Item #1007 497 520/1007 497 524 1007 497 521/1007 497 559 Model # 23101FP/23102FP USE AND CARE GUIDE RUTHERFORD 30 IN. SQUARE LOW PROFILE STEEL GAS FIRE PIT WITH TANK HOLDER SIDE TABLE Questions, problems, missing parts? Before returning to the store, call Home Decorators Collection Customer Service 8 a.m. - 7 p.m., EST, Monday – Friday, 9 a.m. – 6 p.m., EST, Saturday 1-800-986-3460 HOMEDEPOT.
Table of Contents Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 About propane (LP) gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Pre-assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Specifications . . . . . . . . . . . . . . . .
Safety Information (continued) WARNING: Use factory approved replacement parts and accessories only. Use of unapproved parts or accessories can void the warranty on this product and result in a hazardous condition. Please contact us for information regarding replacement hoses, electrodes, ignition modules, fire glasss, logs, etc. The installation must conform with local codes or, in the absence of local codes, with the National Fuel Gas Code,ANSI Z223.
Safety Information (continued) Before each use of this gas appliance, open the LP (liquid propane) tank drawer and inspect the LP hose. If there is evidence of excessive abrasion or wear, or the hose is cut, it must be replaced prior to the gas appliance being put into operation. Use only the replacement hose assembly specified in this manual. Inspect the burner before each use of the appliance.
Safety Information (continued) WARNING: Fuels used in liquefied propane gas appliances, and the products of combustion of such fuels, can expose you to chemicals including benzene, which is known to the State of California to cause cancer and cause birth defects or other reproductive harm. For more information go to: www.p65warnings.ca.gov.
Pre-assembly SPECIFICATIONS INPUT 50,000 Btu/hr Propane Regulator Pressure 11 inches water column Clearances to combustible surfaces Sides: 24in./61cm 30,000 Btu/hr Low fire Top: 60 in. / 152 cm PLANNING ASSEMBLY NOTE: Read all instructions before assembly. To avoid damaging this product, assemble it on a soft, non-abrasive surface such as carpet or cardboard. NOTE: More than one person may be required to assemble this product.
Assembly 1 Installing and using the gas tank □ Connect the gas hose from the fire pit (A) to the LP gas cylinder. Hand tighten clockwise only. □ To disconnect the gas hose from LP gas cylinder, loosen the connector by turning counterclockwise by hand. □ Position the LP gas cylinder (not included) in the gas tank base (E) and fasten with an adjusting screw. A E 7 HOMEDEPOT.COM/HOMEDECORATORS Please contact 1-800-986-3460 for further assistance.
Assembly (continued) 2 Inserting battery □ Open the battery cap on the control panel and install one AAA battery (not included). NOTE: Only one battery is needed. 3 Putting in the fire glass □ Add fire glass (D) to the fire bowl. NOTE: Maximum recommended amount of fire glass (D) for use in the fire bowl is 4~4.5 kg.
Assembly (continued) 4 Placing the lid □ Place the lid (C) on the top of the fire bowl to complete the assembly. C 5 Covering the gas tank with the side table □ Place the side table (B) on top of the LP gas cylinder and gas tank base (E) to conceal it. CAUTION: Keep the gas tank fixed in the tank base. B WARNING: Hose is a trip hazard. E 9 HOMEDEPOT.COM/HOMEDECORATORS Please contact 1-800-986-3460 for further assistance.
Operation BEFORE LIGHTING Fire pit should be thoroughly inspected before each use and by a qualified service person at least annually. If relighting a hot fire pit, always wait at least 5 minutes. Inspect the hose assembly for evidence of excessive abrasion, cuts, or wear. Suspected areas should be leak tested. If the hose leaks, it must be replaced pri or to operation. Only use the replacement hose assembly specified by manufacturer.
Operation(continued) CAUTION: The gas supply must be turned off at the LP gas supply cylinder when this appliance is not in use. Leak Check WARNING: Perform all leak tests outdoors. Extinguish all open flames. NEVER leak test when smoking. Do not use the fire pit until all connections have been leak tested and confirmed no leakage. Hose / Regulator connection □ □ □ □ □ Regulator / Cylinder connection Make 2-3 oz. of leak check solution (one part liquid dishwashing detergent and three parts water).
Questions, problems, missing parts? Before returning to the store, call Home Decorators Collection Customer Service 8 a.m. – 7 p.m., EST, Monday – Friday, 9 a.m. – 6 p.m., EST, Saturday 1-800-986-3460 HOMEDEPOT.COM/HOMEDECORATORS Retain this manual for future use. Master No.
