MM-E 2072-09333-00 SERVICE MANUAL FOR MICOM-Z HF-SSB TRANSCEIVERS Revision A JULY 2011
MM-E 2072-09333-00 WARNINGS, CAUTIONS AND NOTES The following notations are used to place special emphasis on procedures, or to call attention to precautionary measures. WARNING An operating procedure, practice and so forth, which if not followed correctly, could result in personal injury, or loss of life. CAUTION An operating procedure, practice and so forth, which if not followed correctly, could result in damage to, or destruction of equipment.
MM-E 2072-09333-00 SAFETY SUMMARY The following are general safety precautions that are not related to any specific procedures and therefore do not appear elsewhere in this publication. These are recommended precautions that personnel must understand and apply during various phases of operation and maintenance. KEEP AWAY FROM LIVE CIRCUITS. Operating personnel must at all times observe all safety regulations.
MM-E 2072-09333-00 TABLE OF CONTENTS Page Chapter 1 1-1. Chapter 2 INTRODUCTION SCOPE .......................................................................................................................... 1-1 THEORY OF OPERATION Section I. GENERAL DESCRIPTION............................................................................................ 2-1 2-1. MICOM-Z DESCRIPTION ............................................................................................. 2-1 2-2. 2-3. 2-1.1 2-1.
MM-E 2072-09333-00 LIST OF ILLUSTRATIONS Page Figure 2-1. Figure 2-2. Figure 2-3. Figure 2-4. Figure 2-5. Figure 2-6. Figure 2-7. Figure 2-8. Figure 2-9. Figure 2-10. Figure 2-11. Figure 2-12. Figure 2-13. Figure 2-14. Figure 2-15. Figure 2-16. Figure 2-17. Figure 2-18. Figure 2-19. Figure 2-20. Micom-Z Dash-Mount Version Structure .................................................................................. 2-1 Micom-Z Dash-Mount Wiring Diagram .......................................................
MM-E 2072-09333-00 LIST OF ILLUSTRATIONS (Cont'd) Page Figure B-1. Figure B-2. Figure B-3. Figure B-4. Figure B-5. Figure B-6. Figure B-7. Figure B-8. Figure B-9. Figure B-10. Figure B-11. Figure B-12. Figure B-13. Micom-Z Assembly Dash Version ............................................................................................B-2 LORD Assembly.........................................................................................................................
MM-E 2072-09333-00 LIST OF TABLES Page Table 2-1. Table 2-2. Table 2-3. Table 2-4. Table 2-5. Table 2-6. Table 2-7. Table 2-8. Available Options...................................................................................................................... 2-16 Accessories .............................................................................................................................. 2-16 Micom-Z Microphone Connector, Pin Functions ......................................................
MM-E 2072-09333-00 Chapter 1 INTRODUCTION 1-1. SCOPE This Service Manual provides the information needed to maintain Micom-Z HF-SSB radio sets in accordance with manufacturer’s recommendations. For a description of Micom-Z characteristics and capabilities, and for installation and operation procedures, refer to the Micom-Z Operator Manual, Publication OM-E 2072-09689-00. The Micom-Z Operator Manual also describes the cooling tray, available as an accessory for Micom-Z transceivers.
MM-E 2072-09333-00 Intentionally Left Blank 1-2
MM-E 2072-09333-00 Chapter 2 THEORY OF OPERATION Section I. GENERAL DESCRIPTION 2-1. MICOM-Z DESCRIPTION 2-1.1 Micom-Z Dash-Mount Version 2-1.1.1 Structure Figure 2-1 shows the structure of the Micom-Z dash-mount version. Micom-Z dash-mount version consists of two main assemblies, attached by means of four screws: • Body assembly. The body assembly includes two main modules, LORD and HI POWER, interconnected by a few cables.
MM-E 2072-09333-00 2-1.1.2 Wiring Diagram Figure 2-2 shows the wiring diagram of the Micom-Z dash-mount version. Micom-Z dash-mount version comprises the following main modules: a. LORD module, includes the following main circuits: (1) Audio signal processing circuits for the receive and transmit paths. (2) Digital signal processor (DSP) and its auxiliary circuits. (3) RF and IF modulation/demodulation and signal processing circuits for the receive and transmit paths.
MM-E 2072-09333-00 c. CONTROL HEAD module, includes the following main circuits: (1) Microcomputer subsystem, built around a microcontroller, used to manage the operator interface, transfers the operator commands to the main microcomputer subsystem located on the LORD module, and controls the LCD and its operational conditions. (2) Serial RS-232 port for communication with the Micom-Z management subsystem.
MM-E 2072-09333-00 (3) The RF power amplifier in the HI POWER module generates an RF signal at the power level selected by the operator (LOW, MED, HIGH, or MAX). The transmit signal is connected by the TX/RX switch to the harmonic filter, which attenuates harmonics and unwanted spurious signals. The filtered signal then passes to the ANT connector through a power sensor, which generates DC voltages, VFWD and VREV, proportional to the forward and reflected power.
MM-E 2072-09333-00 Body Assembly MIC Audio Connector LORD Front Panel Assembly MIC Audio Amplifier Audio and Data Sources MIC PTT Serial Control Channel MIC PTT Codec A/D Section Voice PTT Data PTT CW PTT ISB Option First Mixer First IF (45.1 MHz) Processor Second Mixer Receiver Second IF (450 kHz) Processor Third Mixer Receiver Third IF (20 kHz) Processor TX Amplifier DSP Subsystem HI POWER Digital SSB Modulator (DSM) 1.05 MHz ANT Power Sensor Harmonic Filter Local Oscillator 1 45.
MM-E 2072-09333-00 2-1.1.3.3 Frequency Conversion Subsystem The Micom-Z frequency conversion scheme is described in Figure 2-4. 1.6 MHz 30 MHz 0.1 MHz 30 MHz 45.1 MHz First IF amplifier 45.1 MHz First IF amplifier 1.05 MHz Second IF amplifier 450 kHz Second IF amplifier 20 kHz Third IF amplifier DS P pr oc es sin g DSP processing DSM Audio Audio A. Transmit Path B. Receive Path Figure 2-4.
MM-E 2072-09333-00 DSP RF Output 1.6 - 30 MHz 1.05 MHz IF Processor 45.1 MHz DSM Synthesizer Subsystem First LO Frequency = 46.7 - 75.1 MHz Step = 8.75 kHz Second LO Frequency = 46.15 MHz Step = 1.25 kHz ÷2 ÷8 VCO 1, 2, 3 VCO 4 0 to 1.25 kHz 10 Hz Resolution Frequency = 368.4 MHz Step = 10 kHz Figure 2-5. Transmit Path Frequency Conversion Scheme DSP IF Processor 45.1 MHz RF Input 0.1 - 30 MHz IF Processor 450 kHz Synthesizer Subsystem First LO Frequency = 45.2 - 75.1 MHz Step = 8.
MM-E 2072-09333-00 b. The main microcomputer subsystem in the LORD module controls the operation of all the Micom-Z circuits, monitors their status, measures the various analog voltages that represent power levels, temperatures, supply voltages, etc., and manages self-test. The microcomputer subsystem uses the information received from the front panel microcontroller and the PTT commands to select the desired operating mode, and stores the operational parameters in a battery-protected memory.
MM-E 2072-09333-00 • Control head, shown in Figure 2-8. This is a separate unit that includes the operator interface and CONTROL HEAD module, which are similar to the front panel of the Micom-Z dash-mount version, except that the speaker is external. The access to the CONTROL HEAD module is through a rear cover fastened by four screws to the front panel. The control head is connected to the body assembly by a cable, which also includes a branch for connecting an external speaker.
MM-E 2072-09333-00 Body Assembly Backup Battery GPS Control Head GPS Receiver J4 Socket for SD Memory Card P501 Interconnection Cable LCD P2 P1 J8 J6 J5 ACCESSORY J3 INTERCONNECTION J4 LORD P2 J2 J1 TX RX J3 P4 P4 P2 ANT P3 P6 E1 E2 VDC IN HI POWER Microphone Speaker Figure 2-9. Micom-Z Trunk-Mount Wiring Diagram 2-1.2.3 Functional Block Diagram The functional block diagram of Micom-Z trunk-mount version is shown in Figure 2-10. 2-1.2.3.1 Transmit Path a.
MM-E 2072-09333-00 • Voice PTT – PTT from an accessory connected to Micom-Z through the ACCESSORY connector, transmits the voice signal from the accessory device. • Data PTT – PTT from a data device, for example, a modem, connected to Micom-Z through the ACCESSORY connector, causes Micom-Z to switch to the data mode and transmit the modem signal. • CW PTT – PTT from a Morse key connected to Micom-Z through the ACCESSORY connector, causes the radio to switch to the CW (Morse) transmission mode.
MM-E 2072-09333-00 LORD MIC PTT MIC PTT PTT and MIC Buffers MIC Audio Amplifier PTT and MIC Buffers MIC Audio and Data Sources Serial Control Channel Voice PTT Codec A/D Section Audio Connector Control Head Assembly Body Assembly Data PTT CW PTT First IF (45.
MM-E 2072-09333-00 2-1.3 Micom-Z Cooling Tray Figure 2-11 shows the structure of the Micom-Z cooling tray. The cooling tray includes one module, the FAN CONTROL module, which provides point-to-point connections between the two 25-pin connectors of the cooling tray. The module also includes the fan control circuit, which enables to turn the supply voltage to the fan ON or OFF in accordance with the control signal provided by the Micom-Z installed on the tray.
MM-E 2072-09333-00 2-2. OPTIONS AND ACCESSORIES The following tables list the options and accessories that can be ordered for Micom-Z. Contact the manufacturer or your local representative if you need an option or accessory not listed below. Table 2-1. Available Options Option Mfg. Cat. No.
MM-E 2072-09333-00 2-3. CONNECTOR DATA 2-3.1 Micom-Z Connector Data Table 2-3. Micom-Z Microphone Connector, Pin Functions Pin Designation Description 1 SWA+ Power output to the microphone 2 RXD Serial communication line (input) 3 TXD Serial communication line (output) 4 GND Ground line 5 MIC AUDIO Input audio signals generated by the microphone (600 Ω impedance; 300 mV tone is required for full output power). 6 PTT MIC Activates transmission by short to ground.
MM-E 2072-09333-00 Table 2-4.
MM-E 2072-09333-00 2-3.2 Cooling Tray Connectors Table 2-6. Micom-Z 44-Pin/25-Pin Adapter Cable Wiring Diagram 44-Pin 25-Pin 44-Pin 25-Pin Connector Connector Connector Connector 1 1 43 14 44 2 15 15 3 3 16 16 4 4 17 17 5 5 18 18 6 6 19 19 7 7 20 20 8 8 21 21 9 9 22 22 10 10 23 23 11 11 24 24 12 12 25 25 13 13 Table 2-7.
MM-E 2072-09333-00 Table 2-7.
MM-E 2072-09333-00 Section II. CIRCUIT ANALYSIS 2-4. LORD MODULE The schematic circuit diagram of the LORD module is shown in Figure A-1, and the module block diagram is shown in Figure 2-12. 2-4.1 Audio Subsystem Refer to Figure A-1.C. The audio subsystem uses the 8V_AUDID_ISB voltage, provided by the linear voltage regulator U6098, and a bias voltage, 4V_AUDID_BIAS, generated by part of U4000. 2-4.1.1 Audio Transmit Path a. Microphone Signal Path.
MM-E 2072-09333-00 the DSP host port interface, and by a few discrete control lines. The RAM U6038 connected to the DSP, address and data buses, is used by the DSP to store temporary variables and data. The DSP has two ESSIs: ESSI 1 is used to connect to the codec U6040, and ESSI 0 is used to connect to the DSM, U6000. The operations performed by the DSP are determined by the program data loaded from the microcontroller through the HPI.
MM-E 2072-09333-00 To HI POWER Preselector Control Data VCC Band Selection Control U1, Q1-Q8 RF IN Preselector CR1-CR16 BIT Noise Generator Q9, Q30, Q2901 9T Front-End Attenuator (RAGC) Q1000, Q1013-Q1015 CR1000, CR1008 Front-End Amplifier Q1002, Q1007 First IF Amplifier Q1011 First Mixer U1000 45.1 MHz Crystal Filter FL1, FL2 30 dB Attenuator Bidirectional 45.1 MHz Second IF Amplifier Mixer Q1003, Q1006 U1108 CR1011, CR1012 Local Oscillator 2 44.05 to 46.15 MHz SW_A+ SW_A+ SW_A+ +5V Reg.
MM-E 2072-09333-00 d. The first mixer converts the 45.1 MHz transmit IF signal to the final RF transmit frequency, by mixing with the local oscillator signal, FIRST_INJ, provided by synthesizer 1 (para. 2-4.7.2). e. In the transmit mode, the mixer output signal passes through the PIN diode CR1010 to the exciter amplifier (CR1009 is reverse-biased). f. The mixer output signal is filtered by a low-pass filter, and is then amplified by Q1004, Q1005.
