JGBS86 LP Conversion

Low setting adjustments must be made with other burners in
operation on a medium setting. This procedure prevents the
ORZÀDPHIURPEHLQJVHWWRRORZUHVXOWLQJLQWKHÀDPHEHLQJ
extinguished when other burners are turned on.
A. Turn on all surface burners to medium setting.
% 7XUQWKHNQRERQWKHEXUQHUEHLQJDGMXVWHGWR³/2´
& 5HPRYHWKHNQREDQGLQVHUWDVPDOOÀDWEODGHVFUHZGULYHU
into the valve shaft and/or side adjustment screw(s) as
shown and turn clockwise to fully tighten down the bypass
screw(s). Repeat for all valves.
' ,IÀDPHDSSHDUVWRRORZRUXQVWDEOHVORZO\WXUQE\SDVVVFUHZ
FRXQWHUFORFNZLVHXQWLODVWDEOHÀDPHH[LVWVIRUHDFKEXUQHU
Remember, other burners must be turned on to medium.
( $GGLWLRQDOO\IRUHDFKEXUQHUEHLQJDGMXVWHGTXLFNO\RSHQ
DQGFORVHWKHRYHQGRRUZKLOHREVHUYLQJÀDPH,IÀDPHLV
extinguished, continue adjusting bypass screw for a larger
ÀDPH5HSHDWGRRURSHQLQJVXQWLOÀDPHLVVWDEOH
F. Replace the knob.
ADDITIONAL INFORMATION
ADJUSTING AIR SHUTTER SETTINGS
FOR OVEN BURNERS
ADJUSTING LOW FLAME SETTING
ON COOKTOP BURNERS
2YHQEXUQHUÀDPHPXVWEHREVHUYHGZLWKWKHGRRUFORVHG
WRSURSHUO\FKHFNÀDPHFKDUDFWHULVWLFV
 &KHFNLQJWKHÀDPHVL]H
It should be approximately
1/2” to 3/4” long for the bake
and broil burners.
The combustion quality of
WKHEXUQHUÀDPHVQHHGVWR
be determined visually.
SPECIAL NOTE:
To convert the oven back to natural gas, reverse the
instructions given in making propane adjustments.
PROPANE CONVERSION INSTRUCTIONS
31-2000718 01-20 GEA
JGBS86
NOTICE:
2QFHWKHFRQYHUVLRQLVFRPSOHWHDQGFRQ¿UPHG¿OORXW
WKHSURSDQHVWLFNHUDQGLQFOXGH\RXUQDPHRUJDQL]DWLRQ
and date conversion was made. Apply the sticker to the
range near the regulator to alert others in the future that
this appliance has been converted to propane. If converting
back to natural gas from propane, please remove the sticker
so others know the appliance is set to use natural gas.
BURNER OUTPUT RATINGS: BTU/HR
NG (Natural) Gas 5” W.C.P.
BURNER
BTU
RATE
ORIFICE
SIZE (in) COLOR MARKING
LF 15,000 0.070 Brown 178N
LR 5,000 0.040 :KLWH3XUSOH 101N
RF 9,500 0.053 Green 136N
RR 12,000 0.061 Red 155N
C 10,000 0.055 Yellow 140N
Upper Bake 7,000 0.046 Yellow 046N
Broil 16,500 0.071 Black/Blue 071N
Lower Bake 14,000 0.066 Red 066N
The air shutters should be turned to the marked settings NG or
propane or set according to the following table.
:LWKD3KLOOLSVKHDGVFUHZGULYHUORRVHQWKHVFUHZVVHFXULQJ
the air shutters on the burners and adjust the air shutters
according to chart.
%DNHDQGEURLOÀDPHVPXVWEHFKHFNHGZLWKWKHRYHQ
GRRUVFORVHGWRSURSHUO\FKHFNÀDPHFKDUDFWHULVWLFV
1. Turn on the gas.
2. Turn on the electricity.
3. Reinstall the lower oven door. Close both doors.
4. Turn on both bake burners.
5. For each burner, observe the following through the oven
door windows.
 D,IWKHÀDPHVDUH\HOORZRSHQWKHDLUVKXWWHUPRUH
 E,IWKHÀDPHVEORZDZD\RUÀXWWHUIURPWKHEXUQHUFORVH
the air shutter slightly, but not by more than 1/8”.
 7XUQEDNHEXUQHURႇDQGUHSHDWZLWKEURLOEXUQHU
BURNER
AIR SHUTTER
SETTING FOR PROPANE
AIR SHUTTER
SETTING FOR NG
Lower Oven
Broil
Burner
0.690 0.690
Upper Oven
Bake
Burner
0.750 0.750
Lower Oven
Bake
Burner
Full Open Full Open
Air Shutter
Setting
Air shutter
3KLOOLSV6FUHZ
WARNING
If you attempt to measure the inner cone
RIWKHÀDPHSOHDVHXVHFDXWLRQEXUQVFRXOGUHVXOW
Center adjustment screw only for all burners.
198
III
Denotes 1.98mm Orifice size opening
Denotes Natural Gas
N
CONVERTING THE OVEN BURNERS
UPPER AND LOWER OVEN BAKE BURNER
ORIFICES
1. Remove the lower oven door from the unit
 5HPRYHRYHQUDFNVRYHQERWWRPVDQGÀDPHVSUHDGHUV
from both ovens. In the lower oven, remove the enclosure
around the rear of the bake burner held in place by three
3KLOOLSVVFUHZV
3. Remove all 1/4” hex
screws securing the bake
burners. Gently slide
each bake burner to the
left to remove it from the
RUL¿FHDQGDOORZEXUQHUV
to rest on the bottom of
their respective ovens.
 :LWKD´ZUHQFKORRVHQHDFKRUL¿FHE\WXUQLQJFRXQWHU
clockwise and remove.
 6HOHFWWKHDSSURSULDWHEDNHRUL¿FHIRUHDFKRYHQIURPWKH
NLWDQGLQVWDOORQWKHWKUHDGHG¿WWLQJV7LJKWHQZLWKZUHQFK
until snug.
 *HQWO\UHSODFHWKHEDNHEXUQHUVRYHUWKHLUUHVSHFWLYHRUL¿FHV
and replace all 1/4” hex screws securing the burners.
BROIL BURNER ORIFICE
1. Remove the 1/4” hex
screw securing the broil
burner and allow it to
hang down free of the
EURLORUL¿FH
2. Apply a 1/2” wrench
to the hex base of the
RUL¿FH/RRVHQWKH
RUL¿FHE\WXUQLQJFRXQWHUFORFNZLVHDQGUHPRYH
 6HOHFWWKHSURSDQHEURLORUL¿FHIURPWKHNLWDQGLQVWDOOLWRQ
the broil elbow. Tighten until snug.
 5HSODFHWKHEURLOEXUQHURYHUWKHRUL¿FHDQGUHSODFHWKH
screw securing the burner.
NOTICE:
This product cannot be converted to propane by adjusting
WKHRYHQRUL¿FHV7KHRUL¿FHVPXVWEHUHSODFHGIRUSURSDQH
127(,IEXUQHUÀDPHVORRNOLNH$IXUWKHUDLUVKXWWHU
adjustment to the bake buner is required. Normal
EXUQHUÀDPHVVKRXOGORRNOLNH%RU&GHSHQGLQJ
on the type of gas you use. With propane gas, some
yellow tipping on the outer cones is normal.
)RUHLJQSDUWLFOHVLQWKHJDVOLQHPD\FDXVHDQRUDQJHÀDPHDW
¿UVWEXWWKLVZLOOVRRQGLVDSSHDU
8. Retighten the air shutter screws.
9. When all adjustments are made and the results are
satisfactory:
a. Replace the enclosure around the rear of the bake
burner in the lower oven.
 E5HSODFHWKHÀDPHVSUHDGHUV
c. Replace the oven bottoms and oven racks.
(A) Yellow flames:
Further Adjustment
Required
(B) Yellow tips on
outer cones:
Normal for Propane Gas
(C) Soft blue flames:
Normal for Natural Gas
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
Broil
2UL¿FH
Oven
Light
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV