OUTDOOR COOKING Outdoor Side Burner AEB Use & Care Manual Installation & Operation
Message from Aspire by Hestan: EN Outdoor cooking is a perfectionist’s pursuit, and with your new investment, you’ve now taken the ultimate step forward. We sincerely welcome you to the Aspire by Hestan Family. We’ve engineered and built our products so that your guests will rave about your meal, but deep down, our customers know it could’ve been just a little more tender, juicier – a pinch more salt in the rub or a few seconds less on the flame.
DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. EN DANGER 1. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
TABLE OF CONTENTS EN 3 MODEL NUMBERS 4 RATING LABELS 4 PRECAUTIONS 7 REGULATORY / CODE REQUIREMENTS 7 PORTABLE LP CYLINDERS 8 LOCATION AND ASSEMBLY 8 INSTALLATION 11 GAS AND ELECTRICAL CONNECTIONS 18 LIGHTING INSTRUCTIONS 19 USING YOUR SIDE BURNER 19 CLEANING AND MAINTENANCE 22 TROUBLESHOOTING 23 WIRING SCHEMATICS 27 PARTS LIST 27 SERVICE 27 WARRANTY MODEL NUMBERS AEB122 AEB121 BUILT-IN MODELS 3 Model No.
RATING LABEL The rating label contains important information about your appliance such as the model and serial number, gas type and manifold pressure, the BTU rating for each burner type, and the minimum installation clearances. EN Outdoor Side Burner rating label is located on the inside rear wall of the unit, behind the control panel. PRECAUTIONS - BEFORE YOU USE YOUR SIDE BURNER When properly cared for, your Aspire side burner will provide safe, reliable service for many years.
PRECAUTIONS - BEFORE YOU USE YOUR SIDE BURNER (continued) 10. Portable LP cylinders - Always shut off the main valve on the liquid propane (LP) cylinder after each use. Never use a dented or rusted LP cylinder. Never attach or disconnect an LP cylinder, or move or alter gas fittings when the side burner is in operation or is hot. EN 11. Inspect LP gas supply hose prior to each use of the side burner. The hose must be kept away from heated areas of the side burner.
PRECAUTIONS - BEFORE YOU USE YOUR SIDE BURNER (continued) 24. Grease is extremely flammable. Let hot grease cool before attempting to handle or dispose of it. Avoid letting excessive grease deposits collect by cleaning the burner bowl often. Never clean while the side burner is on, or hot from recent use. EN 25. Cooking excessively fatty meats and oils will cause flare-ups or grease fires.
REGULATORY / CODE REQUIREMENTS Installation of this cooking appliance must be made in accordance with local codes. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code ANSI Z223.1/ NFPA 54, Natural Gas and Propane Installation code CSA B149.1, or Propane Storage and Handling Code B149.2.
LOCATING AND ASSEMBLING THE SIDE BURNER When determining a suitable location for your side burner, take into account concerns such as exposure to wind, rain, sprinklers, proximity to traffic paths, and keeping any gas supply line runs as short as possible. EN Locate the side burner only in a well-ventilated area. Never locate the side burner in a building, garage, breezeway, shed or other such enclosed areas without an approved ventilation system.
INSTALLATION (continued) enough to burn. Examples of other combustible materials are compressed wood, plant fibers (bamboo), vinyl/plastic, or other materials capable of being ignited and burned. Materials that are flame-proofed or treated with flame-retardant are still considered combustible. EN VENTILATION OPENINGS A minimum of three 10 in² (65 cm²) of ventilation openings must be provided for both left and right sides of your enclosure (island), as well as the back.
INSTALLATION (continued) BUILT-IN DIMENSIONS (COMBUSTIBLE): EN ©2018 Hestan Commercial Corporation 10
GAS AND ELECTRICAL CONNECTIONS GAS SUPPLY EN The local gas authority or supplier should be consulted at the installation planning stage in order to establish the availability of an adequate supply of gas (NG or LP). If it is a new installation, have the gas authorities or supplier check the meter size and piping to assure that the unit is supplied with the necessary amount of gas supply and pressure to operate the unit(s).
GAS AND ELECTRICAL CONNECTIONS (continued) GAS CONNECTION - NATURAL GAS (NG) NOTE: To ensure proper heating performance of this appliance, verify that the gas line supply pressure is adequate. Use only the gas pressure regulator supplied with this appliance. This regulator is set for a supply pressure of 7 inch WC (1.74 kPa) to maintain 4 inch WC (1.00 kPa) outlet (manifold) pressure. Use a minimum 1/2” ID flex hose to prevent gas starvation.
GAS AND ELECTRICAL CONNECTIONS (continued) GAS CONNECTION - LP PIPED SYSTEMS EN An LP piped system is one with a large central LP tank that feeds an entire household. These systems are normally equipped with a high pressure regulator by the large LP tank, and low pressure regulators close to the home. The gas line connectors must comply with the Standard for Connectors for Outdoor Gas Appliances and Manufactured Homes, ANSI Z21.75 • CSA 6.27, and suitable for outdoor installation.
