Post Mount Grill Instructions

ManualsBrandsFire Magic ManualsBarbecue56 Inch Charcoal Grill with Warming Rack, Adjustable Charcoal Pan, Smoker Oven and Hood and 432 sq. in. Cooking Area

INSTALLER:

Leave these instructions with consumer.

CONSUMER: Retain for future reference.

INSTALLATION AND OPERATING

INSTRUCTIONS

IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE.

WARNING

Do not store or use gasoline or other ﬂ ammable

vapors and liquids, including propane cylinders,

in the vicinity of this or any other appliance.

Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, CA 91746

CODE REQUIREMENTS: This grill must be installed in accordance with local codes and ordinances.

WARNING:

All surfaces of the charcoal unit become HOT during use. Exercise caution when using

this unit, especially when adding charcoal or cranking the charcoal pan up or down.

WARNING

Improper installation, adjustment, alteration,

service, or maintenance can cause injury or

property damage. Refer to this manual. For

assistance or additional information, consult a

qualiﬁ ed professional installer, or service agency.

SAFETY WARNINGS & CODES

TABLE OF CONTENTS

22 Series (In-ground and patio mount)

The grill serial identiﬁ cation number is located on the underside of the drip tray handle. It

is recommended that the drip tray ﬁ rst be removed and cleaned / emptied of its contents,

then turned over to view.

REV 4 - 1405300810

L-C2-214

CUSTOM POST

CHARCOAL GRILLS

2 REPLACEMENT PARTS LIST

3 PLANNING THE LOCATION OF YOU POST GRILL

3 EXHAUST REMOVAL

3 INSTALLATION & SETUP

3 SECURING THE PATIO MOUNT GRILL

3 ATTACHING THE IN-GROUND POST EXTENSION

3 IN-GROUND PROCEDURE

4 RIGID SHELF ASSEMBLY

4 OPERATION

5 ACCESSORIES

6 NOTES PAGE

7 CARE & CLEANING

8 WARRANTY

Patio mount

model shown

Summary of content (8 pages)

PAGE 1
CUSTOM POST CHARCOAL GRILLS 22 Series (In-ground and patio mount) INSTALLATION AND OPERATING INSTRUCTIONS Patio mount model shown INSTALLER: Leave these instructions with consumer. CONSUMER: Retain for future reference. IMPORTANT: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE. SAFETY WARNINGS & CODES WARNING WARNING Improper installation, adjustment, alteration, service, or maintenance can cause injury or property damage. Refer to this manual.
PAGE 2
REPLACEMENT PARTS LIST Item Description Part No. Qty. 1. Stainess steel cooking grids (set of 2) 3542-S-2 2. Custom, smoking oven Lift-A-Fire (LAF) 23756-C 1 3. Shelf rigid 24330-017 2 4. Face, Custom LAF assembly 3137-06 1 5. Drip tray assembly 3081 1 6. Patio base w/hardware 24330-31 1 or In-ground base w/hardware 24330-32 1 7. Patio mount hardware kit 24330-25 1 8. Charcoal pan 3302-S 1 9. Warming rack 3672C 1 3900-40 1 11. Crank 23302 1 12.
PAGE 3
PLANNING THE LOCATION OF YOU POST GRILL This grill is designed FOR OUTDOOR USE ONLY. DO NOT use this unit under unprotected flammable surfaces. DO NOT use this appliance inside a building, garage, or any other enclosed area. It must not be used in or on recreational vehicles or boats. Important: This unit is NOT insulated, and therefore during use it must be located with a minimum of 18" of side and back clearance from unprotected combustible materials such as wood, plastic, or stucco with wood framing.
PAGE 4
INSTALLATION & SETUP (cont.) ALIGN CRANK HANDLE WITH NUT & SCREW IN ASSEMBLY Crank 1. Locate the crank handle (Fig. 4-1) packed inside the grill enclosure. 2. Open the door in the front panel as shown in Fig. 4-1 and insert the threaded end into the crank handle through the hole on the right of the grill face and into the nut on the frame as shown. 3. Center the crank on the nut and begin cranking in a clockwise direction until the threads have properly caught hold. 4.
PAGE 5
ACCESSORIES GRILL BRUSH (optional) WARMING RACK (if equipped) Purchase a Fire Magic® stainless-steel grill brush (sold separately) to keep your grill cleaner. It comes with scraper for large particles and a replaceable head with brass bristles for overall cleaning. The warming rack (Fig. 5-2) is packed separately. To install the warming rack, lift the front of the rack up slightly and insert the rack hangers into the two holes in the back of the inner oven hood.
PAGE 6
NOTES PAGE 6
PAGE 7
CARE & CLEANING APPLIANCE MUST BE COMPLETELY COOL WHEN CLEANING. DO NOT SPRAY ANY CLEANER OR LIQUIDS ON THE APPLIANCE WHEN HOT. The appliance must be cleaned as often as once a month (depending on use) to prevent grease build-up and other food deposits. Wipe wit h grain INTERIOR Empty the charcoal drip tray and screen of all ash and drippings after each use. Clean the charcoal screen, pan, and the interior of the grill with a water and mild soap solution. Fig.
PAGE 8
WARRANTY PETERSON FIRE MAGIC GRILLS AND ACCESSORIES LIMITED WARRANTY Robert H. Peterson Co. ("RHP") warrants your Fire Magic® grill to be free from defects in material and workmanship. Fire Magic® cast stainless-steel burners, stainless-steel rod cooking grids, and stainless-steel housings are warranted for as long as you own your Fire Magic® grill -- LIFETIME. (Except as noted below.) Fire Magic Choice stainless steel tubular burners are warranted for TWENTY (20) YEARS.