MM-E 2072-09333-00 2-4.6 Receive IF Path Refer to Figure A-1.M, Figure A-1.N. 2-4.6.1 First IF Processor a. The 45.1 MHz IF signal generated by U1000 is amplified by Q1001 (the PIN diodes CR1011 and CR1012 are reverse-biased). The bias voltage for Q1001 is provided by Q1011, which is turned on in the receive mode by the low level on the 9T line). b. The amplified signal at the drain of Q1001 passes through an attenuator pad to the 45.1 MHz bandpass crystal filters FL1 and FL2. c.
MM-E 2072-09333-00 U5008 can measure the voltage proportional to the ambient temperature near the oscillator (provided by the thermistor R3023) by means of its internal A/D converter, through the AMB_TEMP line connected to the AN5/PDA5 input. 2-4.7.1.2 OCXO Option U3002 is an ovenized crystal oscillator, which includes circuits that enable to maintain the oscillator at a constant temperature, higher than the ambient. The power for the OCXO is provided by a +10V linear voltage regulator, U3004. a.
MM-E 2072-09333-00 a. PLL Control. Synthesizer 1 is a PLL using the frequency synthesizer control subsystem U6075 to generate a control voltage for one of the three VCOs used to cover the required frequency range. The control voltage is derived by the loop filter C2142, C2117, R2047, R2045, C2118, which integrates the pulses appearing at the phase/frequency detector output, CP.
MM-E 2072-09333-00 2-4.8 Main Microcomputer Subsystem Refer to Figure A-1.F, Figure A-1.G. 2-4.8.1 Microcontroller U5008 The main microcomputer subsystem is built around U5008, a 16-bit microcontroller with a 2K internal RAM, and 48KB masked ROM. U5008 has a large number of I/O ports, a serial peripheral interface (SPI), and two serial communication interfaces (UARTs), and an internal 8/10-bit A/D converter with 8 multiplexed analog inputs.
MM-E 2072-09333-00 2-4.8.5 SPI The SPI comprises a serial data line, SPI_DATA, and an associated clock line, SPI_CLK. These lines are used to communicate with other circuits, via serial/parallel converters. Each converter also receives a load (strobe) command, which indicates when to update its outputs. The functions of the various serial/parallel converters are described next to the circuits which are controlled by them. 2-4.8.6 UARTs a.
MM-E 2072-09333-00 2-4.10 LORD Module Test Point Data The LORD module has several test points, which enable measurement of signal levels and frequencies using a spectrum analyzer. Figure 2-16 provides a map of the available test points, and Figure 2-15 provides typical signal levels and frequencies at critical points (these test points are identified by a larger type in Figure 2-16). These test points can be used for troubleshooting purposes. Gain (dB) -3 -2.
2-32 FS DCSI TMS DE_ ALTIN TD1 JTAG_RESET TRST TD0 TCK DTXCP DTXCM DSM_OUT GND HA0 HREQ_ HA1 HA2 HRW EX_AMP_OUT TP_1 TP_2 R9701 AF_3 16.8_SQR IF3_4 IF3_6 IF3_5 AF_2 XTAL_OUT AMP_3 EX_AMP_IN IF3_3 IF3_2 SYN2_D SYN2_RF_TO_MIXER SYN2_CLK SYN2_LD SYN2_LE SYN2_CONTROL Figure 2-16. LORD Test Points Map ADC_IN EX_AMP_LPF DSM_N TEMP_CONT_IN TEMP_SENSE TEMP_CONT SYN1_16.
MM-E 2072-09333-00 2-5. HI POWER MODULE The functional block diagram of the HI POWER module is shown in Figure 2-17. The HI POWER module comprises the power amplifier subsystem, the harmonic filter circuits and their control circuits, and the Micom-Z power supply subsystem. 2-5.1 Power Amplifier (PA) 2-5.1.1 ALC Attenuator Refer to Figure A-2.B. The RF_INPUT_TX signal received via connector P4 from the LORD module is connected to the ALC attenuator, comprising R77 and the PIN diodes CR8, CR9.
MM-E 2072-09333-00 is inserted in the signal path by a pair of relays, controlled by the LORD module via the serial data line SPI_DATA. The relay control data is loaded into the serial/parallel converter U4 at the rate of the SPI_CLK clock signal, and updates the U4 outputs when the SPI_SEL line rises to a high level.
MM-E 2072-09333-00 To LORD P2 RX_OUT SW_BATT Q10, Q12 9T P4 RF_INPUT_TX ALC Attenuator CR8, CR9 Predriver Amplifier Q5, Q7 SW_BATT SW_BATT Driver Amplifier Q3, Q4 TX/RX Switch K1 Power Amplifier Q6, Q11 Harmonic Filter J2 K102 K101 PA_OUT Band 1 (1.6 - 2.43 MHz) PWR_AMP_BIAS ALC_REF_DAC ALC Circuit U5, U13, U14 V_FWD_RADIO V_REV_RADIO R67 Predriver Bias Generator U1 PA_INHIBIT R73 V_REV_RADIO K302 K301 Band 3 (3.7 - 5.6 MHz) 9T BIT K402 K401 Band 4 (5.6 - 8.
MM-E 2072-09333-00 c. Reverse Power Protection. The V_REV_RADIO voltage passes through the peak detector (U14, CR811) to the reverse power comparator, U13: when the reverse power increases, the output (pin 5) voltage decreases, resulting in a higher voltage at the emitter of Q23, which drives the V_ALC line. d. Overheat Protection. The thermistor RT3 causes the voltage on the V_TEMP_PA line (monitored by U5008, located on the LORD module), to be proportional to the internal temperature.
MM-E 2072-09333-00 2-6. CONTROL HEAD MODULE Figure A-3 shows the schematic circuit diagram of the CONTROL HEAD module for both the dash-mount and trunk-mount versions. 2-6.1 CONTROL HEAD Module for Dash-Mount Version Figure 2-18 shows the functional block diagram of the CONTROL HEAD module used in the Micom-Z dash-mount version. 2-6.1.1 Microcontroller Refer to Figure A-3.B. a. Microcontroller.
MM-E 2072-09333-00 c. ON/OFF Control. The ON/OFF push-button, SW26, is normally open: when pressed to turn the Micom-Z on, it connects ground to the ON_OFF_CONT line, which turns the power supply subsystem on the HI POWER module on.
MM-E 2072-09333-00 2-6.2 CONTROL HEAD Module for Trunk-Mount Version Figure 2-19 shows the functional block diagram of the CONTROL HEAD module used in the Micom-Z trunk-mount version. 8V0_AUDIO P501 P6 MIC_IN Amplifier U503 TX_AUDIO Audio Connector PTT_MIC RS-485 Line Driver U506 PTT 3V3 3.
MM-E 2072-09333-00 is made via an RS-485 transceiver, comprising the line receiver U504 and the line driver U505 (refer to Figure A-3.E). 2-6.2.2 Auxiliary Power Supply Refer to Figure A-3.E. The auxiliary power supply is similar to that of the dash-mount version (para. 2-6.1.2). 2-6.2.3 LCD Heater and Backlighting Control The LCD heater and backlighting control circuits are similar to the dash-mount version (para. 2-6.1.3). 2-6.2.
MM-E 2072-09333-00 2-7. INTERCONNECTION MODULE Refer to Figure A-4. Figure 2-20 shows the functional block diagram of the INTERCONNECTION module. P2 P1 Amplifier U1 TX_AUDIO MIC_IN To Internal Circuits 13V8_RADIO_TRUNK To Control Head Voltage Regulator Q1, U2 13V8_DC_RADIO ON_OFF_CONT_PNL To LORD PTT Line Receiver U5 PTT_MIC CH_RXD Line Driver U4 RX_UART0 CH_TXD Line Receiver U3 TX_UART0 Figure 2-20. INTERCONNECTION Module, Functional Block Diagram a.
MM-E 2072-09333-00 Chapter 3 MAINTENANCE 3-1. SCOPE This Chapter provides maintenance instructions for Micom-Z. The information presented in this Chapter covers testing, troubleshooting procedures, and repair instructions. Use Appendix B to identify components and find other data needed for troubleshooting and repair. 3-2. HANDLING PRECAUTIONS DURING MAINTENANCE Equipment maintenance is performed in accordance with standard practice.
MM-E 2072-09333-00 f. Micom-Z modules make extensive use of surface-mounted (SMT) components and miniaturization, therefore personnel involved in troubleshooting and repair must be thoroughly familiar with the applicable workmanship procedures. No special tools are needed for repair, except for a standard technician’s toolbox and a soldering/desoldering station with an appropriate set of tips, considering the component types used in the module (in particular multilead and SMT components).
MM-E 2072-09333-00 3-3. CLEANING WARNING Prolonged breathing of cleaning compounds may be dangerous; make certain that adequate ventilation is provided. Do not use near a flame. Avoid contact with the skin. If contact with skin is made, immediately wash off with water. Before performing any maintenance actions, clean the equipment in accordance with the following procedure: a. Inspect the exterior of the unit. The surfaces should be clean and free of dirt, grease and other contaminants. b.
MM-E 2072-09333-00 3-5. TROUBLESHOOTING The purpose of the troubleshooting procedures is to return a defective Micom-Z unit to normal service as soon as possible, by isolating the malfunction to a replaceable subassembly or module, and then repairing the subassembly or module. 3-5.
MM-E 2072-09333-00 Table 3-2. BIT Error Codes (Cont’d) Meaning Error Code Probable Cause 06 Not applicable 07 Not applicable 08 HC16 flash memory checksum LORD board problem 09 HC16 RAM memory LORD board problem 10 No 16.8 MHz clock Check for good power cable connection.
MM-E 2072-09333-00 3-5.3 Troubleshooting Procedure The purpose of the troubleshooting procedure presented in this Section is to rapidly return a defective Micom-Z to service by replacing suspected modules: a. Identify the closest description of the problem under “Problem Symptom” in Table 3-3. b. Perform the required corrective actions listed under “Corrective Actions” in the table in the order of appearance, until the problem is corrected.
MM-E 2072-09333-00 Table 3-3. Troubleshooting Procedure (Cont’d) No.
MM-E 2072-09333-00 Table 3-3. Troubleshooting Procedure (Cont’d) No. Problem Symptom 28 No receive output signals for external devices in the ACCESSORY connector LORD module 29 No 13.
MM-E 2072-09333-00 3-5.4 Micom-Z Troubleshooting Charts 1. Perform the checks presented in Figure 3-1. 2. If a problem is detected at a checkout step of Figure 3-1, refer to the troubleshooting chart identified next to the corresponding step, and then perform the troubleshooting activities listed in the chart until the problem is corrected. 3. After correcting the problem, repeat the checkout procedure in accordance with Figure 3-1. Start Perform visual inspection of equipment.
MM-E 2072-09333-00 6 Turn radio on and adjust the volume to midrange. Press the SQ key to alternate between squelch on and squelch off Static heard in the speaker when squelch is off? No Proceed to troubleshooting chart 5 Yes 7 Select USB mode and connect a signal generator to the ANT connector. Inject -100 dBm signal at the radios (operating frequency +1 kHz) into the radio. Turn on the squelch and vary the input frequency in a range of ± 500 Hz.
MM-E 2072-09333-00 From Checkout Step 1 Ensure the power supply is on and provides 13.8 VDC to the radio. Check inline fuse: replace if necessary Radio powered on? No Yes Open radio and do a visual inspection of the boards. If visible damage is found, correct by replacing or repairing appropriate part No Radio powered on? Yes Using a DC voltmeter, check for 13.8V at J3 pin 13 and J6 pin 11 on the LORD module No 13.
MM-E 2072-09333-00 From Checkout Step Yes 2 Pop sound heard in speaker when the power switch is turned on? No Verify the condition of the flat cable from the LORD module to the front panel CONTROL HEAD module using an ohmmeter Yes Yes Blank display? The firmware was not loaded correctly or an incorrect version was loaded. Load the correct firmware version. If loading the firmware fixes the problem, proceed to step 2 of the checkout.
MM-E 2072-09333-00 From Checkout Step 3 Possibly a bad microphone: try a different microphone and key it again, or connect pin 6 to ground on the mic jack No No Problem is with the LORD module. Replace or repair as necessary. Proceed to step 3 of the checkout Connect J5 pin 8 to ground. Radio keyed? Radio keyed? Yes Yes Problem found.
MM-E 2072-09333-00 From Checkout Step 4 PW Latch error displayed on the screen when whistling? Yes No Possibly a bad microphone, try a different microphone and key/whistle again, or connect 0 dBm audio to pin 5 on the mic jack. Key the radio by shorting J5 pin 8 to ground Problem is on the HI POWER module. Replace or repair as necessary. Proceed to step 4 of the checkout No Connect a 0 dBm audio signal to J5 pins 6 & 7 and key the radio No Problem found.
MM-E 2072-09333-00 From Checkout Step 6 Check that the volume is at midrange or beyond Yes Using an AC voltmeter, check for audio voltage on J5 pins 1 and 3 No No Turn up the volume and proceed to step 6 of checkout Yes Voltage present? Verify the condition of the flat cable from the LORD module to the front panel CONTROL HEAD module using an ohmmeter Problem is with the LORD module. Replace or repair as necessary.
MM-E 2072-09333-00 From Checkout Step 8 If you are following the instructions in the RSS Owner's Guide, and the oscillator or power output will not adjust, the problem is in the LORD module. Replace or repair as necessary. Proceed to step 8 of the checkout Figure 3-8. MICOM-Z Troubleshooting Chart 7 3-5.
MM-E 2072-09333-00 Start Is any sound heard in the speaker? Yes Check the harmonic filter range switching Problem found Check harmonic filter range and its control lines Problem found Check coax cables Problem found Check LORD board No Check from CONTROL HEAD board to speaker Problem found Ranges OK Check coax from HI POWER to LORD Reception possible Check path from LORD RF input to speaker output Is the input signal to the first mixer OK? Yes Check first local oscillator Problem found
MM-E 2072-09333-00 A Check second local oscillator Problem found Check synthesizer Check 450 kHz signal (IF filter) Problem found Check second mixer Check 20 kHz signal Problem found Check 450 kHz ceramic filter Check A/D converter Problem found Check A/D DC voltage Check DSP output signal Problem found Check VCC Check audio amplifier Problem found Check A+ (13.8 V) Reception possible Check flat cable to CONTROL HEAD Figure 3-9.B.
MM-E 2072-09333-00 Start Transmit to a dummy load Problem persists No Is transmission in AME mode posible? Check the harmonic filter ranges Transmission possible Antenna and/or antenna tuner problem Problem in one range Check the harmonic filter and/or its control lines Yes Problem in all ranges Check the 9T, 9R, PA DISABLE lines Problem found Check the PTT path from the mic connector to the LORD board Problem persists Check PA power transistors No problem found Check from HI POWER module t
MM-E 2072-09333-00 A Check second mixer output (45.1 MHz) Problem found Check second synthesizer Problem found Check first synthesizer Problem found Check coax cable Problem persists Check first mixer output (the frequency of the working channel) Problem persists Check LORD module output to HI POWER module input Figure 3-10.B.
MM-E 2072-09333-00 3-6. MICOM-Z REPAIR PROCEDURES 3-6.1 3-6.1.1 Micom-Z Dash-Mount Version Repair Gaining Access to Modules 1. Refer to Figure 3-11: release the 8 screws fastening the top cover, and then remove the top cover. Top Cover Fastening Screws (8 places) Top Cover Rear Panel Fastening Screws (4 places) Body Assembly Front Panel Fastening Screws (4 places) Figure 3-11. Gaining Access to Modules 2. Release the four screws fastening the front panel to the body assembly.
MM-E 2072-09333-00 CAUTION The rear panel need not be removed to gain access to the modules. Do not attempt to remove the rear panel before removing the LORD and HI POWER modules as explained below. 4. To reassemble the front panel, reverse the procedure described above. 3-6.1.2 Replacing Components of LORD Assembly The LORD assembly includes the LORD module (covered by a shield), the backup battery, and the GPS receiver.
MM-E 2072-09333-00 3-6.1.2.2 Replacing the Backup Battery The backup battery is fastened by a clamp to the top of the LORD module, and its harness connects to connector J4 on the module. Before starting, pay attention to the orientation of the battery. 1. Disconnect the battery harness from connector J4 of the LORD module. 2. Release the screw fastening the battery clamp, and then remove the battery. 3.
MM-E 2072-09333-00 6. Clean the remnants of heatsink compound from the areas identified in Figure 3-14, and then spread a thin layer of fresh compound. 7. Position the replacement LORD module over the lower RFI contacts, place them together in their original positions on the LORD base, and then fasten the LORD module with the two heatsink screws removed in Step 4 above. 8.
MM-E 2072-09333-00 ANT Cable Figure 3-15. Removal of HI POWER Module 3-6.1.3.2 Installing the Replacement HI POWER Module 1. Clean the remnants of heatsink compound from the body assembly and the HI POWER module. 2. Spread a thin layer of fresh compound on the bottom area of the HI POWER module. 3. Route the coaxial cable with the ANT connector over the HI POWER module as shown in Figure 3-15. 4.
MM-E 2072-09333-00 NOTE To remove the LCD, release its four fastening screws, and then disconnect it from the module. Also disconnect the two harnesses connected to connectors P2 and P4 on the module. 5. If necessary, move the LCD to the replacement module. 6. Orient the replacement module in accordance with Figure 3-16, and place it on the spacers. 7. Reconnect the speaker cable to the corresponding module connector. 8. Reinstall the RF shield.
MM-E 2072-09333-00 3-6.2 3-6.2.1 Repair of Micom-Z Trunk-Mount Version Gaining Access to Modules 1. Refer to Figure 3-17: release the 8 screws fastening the top cover, and then remove the top cover. Top Cover Top Cover Fastening Screws (8 places) Rear Panel Fastening Screws (4 places) Body Assembly Front Cover Fastening Screws (4 places) Figure 3-17. Gaining Access to Micom-Z Trunk-Mount Version Modules 2. Release the four screws fastening the front cover to the body assembly.
MM-E 2072-09333-00 CAUTION The rear panel need not be removed to gain access to the modules. Do not attempt to remove the rear panel before removing the LORD and HI POWER modules as explained below. 4. To reassemble the front cover, reverse the procedure described above. 3-6.2.2 Replacing Components of LORD Assembly Refer to para. 3-6.1.2. 3-6.2.3 Replacing the HI POWER Module Refer to para. 3-6.1.3. 3-6.2.4 Replacement of INTERCONNECTION Module 1. Remove the front cover in accordance with para. 3-6.
MM-E 2072-09333-00 Rear Panel Captive Screws (4 places) CONTROL HEAD Module LCD Screws Rear Panel Inserts Module Fastening Screws (9 places) Keypad Front Panel Figure 3-19.
MM-E 2072-09333-00 Intentionally Left Blank 3-30
MM-E 2072-09333-00 Appendix A SCHEMATIC CIRCUIT DIAGRAMS NOTE Components designated as OPTION or LAB in the schematic circuit diagrams are optional, and are not installed on the PCBs. Therefore, ignore such components.
MM-E 2072-09333-00 Intentionally Left Blank A-2
MM-E 2072-09333-00 CPU_AUDIO LOW_RF DIGITAL_16 .8Mhz DSM_OUTPUT_1.05Mhz SPI_CLK SPI_DATA_OUT DIGITAL_16.8Mhz DSM_OUTPUT_1.05Mhz SPI_CLK SPI_DATA_OUT RESET A_D_DATA SR_DATA SR_CLK DSM_AGC_EN CONVST 3.
MM-E 2072-09333-00 41 EXT_RX_AUDIO_ISB 42 EXT_TX_AUDIO_ISB 12 DSI|KW_C_C 24 DSO|FAN_ON_OFF 25 FREEZE|KW_TUNE 22 BKPT_DSC|KW_ALC 21 VPP DSP_UNIT C9534 16 TXA 15 RXA 29 TXB 33 RXB 39 TXC DSO FL3 FREEZE FL4 BKPT_DSCK RXC 38 TXD IN IN 31 RXD IN 19 KW_PTT 17 EX_RESET 8 9 10 37 FL32 FL24 FL29 FL23 FL9 PTT_IN_VOICE PTT_IN_DATA F_VP_VOCODER_PTT IN KW_ON_OFF 2 STOP_SCAN CLK_OUT DSP_REQ DSP_REQ TXC OUT RXC OUT OUT OUT OUT SW_A+ F1 PA_ MUTE CS_ 3 SPKR+ 4
R9697 MM-E 2072-09333-00 ISB_EXT_AUDIO_SW 0 8V_AUDID_ISB R4003 8V_AUDID_ISB 10K R4004 10K EXT_AUDIO_SW R9586 10K Q4004 R4005 20K 3904L R9587 10K 8V_AUDID_ISB AUDIO_C_P_SW Q9066 3904L C4000 33NF R9580 20K R4401 3.3K C4002 270PF C4004 1UF 8V_AUDID_ISB L4001 22UH EXT_TX_AUDIO- C9559 C4007 1000PF C4008 1000PF 16 C4009 1UF R4013 560 9 Y0 CX 1UF MC78M08BDTRK 1 VIN 8V_AUDID_ISB VOUT 3 EXT_TX_AUDIO+ U6098 C9615 4 0.
MM-E 2072-09333-00 3.3V C9483 0.01UF 3.3V C9482 10NF 3.3V C9485 0.01UF 3.3V 3.3V 3.3V 3.3V C9486 0.01UF 3.3V 3.3V 3.3V 14 3.3V C9501 0.1UF C6002 0.1UF 0.1UF 3.3V 40212212354 ADP3338AKC-3.3 3.3V 3.3V C9484 0.01UF C9489 0.01UF C9487 0.01UF C9502 0.1UF 2 3.3V C9490 0.
MM-E 2072-09333-00 3.3V 3.3V C9612 10UF C9611 10UF 3.3V C9578 100NF R9669 OPTION C9579 100NF FRAME MODE R9642 10K R9687 OPTION PULSE MODE R9639 10K 45 3.
OPTION MM-E 2072-09333-00 FOR ANALOG INPUT FROM J5 PIN 39 VCC L5002 22UH VCC R9677 6.8K VCC C9606 0.1UF R9682 R9681 OPT ION OPT ION ANAOLG_INPUT C5004 0.1UF C5003 0.1UF C5007 33UF VCC C5005 0.1UF VCC TXC C5002 0.1UF SW_A+ 1 VOUT C5006 0.01UF C5001 0.1UF 8 C5000 100NF C6035 C5009 0.1UF R5007 39K RS232_TTL_SW UART_CL CR5002 MMBD701LT VR5001 5.
MM-E 2072-09333-00 SPARE C9560 0.1UF 5V_UART U6080 74VHC14 13 14 VCC 12 GND 7 R9608 39K A2 A1 A0 NORMAL PTP RS232_SW = HIGH GPS MODE (J7) RS232_SW = LOW C9518 0.1UF 5V_UART 5V_UART VCC C9519 C5024 0.1UF 0.
MM-E 2072-09333-00 VCO1_SEL VCO2_SEL VCO3_SEL DSM_AGC_EN FILT_LOW_RF_SEL CONVST 9T 3.3V J3 FILT_LOW_RF_SEL 9T SPI_DATA_TO_HF FILT_SPI_CLK 40 PTT_IN R3059 FILT_LOW_RF_SEL 10K FILT_SPI_DATA 39 38 SPI_DATA_TO_HF 37 FILT_SPI_CLK SW_A+_RF VCO1_SEL GND GND GND 32 SPI_DATA_TO_HF J1 J1 J1 1 RF_IN SPI_CLK SPI_DATA_TO_HF RF_IN 2 GND DSM_AGC_EN CONVST 3.
C47 CR8 MMBV3401 MM-E 2072-09333-00 CR9 MMBV3401 1000PF 13V SW_A+_RF 13V L52 C3 15UF 470 C15 0.1UF C56 100NF 22UH C91 0.1UF 3904L R30 1.2K Q5 13V VDD_PS C102 2.7NF CR7 MMBV3401 VDD_PS C58 C36 C92 6.8NF 2.7NF MMBV3401 0.01UF CR16 R13 R11 100K 6.8K L51 22UH C4 0.1UF 16 C90 0.1UF U1 74HC595A L5 22UH FL1 FL2 SPI_DATA_TO_HF C41 1.8NF C28 0.01UF C94 1200PF L7 C40 1.8NF C93 0.
MM-E 2072-09333-00 VOS2 SYN1_CONTROL C2081 VCC SW VCO3 R2045 9.09K CTRL FILT _VCO3_SEL FIRST SECTION FIRST_IN J 0.1UF FN C2061 C2142 3.9NF 1000PF C2118 1.5NF C2117 100NF FILT _VCO2_SEL GND R2048 1K R2000 270 SYNTH_LOCK R2071 300 SYN1_RF_TO_MIXER R2082 18 FILT _VCO1_SEL R2047 4.75K SECOND SECTION SYN2_CONTROL VCC R2046 5.62K C2146 6.8NF 6 2 5 3 GND 0.1UF R2052 7.5K C2067 1000PF R2070 300 C2114 0.1UF SHOULD BE 330PF (1206) FOR BSF OPERATION VDD2 SYN2_VCO_OUT C2083 0.
MM-E 2072-09333-00 VCC VCC R9065 C9099 R9063 C9089 200 1000PF 200 1000PF FN FN C9096 47PF C9098 390PF 3 G2 G1 CTRL CR9075 10PF Q9000 BF992 CR9071 BB659C-E7902 CR9066 BB659C-E7902 Q9020 BF992 4 CR9063 S 1 C9062 R9100 18 C9110 180PF C9097 L9079 L9076 1 .5UH 10PF C9069 12PF S 1 MMBD 701 LT 1.5UH R9020 27K C9063 L9065 5.1PF 35 .5NH L9077 L9070 SH9020 1.5UH 1.5UH SHIELD L9065A C9000 C9020 1000PF 66 .
MM-E 2072-09333-00 C3014 0.01UF TEMP_CONT D2A_TEMP_CONT 9V C3027 0.01UF TEMP_CONT _IN R3942 10K OVEN_TEMP_CNTL1 4 13 R3044 R3006 33K 12 R3350 10K OVEN_TEMP_CNTL2 R3004 150K 33K 14 11 R3330 TEMP_SENSE U3000 MC33174_PWR HEAT_CONT C3011 10K 2 0.01UF R3043 33K TEMP_SENSE 10 3 C3029 C9401 0.01UF 8 5 U3000 MC33174 0.
MM-E 2072-09333-00 AMPLIFIER #1 9T R1000 10K 9T L1029 CR1006 MMBD914T 0.1UF C1000 CR1002 MMBD914T CR1005 MMBD914T R1002 10K L1020 0.1UF C1002 C1003 33UF BIDIRECTIONAL AMPLIFIER #2 9V E1002 FERRITE_BID 18 C1006 C1007 C1008 33UF 0.1UF 0.1UF C1011 10NF 0.1UF R1007 R1005 10 C1005 0.1UF Q1007 C1001 0.1UF R1001 18 R1003 3906L CR1007 MMBD914T Q1011 3906L 22UH C1004 9V 22UH AMPLIFIER #0 R1006 68 10 10 C1018 C1009 10NF RAGC R1011 2K 0.1UF R1012 2K R1014 10 0.
9R MM-E 2072-09333-00 9T 9T_IF VDD_IF TX 1.05MHZ BANDPASSFILT ER VDD L1800 L1801 22UH L1802 1.0UH TX_SEC_INJ 100 1.0UH C1803 0.1UF R1800 33UF C1802 0.1UF VDD_IF C1801 C1800 C1997 C1804 0.1UF 0.1UF 0.1UF L1803 L1804 1.0UH 1.0UH R1801 1K LO RX,TX TRANS_IF 4 C1807 0.1UF C1808 1.8NF L1805 22UH IF RF 2 3 R1802 100 C1810 0.1UF MMBV3401 C1812 4700PF C1820 0.1UF RX 14 11 12 OUT C1815 220PF 10 C1817 0.1UF R1816 100 C1821 0.1UF AMP #33 8 6 CONT.
13 MM-E 2072-09333-00 9T/9R GENERATOR VDD C9537 0.1UF 9V U6077 U6077 74VHC14 14 VCC 12 11 74VHC14 10 C1200 0.1UF R9585 R9584 10K GND 7 VDD 10K 9V R1200 0 9V 9R R1201 1K VCO_SEL_FILTER 9T 1 2 100 74VHC14 4 3 470 470 5 6 14 9 12 8 100 74VHC14 8 9 R1202 R1203 470 470 Q1008 MC33074D U1100 11 R1208 1K R1207 0 1 Q1018 3904L FILT_VCO2_SEL R1211 R1212 470 470 6 MC33074D U1100 C1202 0.
MM-E 2072-09333-00 J2 40330005401 1 DIPOLE 2 P3 1040696 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 +5_VCC_FIL CPU PA_INHIBIT P4 TMP-J01X-A2 TP9 CH_CHANGE TUNER_CUR_LIM SW_BATT +8VDC +5_VCC_FIL +5_VCC_FIL +5_VCC_FIL +10VDC +10VDC DC_TO_ANT_CPLR 9T 9T +5_VCC_FIL J1 40330005401 DC_TO_ANT_CPLR WHIP PA_OUT RF_INPUT_TX PA_INHIBIT PA_INHIBIT 1 2 3 V_REV_TUNE V_REV_PEP RX_TO_LORD BATT_CHECK SPI_SEL_2_PA SW_BATT V_
MM-E 2072-09333-00 R30 CR10 MMBD914LT1 3 CW 1 2 R67 10K 3 L17 R44 412 R23 R29 C47 51.1 412 10N 1 C49 R40 68N 33.2 33.2 R43 33.2 100N C41 R41 100N 33.2 Q3 4 RD16HHF1-101 T3 D C48 G 2089-13023-00-0 PRE_DRIVER S 1 2 L9 C144 330N LAB 180P LAB 10K 47P LAB 6 3 C33 R34 4 1 100N C860 T2 20721300600 R31 1 4.7 6 7 56P 4 3 5 + 2 R169 OPT C854 C869 47U 100N C30 C862 C861 1N 330P 330P C25 10K C52 DRIVER_BIAS 100N 2 3 R33 C51 51.
MM-E 2072-09333-00 DC_TO_ANT_CPLR R36 0.0 K2 EB2-5-NU RANGE1_OUT 3 RANGE1_OUT 1.6-2.429 MHz 8 8 + + - - C707 8 100N + C708 +5_VCC_RLY 10N 100N +5_VCC_RLY FLTR_2_DRIVE 3 RANGE2_IN RANGE2_IN RANGE2_OUT 3 RANGE2_OUT 8 8 + + - - K302 2 4 9 7 1 10 +5_VCC_RLY FLTR_3_DRIVE 2 4 9 7 1 10 10P C74 10P +5_VCC_RLY CR810 FLTR_2_DRIVE HSMS2800 K301 EB2-5-NU 3 RANGE3_IN RANGE3_IN 1 EB2-5-NU 3.7-5.
MM-E 2072-09333-00 FILTER#1 1.6-2.43 MHZ T=18 3.5 UH DRILL 0.85 MM TP4 TP24 FILTER#5 8.5-13.0 MHZ T=16 2.8 UH TP25 T=7 TP39 L101 20721302314 1 20721302313 1 5.20U 3.39U C103 C107 TP42 1 1 20721302305 1 1 0.71U 0.
MM-E 2072-09333-00 E18 +8VDC +8VDC R924 R925 1K 1K V_REV_PEP VR802 LM4040CEM3X-5.0 LAB C896 1+ 2- R905 100N R68 0.0 VEE INH 16 14 6 5 V_REV_PEP 100N V V 1 LMC6482AIMX C90 R88 R93 1K +8VDC LAB R94 9T R916 LM2900DR C119 R61 36.5K C86 +8VDC R914 R913 R58 100N 150K 100K 3.32K 1 8 CR1 R867 2 51.1K V_FWD_RADIO R64 15 LM2900DR V 1 5 U5 LMC6482AIMX MC14053BD V+ 4 9T V- 2 R901 MMBT4403LT3 1K LAB R52 9T LAB VR801 LM4040CEM3X-5.
MM-E 2072-09333-00 Q14 Q26 IRFS3004-7PPBF 6 S 7 S SW_BATT 7 S 3 S +8VDC 1 G C173 Q20 SW_BATT MMBT4403LT3 909K 51.1K IN+ SNS GAITE C165 51.1K OUT 100N AOUT 1 Q21 R161 R170 BST82 100K 100K C157 100N TMR FB EN 10 GND FLT R160 10K LAB 6 4 4 8 11 9 R178 8 R116 3 SW_BATT PWM_EN BATT_CHECK 4 LMC6482AIMX 100N 24.3K VR4 LM4040CEM3X-5.
MM-E 2072-09333-00 J3 FH28-40S-0.5SH(05) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 V0_LCD CPU MZ_CPU C1 2.2U V1 C2 2.2U V2 C3 2.2U V3 V4 C4 2.2U C5 2.2U R213 0.0 R214 0.0 C10 C6P R12 2.2U C11 2.2U C12 2.2U C1P C7 2.2U C8 2.2U C9 2.2U V0_LCD XCS_N_LCD RST_N_LCD RST_N_LCD V0_LCD RD_N_CPU WR_N_CPU WR_N_CPU CPU_D[7:0] VDD_LCD_3V0 68P H H L IF3 IF2 IF1 10K R3 XCS_N_LCD 10K KEY_Y[4:0] R6 0.
MM-E 2072-09333-00 SCL_CPU MISO_CPU MOSI_CPU XCS_N_LCD RST_N_LCD A0_CPU RD_N_CPU V0_LCD WR_N_CPU CPU_D[7:0] E26 BLM18PG600SN1 VLED_HEAT_EN 3V3 3V3_CPU KB_BL_EN KEY_X[4:0] C26 C14 LCD_BL_EN LCD_BL_LEVEL KEY_Y[4:0] 100N 10U 25V C27 4.7U 50V LCD_HEAT_EN LCD_HEAT_LEVEL SDF_SW_DET XCS_N_SDF E502 BLM18PG600SN1 3V3 3V3_CPU_AN PTT_MIC_P_CPU C553 C552 10U 100N 25V RX_UART0_TTL TX_UART0_TTL RX_UART1_TTL TX_UART1_TTL 3V3 XIL_MONITOR 3V3_CPU_AN C15 4.
MM-E 2072-09333-00 3V3_IF KEYPAD 20K 12345 PAD6 !!! 1 2 3 4 3 4 1 2 SW4 PAD_SW_KEY6 3 4 1 2 SW5 PAD_SW_KEY6 3 4 1 2 R583 3 4 67890 PAD6 1 2 3 4 1 2 3 4 1 2 SW10 PAD_SW_KEY6 3 4 1 2 3+ 1- R569 3 4 VR510 3+ 1- R139 1 2 SW13 PAD_SW_KEY6 3 4 1 2 SW14 PAD_SW_KEY6 3 4 1 2 SW15 PAD_SW_KEY6 3 4 1 2 R233 R563 3 4 1 2 3 4 1 2 3 4 1 2 SW20 PAD_SW_KEY5 3 4 1 2 DS1 3 4 5 6 5 6 150 3 4 1 2 ENTER PAD6 ARRDN PAD3 SW25 PAD_SW_KEY2 3 4 1 2 150 DS4 1 1 2 2 1
MM-E 2072-09333-00 3V3 ON_OFF_CONT 13V8_DC 3V3 VLED_BL_LCD KB_BL_EN KB_BL_LEVEL VHEAT_LCD PTT_MIC_N PTT_MIC_P 4 5 14 U502 R166 6 7 ON_OFF_SW TO CPU 10 SW26 2+1 5+4 1 3 4 6 2+3 5+6 L501 13V8_DC R540 10U TRUNK ONLY MHPS2266 VLED_BL_KB LCD_HEAT_EN LCD_HEAT_LEVEL 74HC132D 10K 1 C509 100N R539 POW_OFF_CPU 8V0_AUDIO 33.2 ON_OFF_SW POW_OFF_CPU 2 25V Q507 1K BST82 U501 LM2940SX-5.0 51.1 1 TRUNK ONLY R537 C98 C97 C99 15U 4.
MM-E 2072-09333-00 R552 MIC_IN 20K 9 TX_AUDIO_P 8 4 11 TX_AUDIO_M 10 R551 R553 20K 20K 8V0_AUDIO U503 MC33174DR2 330P C520 R547 R560 470N 4.75K C517 6 7 4 11 C524 MIC_IN 10K 10K R546 5 U503 MC33174DR2 1N R557 C526 + 274 4.7U 10V 8V0_AUDIO L503 TX_AUDIO_P 4.7U C515 R543 1K C516 1N 1N C528 R548 100N R545 4 13 12 V 14 V 11 R554 C529 20K 100N 16V C523 10U 2 10K AUDIO_BIOS 1 3 R544 AUDIO_BIOS U503 MC33174DR2 U503 MC33174DR2 10K R558 C525 + 274 4.
