Submittal Sheet
50014157-001 400-410-001-B 3/23/06 1/1
1. Introduction
The 50014157-001 temperature sensor is designed for use with Honeywell’s
TB6980/TB7980 thermostats to measure the temperature inside an air duct
or air chamber. It can be also used in various other applications.
2. Technical Specifications
Temperature range: -70 to 120°C (-94 to 248°F)
Output signal: resistive
Sensing device: thermistor (10 kΩ @ 25°C or 77°F)
Cable length: 3 m (10 ft)
3. Installation
• Use twisted pair cable for the sensor connection.
• The maximum allowable distance between the sensor and the thermostat
is 50 feet (15 m).
• The sensor must be installed so the reading hole is facing the air flow
direction.
n Drill a 19-mm (0.75-in.) hole for inserting the sensor.
o Install the sensor using # 12 self-tapping screws.
p Wire the sensor to the thermostat (no polarity).
NOTE: Do not submerge in liquid.
4. Warranty
Honeywell warrants this product, excluding battery, to be free from defects in the
workmanship or materials, under normal use and service, for a period of one (1) year
from the date of purchase by the consumer. If at any time during the warranty period the
product is determined to be defective or malfunctions, Honeywell shall repair or replace
it (at Honeywell's option).
If the product is defective,
(i) return it, with a bill of sale or other dated proof of purchase, to the place from
which you purchased it, or
(ii) call Honeywell Customer Care at 1-800-468-1502. Customer Care will make the
determination whether the product should be returned to the following address:
Honeywell Return Goods, Dock 4 MN10-3860, 1885 Douglas Dr N, Golden
Valley, MN 55422, or whether a replacement product can be sent to you.
This warranty does not cover removal or reinstallation costs. This warranty shall not
apply if it is shown by Honeywell that the defect or malfunction was caused by damage
which occurred while the product was in the possession of a consumer.
Honeywell's sole responsibility shall be to repair or replace the product within the terms
stated above. HONEYWELL SHALL NOT BE LIABLE FOR ANY LOSS OR DAMAGE
OF ANY KIND, INCLUDING ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES
RESULTING, DIRECTLY OR INDIRECTLY, FROM ANY BREACH OF ANY
WARRANTY, EXPRESS OR IMPLIED, OR ANY OTHER FAILURE OF THIS
PRODUCT. Some states do not allow the exclusion or limitation of incidental or
consequential damages, so this limitation may not apply to you.
THIS WARRANTY IS THE ONLY EXPRESS WARRANTY HONEYWELL MAKES ON
THIS PRODUCT. THE DURATION OF ANY IMPLIED WARRANTIES, INCLUDING
THE WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE, IS HEREBY LIMITED TO THE ONE-YEAR DURATION OF THIS
WARRANTY. Some states do not allow limitations on how long an implied warranty
lasts, so the above limitation may not apply to you.
This warranty gives you specific legal rights, and you may have other rights which vary
from state to state.
If you have any questions concerning this warranty, please write Honeywell Customer
Relations, 1985 Douglas Dr, Golden Valley, MN 55422 or call 1-800-468-1502. In
Canada, write Retail Products ON15-02H, Honeywell Limited/Honeywell Limitée, 35
Dynamic Drive, Scarborough, Ontario M1V4Z9.
5. Service
If you have any questions about the operation of your thermostat,
please go to http://customer.honeywell.com, or call Honeywell
technical hotline at 1-763-954-6464.
°C Ω °F °C Ω °F
120 388 248 20 12 493 68
115 444 239 15 15 714 59
110 510 230 10 19 903 50
105 587 221 5 25 395 41
100 678 212 0 32 651 32
95 787 203 -5 42 317 23
90 916 194 -10 55 304 14
85 1 070 185 -15 72 911 5
80 1 256 176 -20 97 007 -4
75 1 480 167 -25 130 308 -13
70 1 752 158 -30 176 805 -22
65 2 082 149 -35 242 430 -31
60 2 487 140 -40 336 103 -40
55 2 985 131 -45 471 401 -49
50 3 601 122 -50 669 262 -58
45 4 367 113 -55 962 410 -67
40 5 325 104 -60 1 402 728 -76
35 6 530 95 -65 2 073 705 -85
30 8 056 86 -70 3 111 810 -94
25 10 000 77
-70
-50
-30
-10
10
30
50
70
90
110
100 1000 10000 100000 1000000 10000000
-94
-58
-22
14
50
86
122
158
194
230
Ω
°C
°F
Resistance Curve
Note: Dimensions are expressed in INCHES [MM]
50014157-001
Duct Temperature Sensor