GAS AND ELECTRICAL CONNECTIONS (continued) GAS CONNECTION - LIQUID PROPANE (LP) CYLINDER Should you wish to connect your Aspire Side Burner to a standard 20 lb. LP gas cylinder, you will need to order kit AGCKLPT. This kit includes a two-stage regulator/hose assembly for connection to the tank, and a tank retention device. This regulator/hose assembly must be used WITHOUT alteration. If this assembly needs to be replaced, contact your Hestan dealer for genuine replacement P/N 014309.
GAS AND ELECTRICAL CONNECTIONS (continued) LEAK TESTING EN GENERAL Although all gas connections on your Aspire side burner are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible movement in shipment, or excessive pressure unknowingly being applied to parts of the unit. Periodically check the whole system for leaks, or immediately check if the smell of gas is detected. BEFORE TESTING • Do not smoke while leak testing.
GAS AND ELECTRICAL CONNECTIONS (continued) KEEP ANY ELECTRICAL CORD AND FUEL SUPPLY HOSE AWAY FROM ANY HEATED SURFACES. 1. To protect against electric shock, do not immerse cord or plugs in water or other liquid. EN 2. Unplug from the outlet when not in use and before cleaning. Allow to cool before putting on or taking off parts. 3. Do not operate any outdoor cooking gas appliance with a damaged cord or plug, or after the appliance malfunctions or has been damaged in any manner.
GAS AND ELECTRICAL CONNECTIONS (continued) ADJUSTMENT STEPS: 1. Pull off the “chin” at the base of the control panel, remove control knobs and control panel from the unit. EN 2. Follow lighting instructions by setting the control knob on “HI” and allow the burner to preheat for 10 minutes. 3. Turn the control knob to “LOW” and wait for the burner temperature to drop and stabilize, about 10 minutes. Attempting adjustment at any setting other than LOW can create a dangerous condition. 4.
LIGHTING INSTRUCTIONS Aspire side burners feature a spark-ignition system with flame-sensing technology which will relight the flame should it go out. EN The side burner can also be manually lit should that become necessary. LIGHTING SIDE BURNERS 1. Read Use & Care Manual before lighting. Remove cover during lighting. 2. Stand as far away as possible when lighting. 3. Push and turn selected knob to “HIGH” position. Igniter will spark until flame is established. 4.
USING YOUR SIDE BURNER Your Aspire Side Burner is a powerful cooking tool that complements your Aspire Grill. DO NOT leave the side burner unattended while cooking. EN COOKING WITH SIDE BURNERS Use your Aspire Side Burner like you would any residential gas cooktop in your home. Choose the appropriate pot or pan for the burner. In other words, don’t put a small pot over a large burner. For safety reasons, control the flame height so that it doesn’t go beyond, or curl up the sides of your pot or pan.
CLEANING AND MAINTENANCE (continued) the side burner to its original condition. To avoid re-occurrence of any “rust-staining”, it is essential that the source of the contamination is eliminated. An Aspire side burner cover will go a long way toward preventing this kind of contamination. EN PITTING A more severe form of corrosion is pitting of the surface.
CLEANING AND MAINTENANCE (continued) EN ADDITIONAL CONSIDERATIONS Always keep the area around the grill and side burner free of obstructions and debris. Maintain at least 12” (30 cm) of space around the grill and side burner to ensure proper airflow, and keep all ventilation openings clear and free of debris. Clean appliance after each use, and check for blockages, especially at the burner orifices, after periods of prolonged non-use.
TROUBLESHOOTING GUIDE Symptom Check Burner will not light Gas supply not on / shutoff valve closed LP gas cylinder empty Power cord not plugged in, or no power to receptacle, or blown fuse Low gas pressure to unit Burner ports near igniter are obstructed or dirty Burner cap not installed correctly on base Defective or clogged burner valve Incorrect orifice or clogged orifice Igniter defective (not sparking) Defective regulator or regulator installed improperly Burner will not stay lit Burner ports obst
WIRING SCHEMATIC EN ELECTRICAL BOX SINGLE 23 ©2018 Hestan Commercial Corporation
WIRING SCHEMATIC WIRE HARNESS SINGLE EN ©2018 Hestan Commercial Corporation 24
WIRING SCHEMATIC EN ELECTRICAL BOX DOUBLE 25 ©2018 Hestan Commercial Corporation
WIRING SCHEMATIC WIRE HARNESS DOUBLE EN ©2018 Hestan Commercial Corporation 26
PARTS LIST Please visit the Hestan website to access the parts list for your Aspire by Hestan product: www.hestanhome.com. EN SERVICE All warranty and non-warranty repairs should be performed by qualified service personnel. To locate an authorized service agent in your area, contact your Hestan dealer, local representative, or the manufacturer. Before you call, please have the model number and serial number information ready.
