Honeywell OWNER'SGUIDE F50Fand F300E Electronic Air Cleaners ® U.S.
F50F AND F3OOE ELECTRONIC AIR CLEANERS CONTENTS Operating Getting Your the Most from Maintaining How Electronic Electronic Before Air Cleaner Your Electronic Prefilter(s), Air Cleaning 3 Air Cleaner Cell(s) and Postfilter(s) Works 10-Year Limited Five-year Product Registration 2 UltraClean Warranty 4 6 11 You Call for Service Honeywell 69-0756-4 Electronic 14 Coil Guarantee TM 15 16 17
F50F AND F3OOE ELECTRONIC AIR CLEANERS OPERATINGYOUR ELECTRONICAIR CLEANER Turn the On-Off NOTE: M3584 switch on the power box to On. Set the switch to 1 for On and set the switch to O for Off. The air cleaner now conditioning system benefit and cleaner switch turned on at operates whenever your furnace/air fan operates. For maximum air cleaning air conditioner coils, leave the air cleaner all times and the thermostat fan switch set to On.
F50F AND F3OOE ELECTRONIC AIR CLEANERS GETTINGTHE MOST FROMYOUR ELECTRONICAIR CLEANER Run the electronic air cleaner as much as possible For greatest efficiency, the air do this, set the Fan switch on sure the air cleaner is turned even when the furnace or air NOTE: cleaner should run all the time. To your thermostat to On, and make on. The fan and air cleaner run conditioner is off. A manual fan switch may be built into the furnace furnace fan controller.
F50F AND F3OOE ELECTRONIC If you have a humidifier All Honeywell whole house humidifiers with the Honeywell Electronic filters or system modification. AIR CLEANERS can be used in a system Air Cleaner without any additional If your system includes an atomizing humidifier, you may want to install a standard furnace filter between the humidifier and the air cleaner.This filter would keep the humidifier spray mineral deposits from collecting on the air cleaner.
F50F AND F3OOE ELECTRONIC AIR CLEANERS CLEANING PREFILTER(S), CELL(S) AND POSTFILTER(S) CAUTION Sharp edges. Can cause personal injury. Carefully handle cell(s) or wear protective avoid cuts from sharp metal edges. Setting a regular cleaning schedule gloves to To ensure optimum performance from the air cleaner, the prefilter(s) and cell(s) must be cleaned regularly--the prefilter(s) should be cleaned every one to six months and the cell(s) every six to twelve months.
F50F AND F3OOE ELECTRONIC Cleaning the prefilter(s) Vacuum the prefilter with a brush attachment, hose, or soak it in a tub. Do notwash dishwasher or car wash. AIR CLEANERS rinse it with a the prefilter(s) in the CAUTION Burn Hazard. Can cause personal injury. Allow cell(s) to cool completely in dishwasher tend of wash cycle or wear protective gloves. Washing the cell(s) in your automatic dishwasher Hot water plates.
F50F AND F3OOE ELECTRONIC Step 2 Using AIR CLEANERS your regular dishwashing detergent, allow the dishwasher to run through the complete wash and rinse cycle. Do not use the dry cycle. To avoid burns, let the cell(s) cool completely before removing, or wear protective gloves when removing the cell(s). Remember that water may be trapped inside the cell(s) Step 3 Step 4 plates.
F50F AND F3OOE ELECTRONIC Step 3 AIR CLEANERS After the detergent has completely dissolved, place the cell(s) the container and allow to soak for 15 to 20 minutes or until in water cools. Agitate them up and down a few times and remove. Repeat steps 2 and 3, if necessary, for very dirty cells. Step 4 Step 5 Step 6 Step 7 Maintainingthe postfilter Next, wash the prefilter(s) wash container. the same way.
F50F AND F3OOE ELECTRONIC AIR CLEANERS Replacing electronic air cleaner components Step t Step 2 Step 3 Step 4 Step 5 inspect the cell(s) plates. Repair, Slide the prefilter(s) ionizer wires or call your into the upstream and bent collector contractor prefilter Firmly close the access for service. guides. Slide the air cleaner cell(s) in so the air flow arrow downstream and the handle(s) face outward. points door.
