds after the burner is lit. YOUwill hear the "snapping" sound of the spark until after the knob is released. r Lighting the Rotisserie Burner 1. Do not lean over the grill. 2.
ROTISSERIE CHART Useaportable meat thermometer tocheck internal doneness ofthefood. Turnoffrotisserie burner when meat thermometer reads 5°[:/3°C lower than desired internal temperature. Continue rotating, hood closed, forl0 minutes before carving. Timing isaffected byweather conditions such aswindandoutside temperature.
[] Knobs have High, Medium [] Heat settings [] Grilling indicated and Low settings for flame adjustment. [] When 2 temperatures are listed, for example: Medium to MediumLow; start with the first and adjust based on cooking progress. [] Cooking times may vary from chart times depending fuel, Natural or LP gas. are approximate. times are affected FOOD by weather COOKIN BURNER conditions. G METHOD/ SETTING INTERNAL TEMP.
FOOD COOKING METHOD/INTERNAL TEME BURNER SETTING Fillets, Steaks, Chunks DIRECT Halibut, Sahnon, Swordfish, 8 Medium oz (0.25 kg) TIME SPECIAL INSTRUCTIONS (totalminutes) 4-6per Grill,turning once. Brush grillwith V2"(l.3 cm) thickness offish Whole, Catfish, Rainbow 'Dour, 8-l l oz (0.250.34 kg) DIRECT High 5-7 per side Shellfish, Scallops, Shrimp DIRECT Medium 4-8 oil to keep fish from sticking. Remove when inside is opaque and flaky with skin easily removed.
(iiii:_ _i' ill_iil),(i )( )!_, ii;iiill ,(i¸i;i}fill )!ii,i!, (iii_ik };ili!llii!_ill GRILL i!.ii!i _ii_!!@ _%::_iii_i _i_ i_i_iii_i ii;iii_ii_ii,e !iiiiil;ii_ii_ iiiiiii)ii;_e!iii ,_[!:!L_:ii_ ii:_ii;o _i_ii_:? _ If igniters 1. stop sparking, Unscrew igniter the battery button should be replaced. cap counterclockwise GRATES IMPOII_I'ANT: "1_ avoid damage to grill grates, do not use a steel or fiber scraper, hnmediately after you are finished cooking, loosen food soil with a brass bristle brush.
ROTISSIERE BURNERS Cleaning Method: [] Clean the exterior of the burner with a wire brush. [] Clear any clogged burner ports with a straightened paper clip. [] Do not use a toothpick as it may break off and clog the port. [] Check and clean burner/venturi tubes. 1. 2. Remove grill grates and flame tamers. Remove the screw and clip that hold the burner in place. Remove gas burner from the grill. Cleaning BURNER Method: 1. Light the rotisserie burner.
Low heat TROUBLESHOOTING LP Gas: For outdoor grills using a 20 lb LP gas fuel tank, slowly open the tank valve. Grill will not light NOTE: If flow limiting device activates, your grill may not light. If your grill does light, the flames will be low and will not heat properly. 1. Turn tank valve and all control knobs offand wait 30 seconds. [] Is the 20 lb LP gas fuel tank valve turned Turn the 20 lb LP gas fuel tank on.
LIMITED WARRANTY Nexgrill warrants to the original consumer-purchaser only that this product (Model #740-0780) shall be flee from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require photographic evidence of damage, or that defective parts be returned, postage and or freight pre-paid by the consumer, for review and examination.
Neither dealers northeretailestablishment selling thisproduct hasanyauthority tomake anyadditional walTanties ortopromise remedies inaddition toorinconsistent withthose stated above. Manut:acturer's maximum liability, inanyevent, shallnotexceed thedocumented purchase priceofthe product paidbytheoriginal consumer. Thiswarranty onlyapplies tounits purchased fromanauthorized retailer andorre-seller.