CT-503 Cotton Candy Machine Manual Catalogue 1,Machine parameters 2,Introduction of machine parts 3,Out of the box content 4,Preparation before starting 5,Machine use steps 6,Background settings 7,Shut down and clean 8,Care and Maintenance 9,Precautions 10,Exception handling 11,Common fault error handling
1,Machine parameters Machine size:L:130cm W:66cm H:200cm,Weight 300kg Power Requirements: 10A 110-220V Power:Measured standby non-continuous heating constant temperature state 358w~ 684w,Heating for more than five seconds2000w~2140w;Average hourly 0.8 kWh.
can hold 2kg of sugar,One kilogram of sugar can make 25 candies, and the single sugar consumption is about 40g; the single candies consumption time is 60s-120s Candy pattern:The screen of the machine can support 24 kinds of patterns, and there are 36 kinds of patterns displayed in the background system for free, and the diameter of the patterns is 20-30cm. Display size:21.
Sugar consumption 1kg/25 sugar Size L1300mm W660mm H2000mm Weight 300KG Ambient temperature Use environment 10 degrees -40 degrees 1. Please ensure that the machine is reliably grounded (the machine is equipped with a phase detector) 2. Please make sure the connection line of the machine is 2500W-10A 3. The output is weather related 4. Be sure to use original consumables 2.
3. Contents of unpacking Thank you for your attention and purchase of the CT-503 automatic cotton candy machine. Please be sure to check the number of random objects and consumables in order to start up and operate normally. Some accessories/consumables may be packed and stored inside the machine, please disassemble and check carefully.
3 keys 1 repair kit 1 sugar funnel 1 clean water bucket 12 liters spare tube 1 sewage bucket 1 stove cover Sprinklers sprinkler 4、Preparation before start-up 1, Open all cabinet doors and check whether there is any looseness or falling off of the screws of plugs, pipes, wire ends and components that may be caused by accidents during the logistics and transportation process. It is recommended to screw all the screws on the back of the machine.
2. Check the sugar content of the sugar box. When there is a shortage of sugar, first open the cabinet door on the lower right side of the machine, take out the sugar plug, and then insert the funnel into the sugar box to add sugar; then add special sugar to the sugar boxes of different colors; the added amount is about three-quarters of the candy box. As shown in the figure below; from left to right: white, blue, yellow, red, after adding, put back the stopper 3.
4. Installation of sewage bucket: The location of the sewage bucket is in the left cabinet below the front of the machine; insert 3 sewage pipes into the sewage bucket (the pipes are 1 thick white pipe and 2 thin black pipes) and then insert the sewage bucket, put it in the cabinet. 5.
6. Placement of paper sticks: The stick-out device is located just above the front cabinet door of the machine; remove the paper sticks and put them into the stick-out device in turn; the recommended amount is about three-quarters of the container. 5.Machine use steps 1. After the power is turned on; open the machine cabinet door, push the machine switch upwards; start the machine. 6.Background system settings 1.
2、Enter the password; the initial password is: 123456 1). Parameter setting, you can set temperature and humidity; parameter setting of burner temperature and machine humidity parameter setting; if you need to adjust, please operate under the guidance of technicians.
2).Inventory settings:Set the inventory of sugar and paper sticks and the inventory of clean water box; you need to enter this item after each supplementary material is completed to set the corresponding supplementary material inventory to the corresponding value. 3)Equipment test: Test whether the relevant parts of the machine work normally. Do not operate this test without the guidance of technical personnel.
4).Shopping settings: Shopping time - no operation waiting time on the shopping page, the default is 30s, the minimum can be set to 30s, and the maximum can be set to 120s Shopping Cart - Whether to enable the shopping cart function, after enabling multiple items can be purchased at the same time Maximum Capacity - The maximum number of items that can be purchased at the same time after the shopping cart function is enabled, the default is 5, the minimum can be set to 2, and the maximum can be set to 9 5).
6)system message: Volume, voice broadcast, restart 7)WIFI connection: Machine wireless connection settings
After power on, press and hold the upper right corner of the screen, click the ○ button at the bottom of the screen, then click the Settings button, click WLAN button, and select the WIFI you want to connect to. 7.
1. If the machine is in standby mode; the screen shows that the temperature of the burner is lower than 150 degrees; directly pull down the switch to shut down 2. Machine closing status: In the closing status of the machine, you can directly pull down the switch to shut down. 3.
2. Clean the dust inside the machine every 30 days, and check whether the internal parts of the machine are loose or fall off. 3. Do not put the accessories stored in the machine for more than three months. 9.Precautions 1. It is strictly forbidden to directly unplug the power supply at any time to shut down. You should wait for the mechanical arm to return to its position and the burner to cool down before shutting down. 2. Candy can only be added after the sugar in the candy box is used up.
7. The assembly must be disassembled during long-distance transportation, and the residual sugar must be cleaned up 8. Every time you start the machine, you need to ensure that the machine cabinet door is tightly closed. 10.Exception Handling 11.Common fault error handling 1.
background - click device test - click the humidification play button.1) Touch the red circle to see if the pump vibrates? (next to the clean water bucket) 2).The accessories in the red circle in the picture above vibrate - it depends on whether the nozzle next to the stove is spraying water or the water is a line rather than a spray 3).
Note: The sprinkler is a vulnerable part, and the length of the blockage is related to the local water quality (another reason is that there is sugar falling on the sprinkler). 2.After the candy is finished, there will be flying flossy and fluffy fluff After the sugar is finished, there are still flying silk and floating flocculents.
3.Out of the stick error DTC: 402012 ejector timeout 402013 ejector timeout Troubleshooting and workarounds: 1. Check whether there are sticks in the paper stick storage bin; 2. If there is a stick; enter the management background; click "Device Test" to find "Roller Motor"; adjust the action duration to "5000"; Then click the play button to start. After starting, check whether the scroll wheel under the stick device is working.
If the roller does not turn: Use a multimeter to check whether the roller motor has 24V current input. 4.DTC: 4003 Arm reset failed Troubleshoot and workaround: 1.
This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation NOTE: This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules.