Little Kawa 9/20/02 1:36 PM Page 1 77760 77767 77768 Product features may vary from the picture above. Please read this manual and save it with your original sales receipt. Tools needed for assembly: Phillips Screwdriver and Slotted Screwdriver (both not included). Use only with a Power Wheels® 6 Volt (4.0 Amp/Hr.) Battery, Power Wheels® 25 Amp Fuse and Power Wheels® 6 Volt (4.0 Amp/Hr.) charger (all included). Kawasaki and KX125® are trademarks used under license by Kawasaki Motors Corp., U.S.A.
Little Kawa 9/20/02 1:36 PM Page 2 Table of Contents A B C D E F G H I J K L M N O Important Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 Warnings and Cautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Little Kawa 9/20/02 1:36 PM Page 3 B Warnings and Cautions ELECTRICAL HAZARD WARNING • Battery can fall out and injure a child if vehicle tips over. Always use battery clamp. • PREVENT FIRE - Never modify the electrical system. Alterations could cause a fire resulting in serious injury and could also ruin the electrical system. - Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury.
Little Kawa 9/20/02 1:36 PM Page 4 C Parts • If you experience a problem with this product, or are missing a part, please call us at 1-800-348-0751, rather than return this product to the store. • Please identify all parts before assembly and save all packaging material until assembly is complete to ensure that no parts are discarded. • Some parts were placed under the seat for shipment. Press the tab under the back of the seat and lift to access the battery compartment.
Little Kawa 9/20/02 1:36 PM Page 5 D Parts Diagram Handlebar Assembly 6 Volt (4.0 Amp/Hr.) Charger Seat Vehicle Body Steering Column Retainer 25 Amp Fuse 6 Volt (4.0 Amp/Hr.
Little Kawa 9/20/02 1:36 PM Page 6 E Battery Charging ELECTRICAL HAZARD CAUTION WARNING Use the charger in dry locations only. • Battery can fall out and injure a child if vehicle tips over. Always use battery clamp. • PREVENT FIRE - Never modify the electrical system. Alterations could cause a fire resulting in serious injury and could also ruin the electrical system. - Use of the wrong type battery or charger could cause a fire or explosion resulting in serious injury.
Little Kawa 9/20/02 1:36 PM Page 7 Battery Charging IMPORTANT! The battery must be removed from your vehicle for the initial charge in order to complete assembly. After assembly is complete, you do not need to remove the battery from your vehicle to recharge it. 1 3 25 Amp Fuse Seat ANT IMPORT E MUST FUSD IN TOP AMP RE A 25INSTALLE BEFO GE HAR BE BATTERY OF WILL REC TOY OPERATE OR • Insert a Power Wheels® 25 amp fuse into the battery.
Little Kawa 9/20/02 1:36 PM Page 8 F Battery Charging Assembly WARNING 5 Children can be harmed by small parts, sharp edges and sharp points in the vehicle’s unassembled state, or by electrical items. Care should be taken in unpacking and assembly of the vehicle. Children should not handle parts, including the battery, or help in assembly of the vehicle. Handlebar Assembly 1 • Plug the charger into a standard 120 volt wall outlet.
Little Kawa 9/20/02 1:36 PM Page 9 Assembly Front Wheels Assembly 2 3 Hole in Axle Steering Linkage Steering Column Retainer Groove Grill Steering Column Front Axle Column Steering Column Bottom View Front Axle Column Groove Steering Column Retainer • Turn the vehicle over so that it rests on the handlebars. • Position the front wheels assembly so that the grill is toward the front end of the vehicle body. Fit the front wheels assembly onto the front axle columns.
Little Kawa 9/20/02 1:36 PM Page 10 Assembly 4 5 Pull Up Handlebar Connector Motor Connector • Turn the vehicle upright. • Pull the handlebars up to be sure the steering column is secure. • If you can remove the steering column, you have not assembled the steering column retainer correctly. Please refer back to Assembly step 3. • Plug the handlebar connector into the motor connector.
Little Kawa 9/20/02 1:36 PM Page 11 G Label Decoration Proper label application will help to keep the labels looking their best! When applying labels, keep the following guidelines in mind: • Wash your hands before applying the labels. • Before applying the labels, wipe the surface of the vehicle with a clean, dry cloth to remove any dust or oils. • Place the labels exactly as shown in the illustrations. • For best results, avoid repositioning a label once it has been applied to the vehicle.
Little Kawa 9/20/02 1:36 PM Page 12 H Battery Installation IMPORTANT! Use only a Power Wheels® 6 volt (4.0 Amp/Hr) battery with a Power Wheels® 25 amp fuse installed. Use of any other battery or fuse will damage your vehicle. Make sure that you charge the battery for at least 18 hours using the enclosed Power Wheels® 6 volt charger before operat-ing your vehicle for the first time. Charge the battery for at least 18 hours after each use of the vehicle.
Little Kawa 9/20/02 1:36 PM Page 13 Battery Installation 5 7 Battery Connector Motor Harness Connector Lock Fastener • Plug the battery connector into the motor harness connector. Hint: If the battery connector will not plug into the motor harness connector, turn it over and try again! Do not force the battery connector into the motor harness connector. 6 Seat Tab Locked Unlocked • Using a slotted screwdriver, turn the lock fastener 1/ 4 turn to the locked position .