F50F AND F3OOE ELECTRONIC AIR CLEANERS HOW ELECTRONICAIR CLEANINGWORKS A word about particle size The particles removed by the electronic air cleaner tend to be very small--less than ten microns. But what is a ten-micron particle? The eye of an average size sewing needle is about 750 microns across, and the dot in the i in the word micron is about 400 microns. Generally, particles smaller than ten microns can be seen only with a microscope, except in very large concentrations, such as a puff of smoke.
F50F AND F3OOE ELECTRONIC AIR CLEANERS opposite electric charge.The precharged postfilter continues remove small particles from the air. The air leaving the air cleaner contains very few particles. to /POSTFILTER i._> -------> DIRTY AIR --------_CLEANER AIR OUT a IONIZER WIRES (CHARGING SECTION) COLLECTOR (COLLECTOR PLATES SECTION) M6030A Each time the air circulates through the heating/air conditioning system and air cleaner, more particles are removed.
F50F AND F3OOE ELECTRONIC Ozone and the electronic air cleaner Electronic air cleaners generate person CLEANERS a very small amount about 0.005 to 0.010 parts per million highest when the air cleaner is new. The average AIR (ppm). of ozone, The amount can detect the odor of ozone is in concentrations as low as 0.003 to 0.010 ppm. The U.S. Food and Drug Administration, and Health and Welfare Canada recommend that indoor ozone concentration should not exceed 0.050 ppm.
F50F AND F3OOE ELECTRONIC AIR CLEANERS BEFOREYOU CALL FOR SERVICE If... Then... Electronic air cleaner doesn't 1. seem 2. to be working Arcing (snapping) seems too frequent You smell ozone and find it blower If the electronic cell(s) are wet from washing, cleaner off for two to three hours. 2. Check the cell(s) for broken Repair if necessary. Wash cell(s) and prefilter(s) 1. 2. 3. 4.
F50F AND F3OOE ELECTRONIC AIR CLEANERS HONEYWELL t 0 YEAR UltraClean COil GUARANTEETM Guarantee Send to: Honeywell UltraClean 10 Year Co8 Guarantee Customer Care, MN10-1461 1885 Douglas Drive North Golden Valley, MN 55422 If you properly maintain your new Honeywell Electronic Air Cleaner (EAC), Honeywell guarantees that if your indoor coil requires cleaning within the next 10 years, Honeywell will pay to have it professionally cleaned by a qualified contractor: -- 75% of the cost (up to $150) when i
F50F AND F3OOE ELECTRONIC AIR CLEANERS LIMITED FIVE-YEARWARRANTY Honeywell warrants this product to be free from defects in the workmanship or materiaIs, under normat use and service, for a period of five (5) years from the date of purchase by the consumer If, at any time during the warranty period, the product is defective or maIfunctions, Honeywell shaII repair or replace it (at HoneywelI's option) within a reasonable period of time.
F50F AND F3OOE ELECTRONIC AIR CLEANERS Product Registration (Register 1. Mr Mrs First Name: online Ms @ www.honeywell.com/yourhome) Miss initial: Last Name: Address (Number and Street): Zip or Postal Code City:. email Address: 2. Phone Apt:. State/Province: Number: 3. Date of Purchase Purchase Price: $. (month/day/year) ex: January/18/98: (excluding tax) 4. Where did you purchase this Honeywell product: Heating/cooling contractor Utility company Builder/came with new home Other 5.
F50F AND 69-0756-4 F3OOE ELECTRONIC AIR CLEANERS 18
F50F AND F3OOE ELECTRONIC 19 AIR CLEANERS 69-0756-4
F50F AND F3OOE ELECTRONIC AIR CLEANERS Honeywell t0 Year UltraClean Coil Guarantee TM Your Name Street Add tess City. Phone: email State Evening. Day. Date you moved in (for new home). Please check UItraClean Coil Guarantee details for explanation): C3 UltraClean Coil Guarantee TM. C3 Clean Coil Guarantee TM. Your heating/cooling Street Address: contractor City.