Our Ideas. Your Home Instructions for Installation and Use 50cm Free Standing Eye-level Gas Cooker Alkaline AA HL500G NOTE: This appliance is fitted with a battery powered ignition system (the battery provided). Sholud the ignition system start to spark slowly - or not at all, the battery will need replacing. See the section on battery replacement. To the Installer Before installation fill in the product details on the back cover this book. The information can be found on the rating plate.
Contents Introduction 3 Installation Installation of Eye-Level Grill 4 8 Burner and Nozzle Specifications 10 Safety Information Features 11 13 Control Panel 14 Use of hotplates Grilling 15 16 Oven 17 Oven cooking charts Care and Cleaning / Battery Replacement 18 19 Cooking Results Not Satisfactory? 20 Something Wrong With Your Cooker? Technical Characteristics 21 22 After Sales Service 26 Hotpoint Guarantee Key Contacts 27 Back Cover You must read these instructions prior to using y
Introduction Your new appliance is guaranteed* and will give lasting service. This guarantee is only applicable if the appliance has been installed in accordance with the installation instructions detailed in this booklet. To help make best use of your cooking equipment, please read this booklet carefully. The cooker is designed specifically for domestic use and responsibility will not be accepted for use in any other installation.
Installation The appliance must only be installed by a competent person. In the UK, CORGI registered installers undertake to work to safe and satisfactory standards. Before moving your cooker check that it is cool, and switch off at the cooker control unit. Splashplate optional, apply to Parts Department (see Back Cover for contact number.
Gas connection The cooker should be connected to the gas-supply by a corgi registered installer. During installation of this product it is essential to fit an approved gas tap to isolate the supply from the appliance for the convenience of any subsequent removal or servicing. Connection of the appliance to the gas mains or liquid gas must be carried out according to the prescribed regulation in force, and only after it is ascertained that it is adaptable to the type of gas to be used.
• (see table 1 “Burner and nozzle characteristics”). replace all the components by repeating the steps in reverse order. c) Minimum regulation of the hob burners: • turn the tap to minimum; • remove the knob and adjust the regulation screw, which is positioned in or next to the tap pin, until the flame is small but steady. N.B.: in the case of liquid gas, the regulation screw must be screwed in to the bottom. • check that the flame does not turn off when you turn the tap quickly from high to low.
• regulate the screw positioned outside the thermostat pin until the flame is small but steady. N.B.: in the case of liquid gas, the regulation screw must be screwed in to the bottom. • check that the burner does not turn off when you turn the knob from Max to Min and and when you open and close the oven door quickly.
Installation of Eye-Level Grill 1. 2. Unpack the product. Unscrew the lid which protects the gas supply connection attachment for the Grill. 3. Remove the rear cover protecting the Grill assembly, which is fixed in place with 6 screws (see photograph). 4. Join the Grill assembly to the cooker. To do this, it will be necessary to "jump" the gas attachment by folding the Grill assembly to 45° (see photograph). 5.
6. Join the Grill hose attachment to the cooker attachment (using a torque wrench setting of 11±2 Nm). 7. Connect the appliance electrically using the fastons on the rear part of the cooker (it makes no difference in which order these are connected). 8. Replace the rear cover and fix it in place using the same screws (6) as removed previously in step 3 of this procedure.
Burner and Nozzle Specifications Table 1 Liquid Gas Burner Diameter (mm) Thermal Power Thermal Power By-Pass Nozzle kW (p.c.s.*) kW (p.c.s.*) 1/100 1/100 Natural Gas Flow* g/h Thermal Power Nozzle kW (p.c.s.
Safety Information When used properly your appliance is completely safe but as with any electrical product there are certain precautions that must be observed. PLEASE READ THE PRECAUTIONS BELOW BEFORE USING YOUR APPLIANCE. Always l Remove all packing from inside the oven and grill compartments before switching on for the first time. l Understand the controls prior to using the appliance. l Keep children away from the appliance when grilling as the surfaces will get extremely hot during and after use.
Safety Information Never l Never line the interior of the oven with foil as this may cause the appliance to overheat. l Never leave children unsupervised where a cooking appliance is installed as all surfaces will be hot during and after its use. l Do not allow children or persons who are not familiar with the appliance to use it, without supervision. l Never allow anyone to sit or stand on any part of the appliance. l Never store items above the appliance that children may attempt to reach.