LIMITED WARRANTY (continued) EXTENSIONS TO ONE YEAR LIMITED WARRANTY PERIOD: In addition to the One-Year Limited Warranty, the following components have extended warranty coverage as specifically set forth below: 1. The Product’s stainless steel grill body, stainless tubular grill burners, Sear burners and rotisserie infrared burner (where applicable) are warranted to be free from defects in material and workmanship under normal non-commercial use and service for the lifetime of the original Purchaser.
LIMITED WARRANTY (continued) EN LIMITATION OF LIABILITY: This Limited Warranty is the final, complete and exclusive agreement between HCC and Purchaser regarding the Product. THERE ARE NO EXPRESS WARRANTIES OTHER THAN THOSE LISTED AND DESCRIBED ABOVE. NO WARRANTIES WHETHER EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE SHALL APPLY AFTER THE LIMITED WARRANTY PERIOD STATED ABOVE.
DANGER S’il Y a une odeur de gaz : 1. Coupez I’admission de gaz de I’appariel. 2. 2. Éteindre toute flamme nue. 3. 3. Ouvrir Ie couvercle. 4. 4. Si I’odeur persiste, éloiqnez-vous de I’appareil et appelez lmmédiatement Ie fournisseur de gaz ou Ie service d’incendie. DANGER 1. 2. Ne pas entreposer ni utiliser de I’essence ni d’autres vapeurs ou liquides inflammables dans Ie voisinage de l’apparell, ni de tout autre appareil.
NUMÉROS DE MODÈLE FR AEB122 AEB121 MODÈLES ENCASTRÉS 2 Numéro de Modèle Description AEB121-NG / -LP ENCASTRÉ BRÛLEUR LATÉRAL UNIQUE 12 po AEB122-NG / -LP ENCASTRÉ BRÛLEUR LATÉRAL DOUBLE 12 po ©2018 Hestan Commercial Corporation
PLAQUE SIGNALÉTIQUE La plaque signalétique donne des informations importantes sur cet appareil telles que les numéros de série et de modèle, le type de gaz et la pression d’admission, la cote BTU pour chaque type de brûleur et les dégagements minima d’installation. FR La plaque signalétique des brûleurs latéraux pour usage extérieur se trouve sur la paroi arrière intérieure de l’appareil, derrière le panneau de commande.
PRÉCAUTIONS À PRENDRE AVANT D’UTILISER CE GRIL (suite) 11. Examiner le tuyau d’alimentation en GPL avant chaque utilisation du brûleur latéral. Le tuyau doit rester à l’écart des parties chauffées du brûleur latéral. Si le tuyau présente des signes d’abrasion ou d’usure excessive, ou de coupure, il doit être remplacé avant utilisation du brûleur latéral. Le tuyau et le détendeur de GPL sont fournis sous forme d’ensemble complet et doivent être remplacés comme tel.
PRÉCAUTIONS À PRENDRE AVANT D’UTILISER CE GRIL (suite) 24. La graisse est extrêmement inflammable. Laisser la graisse chaude refroidir avant d’essayer de la manipuler ou de la jeter. Évitez de laisser des dépôts de graisse excessives recueillent en nettoyant le bol du brûleur souvent. Ne jamais le nettoyer quand le brûleur latéral est allumé ou Aspire chaud après avoir récemment fonctionné. 25.
LISTE DES PIÈCES Visiter le site Web Hestan pour consulter la liste des pièces de ce produit de plein air Hestan : www.hestanhome.com. SERVICE Toutes les réparations dans le cadre ou en dehors de la garantie doivent être effectuées par du personnel d’entretien qualifié. Pour localiser un réparateur agréé dans la région, s’adresser au concessionnaire , au représentant local ou à l’usine. Avant d’appeler, veiller à avoir les numéros de modèle et de série à portée de la main.
GARANTIE LIMITÉE (suite) ALLONGEMENTS AU-DELÀ DE LA PÉRIODE DE GARANTIE LIMITÉE D’UN AN: En plus de la Garantie limitée d’un an, les composants qui suivent bénéficient d’un prolongement de la garantie comme indiqué expressément ci-après : 1.
GARANTIE LIMITÉE (suite) LIMITATION DE RESPONSABILITÉ : La présente Garantie limitée constitue l’accord définitif, intégral et exclusif entre HCC et l’Acheteur eu égard au Produit. IL N’EXISTE AUCUNE GARANTIE EXPRESSE AUTRE QUE CELLES ÉNUMÉRÉES ET DÉCRITES PLUS HAUT. AUCUNE GARANTIE EXPRESSE OU IMPLICITE, Y COMPRIS SANS S’Y LIMITER, TOUTE GARANTIE IMPLICITE DE QUALITÉ MARCHANDE OU D’ADAPTATION À UN USAGE PARTICULIER NE S’APPLIQUERA APRÈS L’EXPIRATION DE LA PÉRIODE DE GARANTIE LIMITÉE INDIQUÉE PLUS HAUT.
RETAIN THIS MANUAL FOR FUTURE REFERENCE CONSERVEZ CE MANUEL POUR UNE RÉFÉRENCE FUTURE Hestan Commercial Corporation 3375 E. La Palma Ave.