MM-E 2072-09333-00 5V0_RS PTT_M PTT_MIC_P 3V3_UART E601 BLM18PG600SN1 E501 BLM18PG600SN1 5V0 3V3 PTT_P CH_RXD_M C602 100N C601 10U TRUNK_RX_UART0_TTL CH_RXD_P C530 10U 25V C543 100N 25V CH_TXD_M TX_UART0_TTL CH_TXD_P 5V0 3V3 TX_UART1_TTL RXD (PTP_RXD) RX_UART1_TTL TXD (PTP_TXD) SH_DN_232_N ACTIVE LOW OPSTATUS 5V0_RS R579 TX_UART0_TTL 10 L505 5V0_RS U505 C557 100N LTC485IS8 8 1 2 5 DI VCC RO DE RE A GND B R567 1K 4 3 6 7 F_OFF_N EN_N T_OUT R_OUT SHDN FORCEON X
P2 43045-1618 5V0 C26 180P PTT_M PTT_P C27 180P CH_RXD_P CH_RXD_M L5 PTT_M CH_TXD_M DI 4.7U CH_TXD_P C28 180P 100N LTC485IS8 4 3 6 7 R5 1K 10K L11 U5 4.7U SPKR_M R13 C35 L6 PTT_P SPKR_P 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 VCC DE RO A RE B GND 8 1 2 5 PTP_TXD 22U R25 C16 1N PTT_MIC_POS 10 C17 1N PTP_TXD_PNL PTP_RXD_PNL C29 180P R12 PTP_TXD_PNL 10K L10 PTP_RXD_PNL PTP_RXD 22U TX_AUDIO_P C14 1N TX_AUDIO_M ON_OFF_CONT_PNL SPKR_M R30 13V8_RADIO_TRUNK 0.
MM-E 2072-09333-00 SW_FAN 12VDC Q2 MJD2955T4 12VDC 3 4 U1 LP2951CMX 470P C7 R7 1K 8 7 2 3 R1 110 L1 CW R2 1 2 3 4 5 6 7 8 9 56.2K J1 CD729S31D4 R6 475 C10 C6 10N 2.2U + 1 22U C4 1N C3 1N 4 IN OUT FDBCK SENS 5VTAP STDN ERR 1 6 5 3 GND 1 SPKR- 2 MMBT3904LT1 10K DSO/FAN_ON_OFF C2 1N C8 IN_FROM_RADIO C9 10N Q1 L2 22U 1N R3 R4 511 511 C5 C1 1N 2.
MM-E 2072-09333-00 Appendix B PARTS LISTS Section I. MICOM-Z DASH-MOUNT VERSION Table B-1. Micom-Z Assembly Dash Version, Parts List Ref. Des. Description Mfg. Catalog No. Qty. 2072-90715-00 MICOM-Z ASSEMBLY, DASH Figure B-1 BL1 2072-95170-10 HI POWER MODULE 1.0 BL2 2072-90833-00 FRONT PANEL DASH ASSY 1.0 BL3 2072-90832-00 LORD ASSY 1.0 BL5 4053-10013-16 WASHER, SPRING, CRS, PASSIVATED, #10 1.0 BL6 4053-00037-16 WASHER, FLAT, CRS, PASSIVATED, .219 2.
MM-E 2072-09333-00 Figure B-1.A.
MM-E 2072-09333-00 Figure B-1.B.
MM-E 2072-09333-00 Table B-2. LORD Assembly, Parts List Ref. Des. Description Mfg. Catalog No. Qty. 2072-90832-00 LORD ASSEMBLY BL1 2072-95196-10 LORD MODULE 1.0 BL2 2072-48195-10 LORD PAD MACHINING 1.0 BL3 2072-48165-10 SHIELD HOUSING MACHINING 1.0 BL4 2072-90050-00 BATTERY ASSY, 0102703K64 1.0 BL5 4053-16001-00 WASHER, SPRING LOCK, M3 3.0 BL6 4052-15003-00 SCREW, CROSS RECESSED, PAN HEAD 3.0 BL7 2072-52004-00 SCREW, M3XP0.5X16 6.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List Ref. Des. Description Mfg. Catalog No. Qty. 2072-95196-10 LORD MODULE Figure B-3 BL1 2072-32200-50 PCB LORD 1.0 BL2 2072-41030-00 SPACER 2.0 BL3 4053-10010-16 WASHER, SPRING, CRS, PASSIVATED, #4 2.0 C1 2072-17107-00 CAPACITOR, TANTALUM, CHIP, 33UF, 16V 1.0 C2 2072-17107-00 CAPACITOR, TANTALUM, CHIP, 33UF, 16V 1.0 C3 2072-17105-00 CAPACITOR, TANTALUM, CHIP, 15UF, 25V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C41 2072-17031-00 CAPACITOR, CHIP, X7R, 1.8NF 1.0 C42 4017-20261-00 CAPACITOR, 0603, X7R, 1.5N, 50V 1.0 C43 4017-20261-00 CAPACITOR, 0603, X7R, 1.5N, 50V 1.0 C44 2072-17030-00 CAPACITOR, CHIP, X7R, 1.2NF 1.0 C45 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C46 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C47 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C95 4017-25279-00 CAPACITOR, CHIP, CG, 470PF, 5% 1.0 C96 4017-25279-00 CAPACITOR, CHIP, CG, 470PF, 5% 1.0 C97 4017-25279-00 CAPACITOR, CHIP, CG, 470PF, 5% 1.0 C98 4017-25279-00 CAPACITOR, CHIP, CG, 470PF, 5% 1.0 C99 4017-25279-00 CAPACITOR, CHIP, CG, 470PF, 5% 1.0 C100 2072-17032-00 CAPACITOR, CHIP, X7R, 3.3NF 1.0 C101 2072-17025-00 CAPACITOR, CHIP, X7R, 2.7NF 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. C1015 2072-17107-00 CAPACITOR, TANTALUM, CHIP, 33UF, 16V 1.0 C1016 4017-20171-00 CAPACITOR, CHIP, CERAMIC, 10NF, 100V 1.0 C1017 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1018 4017-20171-00 CAPACITOR, CHIP, CERAMIC, 10NF, 100V 1.0 C1019 4017-20171-00 CAPACITOR, CHIP, CERAMIC, 10NF, 100V 1.0 C1020 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C1059 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1060 4017-20171-00 CAPACITOR, CHIP, CERAMIC, 10NF, 100V 1.0 C1061 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1062 4017-20171-00 CAPACITOR, CHIP, CERAMIC, 10NF, 100V 1.0 C1063 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1064 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C1210 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1211 2072-17105-00 CAPACITOR, TANTALUM, CHIP, 15UF, 25V 1.0 C1212 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1213 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1214 2072-17107-00 CAPACITOR, TANTALUM, CHIP, 33UF, 16V 1.0 C1215 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C1805 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1806 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1807 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1808 4017-25293-10 CAPACITOR, CHIP, NP0, 1800PF, 1% 1.0 C1809 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1810 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C1845 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1846 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1847 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1848 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1851 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C1852 4017-25269-00 CAPACITOR, 0603, NP0, 68P, 50V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C2020 4017-20085-00 CAPACITOR, CHIP, CERAMIC, X7R, 100NF 1.0 C2021 4017-20085-00 CAPACITOR, CHIP, CERAMIC, X7R, 100NF 1.0 C2024 4017-20085-00 CAPACITOR, CHIP, CERAMIC, X7R, 100NF 1.0 C2025 4017-20085-00 CAPACITOR, CHIP, CERAMIC, X7R, 100NF 1.0 C2030 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C2031 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C2075 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C2076 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C2077 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C2078 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C2079 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C2080 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C2118 4017-20261-00 CAPACITOR, 0603, X7R, 1.5N, 50V 1.0 C2120 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C2121 4017-20266-00 CAPACITOR, CHIP, X7R, 3.9NF, 50V 1.0 C2123 2072-17017-00 CAPACITOR, CHIP, 0603, 11PF 1.0 C2124 4017-25256-00 CAPACITOR, CHIP, 5.6PF, 100V 1.0 C2125 4017-25256-00 CAPACITOR, CHIP, 5.6PF, 100V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C3028 4017-20271-00 CAPACITOR, CHIP, X7R, 10NF, 10% 1.0 C3029 4017-20271-00 CAPACITOR, CHIP, X7R, 10NF, 10% 1.0 C3031 4017-20271-00 CAPACITOR, CHIP, X7R, 10NF, 10% 1.0 C3033 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C3034 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C3035 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C4021 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C4022 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C4023 2072-17029-00 CAPACITOR, CHIP, X7R, 680PF 1.0 C4035 2072-17110-00 CAPACITOR, CHIP, 0603, X7R, 1UF 1.0 C4038 4017-20085-00 CAPACITOR, CHIP, CERAMIC, X7R, 100NF 1.0 C4039 4017-20271-00 CAPACITOR, CHIP, X7R, 10NF, 10% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C5005 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C5006 4017-20271-00 CAPACITOR, CHIP, X7R, 10NF, 10% 1.0 C5007 2072-17107-00 CAPACITOR, TANTALUM, CHIP, 33UF, 16V 1.0 C5008 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C5009 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C5010 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. C6041 4017-25276-00 CAPACITOR, CHIP, CG, 270PF, 5% 1.0 C6091 4016-23922-10 RESISTOR, 39.2K, 1%, 1/16W 1.0 C7001 4017-25259-00 CAPACITOR, CHIP, CG, 10PF, 5% 1.0 C7002 4017-25259-00 CAPACITOR, CHIP, CG, 10PF, 5% 1.0 C7003 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C7004 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C9072 4017-25271-00 CAPACITOR, CHIP, CG, 100PF, 5% 1.0 C9074 2072-17014-00 CAPACITOR, CHIP, 0805 43PF, 5% 1.0 C9075 4017-25265-00 CAPACITOR, CHIP, 0603, NP0, 33PF 1.0 C9076 2072-17011-00 CAPACITOR, CHIP, 0805 7.5PF 1.0 C9078 4017-25053-00 CAPACITOR, CHIP, CERAMIC, C0G, 3.3PF 1.0 C9080 4017-25053-00 CAPACITOR, CHIP, CERAMIC, C0G, 3.3PF 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C9490 4017-20271-00 CAPACITOR, CHIP, X7R, 10NF, 10% 1.0 C9491 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C9492 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C9496 4017-20567-00 CAPACITOR, CHIP, X7R, 10NF, 16V 1.0 C9498 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C9499 4017-20578-00 CAPACITOR, CHIP, 0402, 100NF 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. C9545 4017-25077-00 CAPACITOR, CHIP, CERAMIC, C0G, 330PF 1.0 C9548 4017-20085-00 CAPACITOR, CHIP, CERAMIC, X7R, 100NF 1.0 C9549 4017-20085-00 CAPACITOR, CHIP, CERAMIC, X7R, 100NF 1.0 C9551 4017-20578-00 CAPACITOR, CHIP, 0402, 100NF 1.0 C9552 4016-26040-10 RESISTOR, CHIP, 0603, 604, 1% 1.0 C9553 4017-20931-00 CAPACITOR, 1206, 10UF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. C9601 4017-60513-00 CAPACITOR 1.0 C9602 4017-25077-00 CAPACITOR, CHIP, CERAMIC, C0G, 330PF 1.0 C9603 4017-25077-00 CAPACITOR, CHIP, CERAMIC, C0G, 330PF 1.0 C9604 4017-20578-00 CAPACITOR, CHIP, 0402, 100NF 1.0 C9605 4017-20931-00 CAPACITOR, 1206, 10UF, 16V 1.0 C9606 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. C1FL24 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C1FL27 4017-20559-00 CAPACITOR, CHIP, X7R, 1NF, 10% 1.0 C1FL28 4017-20559-00 CAPACITOR, CHIP, X7R, 1NF, 10% 1.0 C1FL29 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C1FL30 4017-20559-00 CAPACITOR, CHIP, X7R, 1NF, 10% 1.0 C1FL31 4017-20559-00 CAPACITOR, CHIP, X7R, 1NF, 10% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. CR4 2072-21025-00 DIODE, PIN 1.0 CR5 2072-21025-00 DIODE, PIN 1.0 CR6 2072-21025-00 DIODE, PIN 1.0 CR7 2072-21025-00 DIODE, PIN 1.0 CR8 2072-21025-00 DIODE, PIN 1.0 CR9 2072-21025-00 DIODE, PIN 1.0 CR10 2072-21025-00 DIODE, PIN 1.0 CR11 2072-21025-00 DIODE, PIN 1.0 CR12 2072-21025-00 DIODE, PIN 1.0 CR13 2072-21025-00 DIODE, PIN 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. CR5004 4021-10115-35 DIODE, SCHOTTKY 1.0 CR5005 4021-10115-35 DIODE, SCHOTTKY 1.0 CR9000 4021-10360-35 VARICAP 1.0 CR9020 4021-10360-35 VARICAP 1.0 CR9040 4021-10360-35 VARICAP 1.0 CR9063 4021-10115-35 DIODE, SCHOTTKY 1.0 CR9064 4021-10115-35 DIODE, SCHOTTKY 1.0 CR9066 4021-10360-35 VARICAP 1.0 CR9067 4021-10360-35 VARICAP 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. L5 