Little Kawa 9/20/02 1:36 PM Page 14 I Battery Care and Disposal Battery Care and Disposal Care Disposal If a battery leak develops, avoid contact with the leaking acid and place the damaged battery in a plastic bag. See information below for proper disposal. If acid comes in contact with skin or eyes, flush with cool water for at least 15 minutes and call a physician. If acid is internally ingested, give water, milk of magnesia or egg whites immediately. Never give emetics or induce vomiting.
Little Kawa 9/20/02 1:36 PM Page 15 K Rules for Safe Driving RIDING HAZARD 7. Do not allow your child to drive on sloped or inclined surfaces. Restrict your child’s driving to generally level ground ONLY! 8. Do not allow your child to drive down or across a steep slope. - The vehicle may gain unsafe speed, even if the button is released to stop. - The vehicle may tilt and tip over. - The wheels could lose traction, causing the vehicle to slip. 9. Do not allow your child to drive up steep inclines.
Little Kawa 9/20/02 1:36 PM Page 16 L M How to Operate Your Vehicle IMPORTANT! use the vehicle ONLY outdoors. Most interior flooring can be damaged by riding this vehicle indoors. Fisher Price® will not be responsible for damage to the floor if the vehicle is used indoors. Bumper-to-Bumper* Limited Warranty *One year limited warranty from the date of purchase on the Power Wheels® vehicle. Six month limited warranty on the 6 volt battery.
Little Kawa 9/20/02 1:36 PM Page 17 N Problems and Solutions Guide IMPORTANT! If you experience a problem with your vehicle, first check the Problems and Solutions Guide below. If you still experience a problem, please contact Power Wheels® Consumer Relations, toll-free at 1-800-348-0751 between 8 AM and 6 PM (EST) Monday through Friday. Or, contact your local Power Wheels® authorized service center. For the location nearest you, please refer to the Authorized Service Center list beginning on page 20.
Little Kawa 9/20/02 1:36 PM Page 18 Problems and Solutions Guide Problem Short run time (Less than 1 - 3 hours per charge) Possible Cause Solution Undercharged battery Charge the battery. A new battery should have been charged for at least 18 hours before using the vehicle for the first time. After first-time use, recharge the battery for at least 18 hours after each use. Never charge the battery longer than 30 hours. Check all wires and connectors.
Little Kawa 9/20/02 1:36 PM Page 19 Problems and Solutions Guide Problem Sometimes the vehicle doesn’t run, but other times it does Possible Cause Solution Loose wire or connector Check all wires around the motor and all connectors to make sure they are tight. Motor or electrical switch damage Contact your local Power Wheels® Authorized Service Center for diagnosis and repair. Loose wire or connector to make sure they are tight. Check all wires around the motor and all connectors.
Little Kawa 9/20/02 1:36 PM Page 20 O Authorized Service Centers We are continually expanding our independently owned and operated Authorized Service Center Network. Please check this listing for the independently owned and operated Authorized Service Center nearest you. If there is not one in your area, please call Power Wheels® Consumer Relations at 1-800-348-0751. ALABAMA BIRMINGHAM - Frigid Service & Sales, 701 Graymont Ave.
Little Kawa 9/20/02 1:36 PM Page 21 Authorized Service Centers INDIANA EVANSVILLE - Electro Hygiene Co., 1614 S Kentucky, 47714, (812) 425-2671 FT. WAYNE - Southside Vacuum Co. Inc., 3702 South Calhoun Street, 46807, (260) 745-7788, (888) 209-8113 INDIANAPOLIS - Brand Service Center, 1827 N. Meridian Street, 46202, (317) 924-1386 INDIANAPOLIS - Sullivan Hardware Do-It Center, 7021 N. Keystone, 46220, (317) 255-9230 NEW ALBANY - Wells Hardware, Inc.
Little Kawa 9/20/02 1:36 PM Page 22 Authorized Service Centers TRENTON - Tattersall, Inc., 309 N. Willow Street, 08618, (609) 393-4293 NEW MEXICO ALBUQUERQUE - Appliance Service Center, 3219 Candelaria, NE, 87107, (505) 265-7774 CLOVIS - Burns Hardware, 1511 N. Prince, 88101, (505) 769-2528 NEW YORK ALBANY - Lake Electronic Service, 1650 Central Avenue, 12205, (518) 869-8424, (800) 585-3777 BAYSHORE, L.I. - Turnpike Appliance of Suffolk, Inc.
Little Kawa 9/20/02 1:36 PM Page 23 Authorized Service Centers TEXAS AMARILLO - Reid’s Appliance Service, Inc., 906 Georgia, 79102, (806) 373-8812 CORPUS CHRISTI - Brand Appliance & Microwave, 2751 South Staples, 78404, (361) 854-1851 DALLAS - All Type Sales and Service Co., Inc., 2835 Irving Blvd., 75207, (214) 638-1170, (800) 717-1170 DALLAS - Pearsol Appliance Co., 3127 Main Street, 75226, (214) 939-0930 FT. WORTH - Ft.
Little Kawa 9/20/02 1:36 PM Page 24 IMPORTANT! DO NOT use this vehicle for the first time until you have charged the battery for 18 hours. Remember to… ✔ Insert a 25 amp fuse (included) into the battery. ✔ Charge the battery immediately after each use. ✔ Charge the battery once a month during storage, even if the vehicle has not been used. Failure to follow these instructions will permanently damage your battery and void your warranty.