Installation Instructions for all PS-SWMCP swivel fixtures for round pipes PIPE MOUNTING FIXTURES (SWIVEL) FOR PS650-VEX™ ENCLOSED SPEAKER SYSTEMS
Slide an M6 x 16 mm Machine Screw through the center hole of the clamp receiver and into the center hole in the pre-installed fixture base. Hand-tighten, allowing just enough freedom for the enclosure to spin. Place the supplied plastic strip around the pipe to prevent scratching. Push the clamps over the pipe (remove the plastic strip). Align the clamps with the clamp receiver on the enclosure. Secure the clamps to the clamp receiver using a pair of M6 x 45 mm Machine Screws, M6 Flat Washers, and ,\16 Lo
Apply Loctite• red thread-locking compound to two M6 x 16 mm Machine Screws, slide them through the slots in the clamp receiver, into the appropriate holes in the fixture base, and fully tighten. Remove the center M6 x 16 mrn Machine Screw from the clamp receiver, apply Loctite" red thread-locking compound, reinstall, and fully tighten.
If you wish to rotate the speaker's grille/logo badge alignment, remove the six #8 x 1- l/4" speaker mounting screws and #8 Flat Washers. Rotate the speaker to the desired angle. Reinstall the speaker and speaker mounting screws and washers. Hand-tighten in a criss-cross pattern. ~ ::::.= ::,........ ....... For best adhesion, it is recommended to clean the inside of the aJuminum cap v.ith acetone (not included) prior to attaching it to the enclosure.
For LED Models Only: q~Biue 'VO Example: One speaker pair of LED circuits connected in parallel. Yellow-+-. q~Biue 'VO Yellow--... q~Biue 'VO Yellow-•-. q~Biue 'VO Yellow-+. . Example: Two speaker pairs of LED circuits connected in parallel. II ~-Blue Yellow--.. • For marine installations, do not connect the speaker's LED lights to the vessel's navigational lighting circuits.
Included Hardware: (hardware pictured for one) .. .~ ; I : ---- - - -························· .........~ ..............
BOM ID Quantity <4·.·.. ·:·:.··.· ·•· ·i · T< Description ··:. i ,··· ..... ···················2··············· --~··········:t···:······ ..... ·····: 6... .............. o: •• Axia Alloys Strap Clamp -~16 ~ 16 ~1~~ s~~k~·t· c:~p M~~hi11~ sc~~~ J . .... r: ';,' ~~~;;;;'<,;:, !·';'·:~':;,~:;·,;' ;' ~'!·· · · · · · · · · · · .................. s~;;~j.g~~:;e·· · .. ...····•··· ···· · ··· ......... .....·•·· ......... t·:,.,.; .......,,...,..,... 'tj~-,···· ··' , ,,, ...,,,,,...,.,.,.:······-,,.
LIMITED WARRANTY- MARINE PRODUCTS (USA) JL AUDIO warrants this product to be free of defects in materials and workmanship for a period of two (2) years from the original date of purchase. This warranty is not transferable and applies only to the original purchaser from an authorized JL AUDIO dealer.