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L6 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L7 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L8 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L9 2072-18008-00 INDUCTOR, CHIP, 10000NH, 5% 1.0 L10 2072-18008-00 INDUCTOR, CHIP, 10000NH, 5% 1.0 L12 2072-18008-00 INDUCTOR, CHIP, 10000NH, 5% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. L54 4018-12036-50 INDUCTOR, RFC, 3.3UH, 5% 1.0 L55 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L1000 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L1006 4018-12320-10 INDUCTOR, RFC, 0.27 UH, 1% 1.0 L1007 4018-12320-10 INDUCTOR, RFC, 0.27 UH, 1% 1.0 L1008 4018-12320-10 INDUCTOR, RFC, 0.27 UH, 1% 1.0 L1012 4018-12329-00 INDUCTOR, CHIP, 910NH, 5 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. L1214 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L1800 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L1801 4018-12029-20 INDUCTOR, RFC, 1UH, 2% 1.0 L1802 4018-12029-20 INDUCTOR, RFC, 1UH, 2% 1.0 L1803 4018-12029-20 INDUCTOR, RFC, 1UH, 2% 1.0 L1804 4018-12029-20 INDUCTOR, RFC, 1UH, 2% 1.0 L1805 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. L3006 2072-18008-00 INDUCTOR, CHIP, 10000NH, 5% 1.0 L3007 4018-12032-20 INDUCTOR, RFC, 1.5UH, 2% 1.0 L3008 4018-12032-20 INDUCTOR, RFC, 1.5UH, 2% 1.0 L4001 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L4002 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L5000 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L5001 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. L1FL10 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L1FL11 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L1FL12 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L1FL13 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L1FL14 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L1FL15 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.0 L1FL17 4018-12206-00 INDUCTOR, CHIP, 22UH, 5% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. Q1010 4021-00343-35 TRANSISTOR, PNP 1.0 Q1011 4021-00343-35 TRANSISTOR, PNP 1.0 Q1012 4021-00343-35 TRANSISTOR, PNP 1.0 Q1013 4021-00342-35 TRANSISTOR, NPN 1.0 Q1014 4021-00342-35 TRANSISTOR, NPN 1.0 Q1015 4021-00342-35 TRANSISTOR, NPN 1.0 Q1017 4021-00342-35 TRANSISTOR, NPN 1.0 Q1018 4021-00342-35 TRANSISTOR, NPN 1.0 Q1019 4021-00342-35 TRANSISTOR, NPN 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. Q9069 4021-00342-35 TRANSISTOR, NPN 1.0 R1 4016-41000-10 RESISTOR, 2512, 100, 1%, 1W 1.0 R2 4016-41000-10 RESISTOR, 2512, 100, 1%, 1W 1.0 R3 4016-41000-10 RESISTOR, 2512, 100, 1%, 1W 1.0 R4 4016-41000-10 RESISTOR, 2512, 100, 1%, 1W 1.0 R5 4016-21003-10 RESISTOR, 100K, 1%, 1/16W 1.0 R6 4016-21003-10 RESISTOR, 100K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R82 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R1000 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R1001 4016-21829-10 RESISTOR, CHIP, 0603, 18.2, 1% 1.0 R1002 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R1003 4016-21829-10 RESISTOR, CHIP, 0603, 18.2, 1% 1.0 R1005 4016-21009-10 RESISTOR, CHIP, 0603, 10, 1% 1.0 R1006 4016-26819-10 RESISTOR, CHIP, 0603, 68.1, 1% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R1040 4016-20100-50 RESISTOR, CHIP, 10, 5%, 1/16W 1.0 R1041 4016-20100-50 RESISTOR, CHIP, 10, 5%, 1/16W 1.0 R1042 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R1043 4016-22740-10 RESISTOR, 274, 1%, 1/16W 1.0 R1044 4016-22740-10 RESISTOR, 274, 1%, 1/16W 1.0 R1045 4016-23920-10 RESISTOR, 392, 1%, 1/16W 1.0 R1046 4016-22741-10 RESISTOR, 2.74K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R1201 4016-21001-10 RESISTOR, 1.00K, 1%, 1/16W 1.0 R1202 4016-24750-10 RESISTOR, 475, 1%, 1/16W 1.0 R1203 4016-24750-10 RESISTOR, 475, 1%, 1/16W 1.0 R1204 4016-24750-10 RESISTOR, 475, 1%, 1/16W 1.0 R1205 4016-24750-10 RESISTOR, 475, 1%, 1/16W 1.0 R1206, 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R1207 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R1241 4016-21829-10 RESISTOR, CHIP, 0603, 18.2, 1% 1.0 R1242 4016-24750-10 RESISTOR, 475, 1%, 1/16W 1.0 R1243 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R1244 4016-30279-50 RESISTOR, CHIP, 2.7 5%, 1/10W 1.0 R1245 4016-30279-50 RESISTOR, CHIP, 2.7 5%, 1/10W 1.0 R1246 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R1247 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. R1827 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R1828 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R1829 4016-24751-10 RESISTOR, 4.75K, 1%, 1/16W 1.0 R1830 4016-24751-10 RESISTOR, 4.75K, 1%, 1/16W 1.0 R1831 4016-24751-10 RESISTOR, 4.75K, 1%, 1/16W 1.0 R1832 4016-60102-00 TRIMPOT, 10K 1.0 R1833 4016-25620-10 RESISTOR, CHIP, 0603, 562, 1% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R1869 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R1870 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R1871 4016-26811-10 RESISTOR, CHIP, 0603, 6.81K, 1% 1.0 R1872 4016-26811-10 RESISTOR, CHIP, 0603, 6.81K, 1% 1.0 R1899 4016-25620-10 RESISTOR, CHIP, 0603, 562, 1% 1.0 R1911 4016-23321-10 RESISTOR, 3.32K, 1%, 1/16W 1.0 R1962 4016-25620-10 RESISTOR, CHIP, 0603, 562, 1% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. R2059 4016-25620-10 RESISTOR, CHIP, 0603, 562, 1% 1.0 R2060 4016-25620-10 RESISTOR, CHIP, 0603, 562, 1% 1.0 R2061 4016-23920-10 RESISTOR, 392, 1%, 1/16W 1.0 R2062 4016-23010-10 RESISTOR, CHIP, 0603, 301, 1% 1.0 R2063 4016-23010-10 RESISTOR, CHIP, 0603, 301, 1% 1.0 R2064 4016-23010-10 RESISTOR, CHIP, 0603, 301, 1% 1.0 R2065 4016-23010-10 RESISTOR, CHIP, 0603, 301, 1% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R3025 4016-40109-50 RESISTOR, 2512, 1.0 5%, 1W 1.0 R3027 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R3029 4016-21503-10 RESISTOR, 150K, 1%, 1/16W 1.0 R3031 4016-21503-10 RESISTOR, 150K, 1%, 1/16W 1.0 R3034 4016-26192-10 RESISTOR, CHIP, 0603, 61.9K, 1% 1.0 R3043 4016-23322-10 RESISTOR, 33.2K, 1%, 1/16W 1.0 R3044 4016-23322-10 RESISTOR, 33.2K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R4005 4016-22002-10 RESISTOR, 20.0K, 1%, 1/16W 1.0 R4006 4016-22742-10 RESISTOR, 27.4K, 1%, 1/16W 1.0 R4007 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R4008 4016-23011-10 RESISTOR, 3.01K, 1%, 1/16W 1.0 R4009 4016-22001-10 RESISTOR, 2.0K, 1%, 1/16W 1.0 R4011 4016-28251-10 RESISTOR, 8.25K, 1%, 1/16W 1.0 R4012 4016-22002-10 RESISTOR, 20.0K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R4062 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R4063 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R4064 4016-21001-10 RESISTOR, 1.00K, 1%, 1/16W 1.0 R4065 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R4066 4016-22742-10 RESISTOR, 27.4K, 1%, 1/16W 1.0 R4067 4016-22001-10 RESISTOR, 2.0K, 1%, 1/16W 1.0 R4068 4016-25112-10 RESISTOR, 51.1K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R5017 4016-23922-10 RESISTOR, 39.2K, 1%, 1/16W 1.0 R5021 4016-23922-10 RESISTOR, 39.2K, 1%, 1/16W 1.0 R5022 4016-21001-10 RESISTOR, 1.00K, 1%, 1/16W 1.0 R5023 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R5024 4016-21001-10 RESISTOR, 1.00K, 1%, 1/16W 1.0 R5025 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R5027 4016-21503-10 RESISTOR, 150K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R5100 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R5101 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R5104 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R6000 4016-23922-10 RESISTOR, 39.2K, 1%, 1/16W 1.0 R6002 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R6009 4016-23922-10 RESISTOR, 39.2K, 1%, 1/16W 1.0 R6016 4016-23922-10 RESISTOR, 39.2K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R9100 4016-21829-10 RESISTOR, CHIP, 0603, 18.2, 1% 1.0 R9200 4016-20100-50 RESISTOR, CHIP, 10, 5%, 1/16W 1.0 R9300 4016-21829-10 RESISTOR, CHIP, 0603, 18.2, 1% 1.0 R9400 4016-20100-50 RESISTOR, CHIP, 10, 5%, 1/16W 1.0 R9409 4016-23922-10 RESISTOR, 39.2K, 1%, 1/16W 1.0 R9410 4016-23922-10 RESISTOR, 39.2K, 1%, 1/16W 1.0 R9411 4016-23922-10 RESISTOR, 39.2K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R9528 4016-24750-10 RESISTOR, 475, 1%, 1/16W 1.0 R9529 4016-24750-10 RESISTOR, 475, 1%, 1/16W 1.0 R9530 4016-24750-10 RESISTOR, 475, 1%, 1/16W 1.0 R9531 4016-25111-10 RESISTOR, 5.11K, 1%, 1/16W 1.0 R9532 4016-21003-10 RESISTOR, 100K, 1%, 1/16W 1.0 R9533 4016-21003-10 RESISTOR, 100K, 1%, 1/16W 1.0 R9535 4016-22001-10 RESISTOR, 2.0K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R9576 4016-22742-10 RESISTOR, 27.4K, 1%, 1/16W 1.0 R9577 4016-22002-10 RESISTOR, 20.0K, 1%, 1/16W 1.0 R9578 4016-22002-10 RESISTOR, 20.0K, 1%, 1/16W 1.0 R9579 4016-22002-10 RESISTOR, 20.0K, 1%, 1/16W 1.0 R9580 4016-22002-10 RESISTOR, 20.0K, 1%, 1/16W 1.0 R9581 4016-22002-10 RESISTOR, 20.0K, 1%, 1/16W 1.0 R9582 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R9632 4016-23013-10 RESISTOR, 301K, 1%, 1/16W 1.0 R9633 4016-50000-50 RESISTOR, CHIP, 0402, JUMPER 1.0 R9634 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R9635 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R9636 4016-51003-10 RESISTOR, CHIP, 0402, 100K 1.0 R9637 4016-55112-10 RESISTOR, CHIP, 0402, 51.1K, 1% 1.0 R9638 4016-55112-10 RESISTOR, CHIP, 0402, 51.1K, 1% 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R9678 4016-53321-10 RESISTOR, CHIP, MF, 3.32K, 0.063 1.0 R9679 4016-22001-10 RESISTOR, 2.0K, 1%, 1/16W 1.0 R9680 4016-24751-10 RESISTOR, 4.75K, 1%, 1/16W 1.0 R9688 4016-21821-10 RESISTOR, 1.82K, 1%, 1/16W 1.0 R9690 4016-26040-10 RESISTOR, CHIP, 0603, 604, 1% 1.0 R9691 4016-26040-10 RESISTOR, CHIP, 0603, 604, 1% 1.0 R9692 4016-50000-50 RESISTOR, CHIP, 0402, JUMPER 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. R1FL21 4016-51000-10 RESISTOR, CHIP, 0402, 100 1.0 R1FL23 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R1FL24 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R1FL27 4016-51000-10 RESISTOR, CHIP, 0402, 100 1.0 R1FL28 4016-51000-10 RESISTOR, CHIP, 0402, 100 1.0 R1FL29 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R1FL30 4016-51000-10 RESISTOR, CHIP, 0402, 100 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. U5005 4021-31014-64 HC, HEX SCHMITT TRIGGER 1.0 U5006 2072-21130-00 MUX/DMUX 1.0 U5007 2072-21130-00 MUX/DMUX 1.0 U5008A 2072-21036-00 IC, 68HC16 1.0 U5009 4021-62025-64 SRAM, 128KX8 1.0 U5010 4021-62025-64 SRAM, 128KX8 1.0 U5014 4021-75017-54 P.S. RESET, CONTROLLER 1.0 U6000 2072-21031-00 ASIC, DSM 1.0 U6021 2072-21045-00 REGULATOR, 5V 1.