Features GRILL EYE-LEVEL GRILL/MEAT PAN WITH HANDLE AND WIRE FOOD SUPPORT 1900W 1900W 3000W 1000W CONTROL PANEL OVEN DRAWER ADJUSTABLE FEET 13
Control Panel ELECTRONIC IGNITION BUTTON OVEN Control Knobs for the gas burners GRILL LEFT FRONT BURNER LEFT REAR BURNER RIGHT REAR BURNER RIGHT FRONT BURNER The position of the gas burner controlled by each one of the knobs is shown by a solid ring •. To light one of the burners, hold a lighted match or lighter near the burner and, at the same time, press down and turn the corresponding knob counter clockwise to the maximum setting.
Use of Hotplates Practical Advice on Using the Burners To use the burners as efficiently as possible, some basic guidelines should be followed: • Use cookware that is the right size for each burner (see table) in order to prevent the flame from spreading beyond the bottom of the cookware. • Only use cookware with flat bottoms. • As soon as the boiling point is reached, turn the knob to the lowest setting. • Always use lids with pots and pans.
Grilling CAUTION: ACCESSIBLE PARTS WILL BECOME HOT WHEN THE GRILL IS USED - CHILDREN SHOULD BE KEPT AWAY. To operate the grill proceed as follows: l Press the ignition button and then push in and turn the grill control knob anti-clockwise to the large flame symbol. Continue to press the ignition button until the spark lights the gas. Grill Pan Handle l Only turn the control knob between the large flame symbol and the small flame symbol for adjusting the setting.
Oven The oven has different heat zones - the thermostat settings refer to the temperature on the middle shelf; above this shelf it is hotter and below it is cooler. Two shelves enable full use of the temperatures inside the oven. Each shelf has a safety stop to prevent if from being pulled out too far when attending to food. Shelves are removed from the oven by pulling them out to the stop and then lifting them at the front to withdraw. The grill pan without the handle can be used in the oven.
Oven Cooking Chart The following times and setting are for guidance only. You may wish to alter the setting to give a result more to your satisfaction. When a different setting to that shown below is given in a recipe, the recipe instructions should be followed. Allow 15 minutes preheat for best results. Always turn the thermostat knob to Mark 9 before selecting the appropriate gas Mark. Shelf position 1 is the highest. Food Gas Mark Shelf Position Approx.
Care and Cleaning Grill Remove the grill pan and the wire grid food support, it is best to wash these items immediately after use to prevent stains from being burnt on when used again. Wipe out the Grill compartment, use a fine steel wool soap pad to remove stubborn stains from the grill runners and the floor of the compartment. Wipe over the control panel with a damp cloth and polish with a dry cloth.
Cooking Results Not Satisfactory? Problem Check Grilling Uneven cooking front to Ensure that the grill pan is positioned centrally below the grill element. back 20 Fat splattering Ensure that the grill is not set to too high a temperature. Oven Baking Uneven rising of cake Ensure that the oven shelves are level by using a spirit level on the rod shelf and adjusting, using suitable packing e.g. wood, under the feet of the appliance. This should be checked both left to right and front to back.
Something Wrong with your Cooker? Before contacting your nearest Service Centre/Installer, check the problem guide below; there may be nothing wrong with your cooker. Problem Ignition does not work Oven Cavity Oven Burner Check If all burners fail to ignite: Check that sparks appear at the burners; A clicking noise should be heard. If not Check that the plug is plugged in to a 13amp Electric socket and the supply is switched on.
Technical Characteristics Main Oven Dimensions (HxWxD): 34x37,5x31 cm Volume: 40 Litres Battery 1.5V Alkaline AA Burners: Adaptable for use with all the types of gas indicated on the data plate. This appliance conforms with the following European Economic Community directives: - 90/396/EEC of 29/06/90 (Gas) and subsequent modifications (only for models which use gas); - 93/68/EEC of 22/07/93 and subsequent modifications.
After Sales Service "No company is better positioned to offer an after sales service on a Hotpoint appliance than us - the manufacturer" As part of our commitment to you, all Hotpoint appliances have the added benefit of a fully inclusive parts and labour guarantee for the first 12 months. In addition to this you also have the advantage of free replacement parts for the first 5 years when fitted by a Hotpoint engineer.
Guarantee "Satisfaction guaranteed or your money back" We give you a unique 'satisfaction guaranteed' promise - valid for 90 days - after you have purchased your Hotpoint appliance. If there is a technical problem simply call Hotpoint Repair service or visit our web-site at www.theservicecentre.co.uk and where necessary, we will arrange for an engineer to call. If the technical problem is not resolved under this guarantee, we will replace your machine or, if you prefer, give you your money back.
Key Contacts After Sales Service Over 1200 trained specialists, directly employed by us, ensure that you can have complete confidence in both the appliances and services we offer. Repair Service and Information Desk UK: 08709 066 066 (Open 8 to 8 Mon - Fri, 8 to 6 Sat, 10 to 4 Sun & Bank Holidays) www.theservicecentre.co.