MM-E 2072-09333-00 Table B-3. LORD Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. VR5 2072-21028-00 ZENER, 10V 1.0 VR1500 4021-10421-35 ZENER, 5.6V 1.0 VR4000 4021-10422-35 ZENER, 27V 1.0 VR5001 4021-10421-35 ZENER, 5.6V 1.0 VR5002 4021-10421-35 ZENER, 5.6V 1.0 VR5003 4021-10421-35 ZENER, 5.6V 1.0 VR5004 4021-10421-35 ZENER, 5.6V 1.0 VR5009 4021-10421-35 ZENER, 5.6V 1.0 VR5010 4021-10421-35 ZENER, 5.6V 1.
MM-E 2072-09333-00 Intentionally Left Blank B-54
MM-E 2072-09333-00 COMPONENT SIDE Figure B-3.A.
MM-E 2072-09333-00 PRINT SIDE Figure B-3.B.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List Ref. Des. Description Mfg. Catalog No. Qty. 2072-95170-10 HI POWER MODULE Figure B-4 BL1 2072-45014-00 POWER PAD 1.0 BL2 2072-32170-00 HI POWER PCB 1.0 BL3 4052-15003-00 SCREW, CROSS RECESSED, PAN HEAD 8.0 BL4 2072-33051-00 SPACER 1.0 BL5 2072-53004-00 WASHER, SHLDR 1483967A03 1.0 BL6 2072-40050-00 SHIELD, 2683423K03 1.0 BL7 2072-48026-00 SHIELD, RF 1.0 BL8 4052-12014-16 SCREW, M2X16, PAN HEAD 10.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C23 4017-20181-00 CAPACITOR, 1210, X7R, 100NF, 200V 1.0 C24 2089-17033-00 CAPACITOR, PORCELAN, 470PF, 5% 1.0 C26 4017-20165-00 CAPACITOR, CHIP, CERAMIC, 100NF, 50V 1.0 C27 4017-20165-00 CAPACITOR, CHIP, CERAMIC, 100NF, 50V 1.0 C28 2089-17033-00 CAPACITOR, PORCELAN, 470PF, 5% 1.0 C29 2089-17033-00 CAPACITOR, PORCELAN, 470PF, 5% 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C74 2089-17003-00 CAPACITOR, PORCELAN, 10PF, 5% 1.0 C75 2089-17003-00 CAPACITOR, PORCELAN, 10PF, 5% 1.0 C76 4017-20165-00 CAPACITOR, CHIP, CERAMIC, 100NF, 50V 1.0 C77 2089-17003-00 CAPACITOR, PORCELAN, 10PF, 5% 1.0 C78 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.0 C79 4017-20165-00 CAPACITOR, CHIP, CERAMIC, 100NF, 50V 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C121 4017-80234-00 CAPACITOR, CHIP, TANTALUM, 100UF, 20V 1.0 C122 4017-20165-00 CAPACITOR, CHIP, CERAMIC, 100NF, 50V 1.0 C123 4017-20109-00 CAPACITOR, 1206, X7R, 10UF 1.0 C124 4017-20109-00 CAPACITOR, 1206, X7R, 10UF 1.0 C126 4017-25279-00 CAPACITOR, CHIP, CG, 470PF, 5% 1.0 C128 4017-80226-00 CAPACITOR, CHIP, TANTALUM, 15UF, 35V 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C166 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C167 4017-20165-00 CAPACITOR, CHIP, CERAMIC, 100NF, 50V 1.0 C168 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C169 4017-20165-00 CAPACITOR, CHIP, CERAMIC, 100NF, 50V 1.0 C171 4017-20153-00 CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V 1.0 C173 4017-25271-00 CAPACITOR, CHIP, CG, 100PF, 5% 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C604 2089-17022-00 CAPACITOR, PORCELAN, 150PF, 5% 1.0 C605 2089-17013-00 CAPACITOR, PORCELAN, 56PF, 5% 1.0 C606 2089-17027-00 CAPACITOR, PORCELAN, 270PF, 5% 1.0 C701 2089-17013-00 CAPACITOR, PORCELAN, 56PF, 5% 1.0 C702 2089-17019-00 CAPACITOR, PORCELAN, 100PF, 5% 1.0 C703 4017-60012-20 CAPACITOR, PORC. 18PF, 2% 1.0 C704 2089-17017-00 CAPACITOR, PORCELAN, 82PF, 5% 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. C885 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C886 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C887 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C888 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C889 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C895 4017-20271-00 CAPACITOR, CHIP, X7R, 10NF, 10% 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. E19 4023-00014-00 ARRESTOR 1.0 E26 4018-60032-00 BEAD, EMI, 600 OHM, 1.5A 1.0 E27 4018-60032-00 BEAD, EMI, 600 OHM, 1.5A 1.0 E28 4018-60032-00 BEAD, EMI, 600 OHM, 1.5A 1.0 E29 4018-60032-00 BEAD, EMI, 600 OHM, 1.5A 1.0 K1 2338-31031-00 RELAY, 5V, DPDT 1.0 K101 2338-31031-00 RELAY, 5V, DPDT 1.0 K102 2338-31031-00 RELAY, 5V, DPDT 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. L602 2072-13023-05 COIL, RF, 0.55uH 1.0 L701 2072-13023-01 COIL, RF, 0.28uH 1.0 L702 2072-13023-01 COIL, RF, 0.28uH 1.0 P2 2072-33016-00 RECEPTACLE, COAX 1.0 P3 2072-33007-00 HEADER, RT, 40 PIN 1.0 P4 2072-33016-00 RECEPTACLE, COAX 1.0 Q1 4021-00302-35 TRANSISTOR, N-CHANNEL, DUAL 1.0 Q2 4021-00202-35 TRANSISTOR, NPN, MMBT2222A 1.0 Q3 4021-06065-35 FET, RF 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. R9 4016-21008-50 RESISTOR, CHIP, 0603, 1 OHM, 5% 1.0 R11 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R13 4016-21503-10 RESISTOR, 150K, 1%, 1/16W 1.0 R15 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R18 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R20 4016-23162-10 RESISTOR, CHIP, 0603, 31.6K, 1% 1.0 R21 4016-43329-10 RESISTOR, CHIP, 33.2, 1%, 1W 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. R62 4016-23010-10 RESISTOR, CHIP, 0603, 301, 1% 1.0 R63 4016-23010-10 RESISTOR, CHIP, 0603, 301, 1% 1.0 R64 4016-21001-10 RESISTOR, 1.00K, 1%, 1/16W 1.0 R65 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R66 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R67 4016-60102-00 TRIMPOT, 10K OHM 1.0 R68 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R111 4016-24751-10 RESISTOR, 4.75K, 1%, 1/16W 1.0 R112 4016-21502-10 RESISTOR, 15.0K, 1%, 1/16W 1.0 R114 4016-28252-10 RESISTOR, CHIP, 0603, 82.5K, 1% 1.0 R116 4016-21003-10 RESISTOR, 100K, 1%, 1/16W 1.0 R117 4016-21103-10 RESISTOR, 110K, 1%, 1/16W 1.0 R118 4016-21502-10 RESISTOR, 15.0K, 1%, 1/16W 1.0 R119 4016-21502-10 RESISTOR, 15.0K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R163 4016-21501-10 RESISTOR, 1.50K, 1%, 1/16W 1.0 R164 4016-21501-10 RESISTOR, 1.50K, 1%, 1/16W 1.0 R165 4016-21503-10 RESISTOR, 150K, 1%, 1/16W 1.0 R166 4016-22152-10 RESISTOR, 21.5K, 1%, 1/16W 1.0 R167 4016-25112-10 RESISTOR, 51.1K, 1%, 1/16W 1.0 R171 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R172 4016-21502-10 RESISTOR, 15.0K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R862 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R863 4016-22742-10 RESISTOR, 27.4K, 1%, 1/16W 1.0 R865 4016-21003-10 RESISTOR, 100K, 1%, 1/16W 1.0 R867 4016-21001-10 RESISTOR, 1.00K, 1%, 1/16W 1.0 R868 4016-22741-10 RESISTOR, 2.74K, 1%, 1/16W 1.0 R870 4016-25112-10 RESISTOR, 51.1K, 1%, 1/16W 1.0 R871 4016-29761-10 RESISTOR, CHIP, 9.76K, 1%, /16W 1.
MM-E 2072-09333-00 Table B-4. HI POWER Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. R919 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R921 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R922 4016-21820-10 RESISTOR, 182, 1%, 1/16W 1.0 R923 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R924 4016-21001-10 RESISTOR, 1.00K, 1%, 1/16W 1.0 R928 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 RT1 4016-91495-00 THERMISTOR. NTC, 1K 1.
MM-E 2072-09333-00 Figure B-4.A.
MM-E 2072-09333-00 COMPONENT SIDE Figure B-4.B.
MM-E 2072-09333-00 PRINT SIDE Figure B-4.C.
MM-E 2072-09333-00 Table B-5. Dash Front Panel, Control Head Assembly, Parts List Ref. Des. Description Mfg. Catalog No. Qty. 2072-90833-00 DASH FRONT PANEL ASSY Figure B-5 BL1 2072-45001-10 FRONT PANEL 1.0 BL2 2072-95211-00 DASH FRONT PANEL MODULE 1.0 BL3 2072-45004-00 KEYPAD 1.0 BL4 2072-90115-00 DISPLAY ASSY 1.0 BL5 2072-45007-00 WINDOW, LC 1.0 BL6 2072-45008-00 HOLDER SPEAKER 1.0 BL7 2072-45020-00 PLUG 1.0 BL8 2072-31050-00 SPEAKER (MIRS) 5002236P 1.
MM-E 2072-09333-00 Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List Ref. Des. Description Mfg. Catalog No. Qty. 2072-95211-00 DASH FRONT PANEL MODULE BL1 2072-32211-00 FRONT PANEL PCB 1.0 BL2 2072-45003-00 STUD FOR MICOM-Z 4.0 C1 4017-20153-00 CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V 1.0 C2 4017-20153-00 CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V 1.0 C3 4017-20153-00 CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V 1.0 C4 4017-20153-00 CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V 1.
MM-E 2072-09333-00 Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C54 4017-20192-00 CAPACITOR, 1210, X7R, 4.7UF, 50V 1.0 C59 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C60 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C61 4017-25271-00 CAPACITOR, CHIP, CG, 100PF, 5% 1.0 C62 4017-25271-00 CAPACITOR, CHIP, CG, 100PF, 5% 1.0 C63 4017-25271-00 CAPACITOR, CHIP, CG, 100PF, 5% 1.
MM-E 2072-09333-00 Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. C121 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C501 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C502 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.0 C503 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.0 C504 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.0 C505 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.
MM-E 2072-09333-00 Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. DS23 4021-80052-35 LED, GREEN 1.0 DS24 4021-80052-35 LED, GREEN 1.0 DS25 4021-80052-35 LED, GREEN 1.0 DS26 4021-80052-35 LED, GREEN 1.0 DS27 4021-80052-35 LED, GREEN 1.0 E19 4018-60017-00 BEAD, EMI, 60 OHM, 500mA 1.0 E20 4018-60030-00 BEAD, EMI, 75 OHM, 200mA 1.0 E26 4018-60017-00 BEAD, EMI, 60 OHM, 500mA 1.
MM-E 2072-09333-00 Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. Q507 4021-00415-35 FET 1.0 R1 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R2 4016-11009-10 RESISTOR, CHIP, 10.0K, 1%, 1/8W 1.0 R3 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R4 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R5 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R9 4016-22210-10 RESISTOR, 221, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R45 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R46 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R47 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R48 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R49 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R50 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R51 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.
MM-E 2072-09333-00 Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R85 4016-50000-50 RESISTOR, CHIP, 0402, JUMPER 1.0 R86 4016-50000-50 RESISTOR, CHIP, 0402, JUMPER 1.0 R87 4016-51002-10 RESISTOR, CHIP, MF, 10K, 0.06W 1.0 R88 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R89 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R90 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R91 4016-52219-10 RESISTOR, CHIP, 0402, 22.
MM-E 2072-09333-00 Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R125 4016-21500-10 RESISTOR, CHIP, MF, 150E, 0.063W 1.0 R126 4016-21500-10 RESISTOR, CHIP, MF, 150E, 0.063W 1.0 R127 4016-11500-10 RESISTOR, CHIP, 150, 1%, 1/8W 1.0 R128 4016-11500-10 RESISTOR, CHIP, 150, 1%, 1/8W 1.0 R133 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R137 4016-22002-10 RESISTOR, 20.0K, 1%, 1/16W 1.
MM-E 2072-09333-00 Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R204 4016-43329-10 RESISTOR, CHIP, 33.2, 1%, 1W 1.0 R206 4016-25111-10 RESISTOR, 5.11K, 1%, 1/16W 1.0 R207 4016-25111-10 RESISTOR, 5.11K, 1%, 1/16W 1.0 R212 4016-22213-10 RESISTOR, 221K, 1%, 1/16W 1.0 R213 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R214 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.
MM-E 2072-09333-00 Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. R536 4016-18251-10 RESISTOR, CHIP, 8.25K, 1%, 1/8W 1.0 R538 4016-24029-10 RESISTOR, CHIP, 0603, 40.2, 1% 1.0 R539 4016-23329-10 RESISTOR, CHIP, 0603, 33.2, 1% 1.0 R541 4016-28669-10 RESISTOR, CHIP, 0603, 86.6, 1% 1.0 R563 4016-21101-10 RESISTOR, 1.10K, 1%, 1/16W 1.0 R569 4016-21101-10 RESISTOR, 1.10K, 1%, 1/16W 1.
MM-E 2072-09333-00 Intentionally Left Blank B-90
MM-E 2072-09333-00 COMPONENT SIDE PRINT SIDE Figure B-6.
MM-E 2072-09333-00 Section II. MICOM-Z TRUNK-MOUNT VERSION Table B-7. Micom-Z Assembly, Trunk Version, Parts List Ref. Des. Description Mfg. Catalog No. Qty. 2072-90719-20 MICOM-Z ASSEMBLY, TRUNK BL1 2072-95170-10 HI POWER MODULE Figure B-7 1.0 BL2 2072-45029-10 BLANK PANEL 1.0 BL3 2072-90832-00 LORD ASSY 1.0 BL5 4053-10013-16 WASHER, SPRING, CRS, PASSIVATED, #10 1.0 BL6 4053-00037-16 WASHER, FLAT, CRS, PASSIVATED, .219 2.0 BL7 4051-00011-16 NUT, HEX, CRS, PASSIVATED, #10-32 1.
MM-E 2072-09333-00 Figure B-7.A.
MM-E 2072-09333-00 Figure B-7.B.
MM-E 2072-09333-00 Table B-8. LORD Assembly, Parts List The LORD assembly used in the Micom-Z trunk version is identical to the LORD assembly used in the Micom-Z dash version. See page B-4 to page B-58.
MM-E 2072-09333-00 Table B-9. HI POWER Module, Parts List The HI POWER module used in the Micom-Z trunk version is identical to the HI POWER module used in the Micom-Z dash version. See page B-59 to page B-78.
MM-E 2072-09333-00 Table B-10. Trunk Front Panel, Control Head Assembly, Parts List Ref. Des. Description Mfg. Catalog No. Qty. 2072-90831-00 FRONT PANEL TRUNK ASSY BL1 2072-45015-10 FRONT PANEL 1.0 BL2 2072-95211-10 FRONT PANEL MODULE TRUNK 1.0 BL3 2072-45004-00 KEYPAD 1.0 BL4 2072-90115-00 DISPLAY ASSY 1.0 BL5 2072-45007-00 WINDOW LC 1.0 BL6 2072-45036-00 INSERT 1.0 BL7 2072-45020-00 PLUG 1.0 BL8 2072-45027-10 REAR PANEL 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List Ref. Des. Description Mfg. Catalog No. Qty. 2072-95211-10 FRONT PANEL MODULE TRUNK Figure B-9 BL1 2072-32211-00 FRONT PANEL PCB 1.0 BL2 2072-45003-00 STUD FOR MICOM-Z 4.0 C1 4017-20153-00 CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V 1.0 C2 4017-20153-00 CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V 1.0 C3 4017-20153-00 CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V 1.0 C4 4017-20153-00 CAPACITOR, CHIP, CERAMIC, 2.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C54 4017-20192-00 CAPACITOR, 1210, X7R, 4.7UF, 50V 1.0 C59 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C60 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C61 4017-25271-00 CAPACITOR, CHIP, CG, 100PF, 5% 1.0 C62 4017-25271-00 CAPACITOR, CHIP, CG, 100PF, 5% 1.0 C63 4017-25271-00 CAPACITOR, CHIP, CG, 100PF, 5% 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. C121 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C501 4017-25282-00 CAPACITOR, CHIP, CG, 1NF, 5% 1.0 C502 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.0 C503 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.0 C504 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.0 C505 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. C540 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.0 C541 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.0 C542 4017-25274-00 CAPACITOR, 0603, NP0, 180PF, 50V 1.0 C543 4017-20284-00 CAPACITOR, CHIP, CERAMIC, 100NF, 16V 1.0 C544 4017-20192-00 CAPACITOR, 1210, X7R, 4.7UF, 50V 1.0 C545 4017-20578-00 CAPACITOR, CHIP, 0402, 100NF 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. DS17 4021-80052-35 LED, GREEN 1.0 DS18 4021-80052-35 LED, GREEN 1.0 DS19 4021-80052-35 LED, GREEN 1.0 DS20 4021-80052-35 LED, GREEN 1.0 DS21 4021-80052-35 LED, GREEN 1.0 DS22 4021-80052-35 LED, GREEN 1.0 DS23 4021-80052-35 LED, GREEN 1.0 DS24 4021-80052-35 LED, GREEN 1.0 DS25 4021-80052-35 LED, GREEN 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. P4 4033-51007-01 HEADER, 2 PIN 1.0 P5 4033-50225-01 STRIP, DOUBLE ROW, 5 PIN 1.0 P6 2072-33325-00 CONNECTOR, MIC 1.0 P7 4033-50212-01 STRIP, SINGLE ROW, 2 PIN 1.0 P501 4033-51315-00 CONNECTOR, HEADER, DUAL ROW, 16 PIN 1.0 Q1 4021-00183-35 MOSFET, P-CHANNEL 1.0 Q2 4021-00299-35 MOSFET, N-CHANNEL 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R28 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R29 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R30 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R31 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R32 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R33 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R34 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R68 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R69 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R70 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R71 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R72 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R73 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.0 R74 4016-52219-10 RESISTOR, CHIP, 0402, 22.1 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R108 4016-51002-10 RESISTOR, CHIP, MF, 10K, 0.06W 1.0 R109 4016-51002-10 RESISTOR, CHIP, MF, 10K, 0.06W 1.0 R110 4016-51002-10 RESISTOR, CHIP, MF, 10K, 0.06W 1.0 R111 4016-51002-10 RESISTOR, CHIP, MF, 10K, 0.06W 1.0 R112 4016-51002-10 RESISTOR, CHIP, MF, 10K, 0.06W 1.0 R113 4016-51002-10 RESISTOR, CHIP, MF, 10K, 0.06W 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R166 4016-21009-10 RESISTOR, CHIP, 0603, 10, 1% 1.0 R167 4016-14750-10 RESISTOR, CHIP, 475, 1%, 1/8W 1.0 R170 4016-23329-10 RESISTOR, CHIP, 0603, 33.2, 1% 1.0 R177 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.0 R178 4016-23011-10 RESISTOR, 3.01K, 1%, 1/16W 1.0 R181 4016-20000-50 RESISTOR, CHIP, 0603, JUMPER 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R516 4016-23011-10 RESISTOR, 3.01K, 1%, 1/16W 1.0 R517 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R518 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R519 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R520 4016-21000-10 RESISTOR, 100, 1%, 1/16W 1.0 R521 4016-21002-10 RESISTOR, 10.0K, 1%, 1/16W 1.0 R522 4016-21002-10 RESISTOR, 10.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. R557 4016-22740-10 RESISTOR, 274, 1%, 1/16W 1.0 R558 4016-22740-10 RESISTOR, 274, 1%, 1/16W 1.0 R559 4016-22741-10 RESISTOR, 2.74K, 1%, 1/16W 1.0 R560 4016-24751-10 RESISTOR, 4.75K, 1%, 1/16W 1.0 R561 4016-21001-10 RESISTOR, 1.00K, 1%, 1/16W 1.0 R562 4016-21001-10 RESISTOR, 1.00K, 1%, 1/16W 1.0 R563 4016-21101-10 RESISTOR, 1.
MM-E 2072-09333-00 Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. U504 4021-70098-54 LINE TRANSCEIVER, RS-485 1.0 U505 4021-70098-54 LINE TRANSCEIVER, RS-485 1.0 U506 4021-70098-54 LINE TRANSCEIVER, RS-485 1.0 U507 4021-70697-64 RS232, 2TX+2RX 1.0 VR1 4021-10471-35 ZENER, 4.3V 1.0 VR2 4021-10471-35 ZENER, 4.3V 1.0 VR501 4021-10810-35 ZENER, 3.6V 1.0 VR502 4021-10471-35 ZENER, 4.3V 1.
MM-E 2072-09333-00 Intentionally Left Blank B-112
MM-E 2072-09333-00 COMPONENT SIDE PRINT SIDE Figure B-9.
MM-E 2072-09333-00 Table B-12. INTERCONNECTION Module, Parts List Ref. Des. Mfg. Catalog No. Description Qty. 2072-95212-00 INTERCONNECTION MODULE Figure B-10 BL1 2072-32212-00 INTERCONNECTION PCB 1.0 C1 2072-17821-00 CAPACITOR, CHIP, X7R, 390NF, 16V 1.0 C2 2072-17821-00 CAPACITOR, CHIP, X7R, 390NF, 16V 1.0 C3 2072-17821-00 CAPACITOR, CHIP, X7R, 390NF, 16V 1.0 C4 2072-17821-00 CAPACITOR, CHIP, X7R, 390NF, 16V 1.0 C5 2072-17821-00 CAPACITOR, CHIP, X7R, 390NF, 16V 1.
MM-E 2072-09333-00 Table B-12. INTERCONNECTION Module, Parts List (Cont’d) Ref. Des. Description Mfg. Catalog No. Qty. L1 4018-12052-00 COIL, FIXED, 4.7UH 1.0 L2 4018-12052-00 COIL, FIXED, 4.7UH 1.0 L3 4018-12052-00 COIL, FIXED, 4.7UH 1.0 L4 4018-12052-00 COIL, FIXED, 4.7UH 1.0 L5 4018-12052-00 COIL, FIXED, 4.7UH 1.0 L6 4018-12052-00 COIL, FIXED, 4.7UH 1.0 L7 4018-10016-00 COIL, CHIP, 22UH, 10% 1.0 L8 4018-10016-00 COIL, CHIP, 22UH, 10% 1.
MM-E 2072-09333-00 Table B-12. INTERCONNECTION Module, Parts List (Cont’d) Ref. Des. Mfg. Catalog No. Description Qty. R27 4016-65620-10 RESISTOR, CHIP, 562, 1%, 1/2W 1.0 R29 4016-10000-10 RESISTOR, CHIP, 1/8W, JUMPER 1.0 R30 4016-10000-10 RESISTOR, CHIP, 1/8W, JUMPER 1.0 U1 4021-20084-54 OPERATIONAL AMPLIFIER, MC33072D 1.0 U2 4021-20010-54 VOLTAGE REGULATOR, ADJUSTABLE, LP2951 1.0 U3 4021-70098-54 LINE TRANSCEIVER, RS-485 1.0 U4 4021-70098-54 LINE TRANSCEIVER, RS-485 1.
MM-E 2072-09333-00 COMPONENT SIDE PRINT SIDE Figure B-10.
MM-E 2072-09333-00 Section III. COOLING TRAY Table B-13. Cooling Tray Assembly, Parts List Ref. Des. Description Mfg. Catalog No. Qty. BL1 2072-45037-00 COOLING TRAY BL2 4056-90028-88 PROTECTIVE BUFFER Figure B-11 4.0 BL3 2072-52039-00 SCREW, M3×10, PHILIPS BLACK 4.0 BL4 4052-15008-00 CROSS COUNTERSUNK HEAD 4.0 BL5 2072-40970-00 GRILL FOR FAN, 1308116L0 1.0 BL6 2072-51002-00 NUT, M4X0.7 HEX SSTP 4.0 BL7 4053-15001-00 FLAT WASHER 8.0 BL8 4053-70002-16 WASHER, SPRING, M4 4.
MM-E 2072-09333-00 Table B-14. FAN CONTROL Module, Parts List Ref. Des. Mfg. Catalog No. Description Qty. 2072-95235-00 FAN CONTROL MODULE C1 4017-25282-00 CAPACITOR, 1NF, 06035A102JAT2A 1 C2 4017-25282-00 CAPACITOR, 1NF, 06035A102JAT2A 1 C3 4017-25282-00 CAPACITOR, 1NF, 06035A102JAT2A 1 C4 4017-25282-00 CAPACITOR, 1NF, 06035A102JAT2A 1 C5 4017-80112-02 CAPACITOR, 2.2UF, 293D225X0035C2T 1 C6 4017-80112-02 CAPACITOR, 2.
MM-E 2072-09333-00 Table B-15. Fan Harness Assembly, Parts List Description Ref. Des. Qty. 1 WIRE HARNESS Figure B-13 2 CONNECTOR, 9 PIN, D-TYPE, FEMALE 1 3 FAN, 298DHLP11000 1 4 5.3 mm DC PHONE JACK 1 5 1/4" PHONE JACK 1 6 SCREW, 4-40 UNC, 23.
MM-E 2072-09333-00 Intentionally Left Blank B-122