Charisma Shower Door & Base SHOWER DOOR AND BASE INSTALLATION INSTRUCTIONS PLEASE REVIEW THIS ENTIRE MANUAL PRIOR TO INSTALLATION STEP 1: Install Shower Base STEP 2: Install Shower Door 1-866-731-2244 For more information about DreamLine® products please visit DreamLine.
©2018 DreamLine. All Rights Reserved SLIMLINE SHOWER BASE SHOWER BASE DIMENSIONS AND INSTALLATION INSTRUCTIONS IMPORTANT DreamLine® reserves the right to alter, modify or redesign products at any time without prior notice for the purpose of product improvement and customer experience. Please refer to the model’s web page on DreamLine.com for the latest technical drawings, installation manuals, warranty information or additional product details.
©2018 DreamLine. All Rights Reserved Preparation 1. Prior to installation, examine all boxes and packages for shipping damage and compare the piece count with your packing slip. After opening all boxes and packages read this introduction carefully. Check that all of the parts are included in the package by checking off the components on the parts list.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine.
©2018 DreamLine. All Rights Reserved Shower Base Cross Section Diagram Finished Wall Shower Base Cement board (2"×4") Stud Mortar Drain* * not included This product should be installed by someone familiar with the construction requirements for this type of project and the care necessary for the safe installation and operation of the product.
©2018 DreamLine. All Rights Reserved Shower Base Installation - Preparation 1. Ensure that the floor and the studs are at right angles. Provide a 5”×5” opening in the subfloor for the drain. The 2” PVC waste pipe should extend above the surface of the sub-floor according to the drain installation instructions and the height of the Shower base. Refer to the product drawings and tables in this installation manual for the drain location.
©2018 DreamLine. All Rights Reserved 2. Install the shower drain (NOT INCLUDED) according to the drain installation manual (supplied with the drain). (Fig 2) Fig 2 3. Place the tray into the designated position so that the Drain cutout drops around the Drain Pipe and butt the Shower Base up against the studs. (Fig 3) Lower the base over the drain pipe and set it into place against the studs.
©2018 DreamLine. All Rights Reserved 4. Level the tray and place marks on the studs above the upper edge of the tile flange. (Fig 4) Level base in two directions Fig 4 5. Mix the bedding material (Mortar, cement-sand mix, etc.) Concrete or plaster is not recommended. Apply enough bedding material to support the entire bottom of the shower base. This will add additional stability and prevent the base from shifting position.
©2018 DreamLine. All Rights Reserved 6. After the bedding material has been poured and before it sets, place the shower base into the position with the drain assembly sliding over the PVC waste pipe. It will be necessary to push the shower base until the top of the tile flange aligns with the marks drawn on the studs and the front edge is contacting the rough floor along the entire length of the shower base. Ensure that the base is level in all directions.
©2018 DreamLine.
©2018 DreamLine. All Rights Reserved Product Maintenance BASES and BACKWALLS: To ensure long lasting life for your acrylic base and/or back walls: wipe them off after each use with a soft cloth. To clean the acrylic base or back walls use non-abrasive sprays or cream-based cleaners. Avoid the use of aerosol spray cleaners. Never use abrasive cleansers, metal brushes or scrapers that could scratch or dull the surface.
TEL: 866-731-2244 FAX: 866-857-3638 DREAMLINE.COM For more information on DreamLine® Shower Doors and Enclosures please visit DreamLine.com ©2018 DreamLine.
CHARISMA ® d e e SHOWER DOOR INSTALLATION I NSTRUCTIONS n v i r L e s m e PLEASE REVIEW THIS ENTIRE MANUAL PRIOR TO INSTALLATION a R e r s D ght © Ri All ® e r n i L e s m e a R e Dr ghts © Ri All d e v MODEL #s: SHDR-1348760-## SHDR-1360760-## ##=finish 01- Chrome 04- Brushed Nickel IMPORTANT! DreamLine® reserves the right to alter, modify or redesign products at any time without prior notice for the purpose of product improvement and customer experience.
©2020 DreamLine® All Rights Reserved NOTES d e e n v i r L e s m e a R e Dr ghts © Ri All ® d e e n v i r L e s m e a R e Dr ghts © Ri All ® Record the following purchase information for your records or in the event you need to contact Purchase Order Number Store/Vendor Purchased From Installation Date OD Number (optional) Installed By: SKU Number CHARISMA Shower Door Manual Ver 4 052020 ® : *found on the shipping box or label if available.
Section Title Warnings and General Preparaton Model Specific Preparation Tools Detailed Diagram of Shower Door Components Parts List Installation Steps Door Glass Installation Roller Assembly Adjustment Procedure Towel Bar Handle Installation Product Maintenance Troubleshooting Factory Parts Information d e e n v i r L e s m e a R e Dr ghts © Ri All ® d e e n v Symbol Legendi r L e s m e a R e Dr ghts © Ri All Page # 2 3 4 5 6-7 8-19 16 16 16 20 21 22-23 ® TIP TIP - for ease of installation.
d e e n v i r L e s m e a R e r s D ght © Ri All IMPORTANT • • • DreamLine® reserves the right to alter, modify or redesign products any time without prior notice for product improvement and customer experience. Please refer to the model’s web page on DreamLine.com for the latest technical drawings, installation manuals, warranty information or additional product details.
©2020 DreamLine® All Rights Reserved Model Specific Preparation ! REQUIRED: No Out-of-Plumb Adjustment; Verify threshold and walls with a level ±0.0 d e e n v i r L e s m e a R e Dr ghts © Ri All ® Threshold must be level Acrylic Tile TIP ±0.0 2” (50.8mm) minimum threshold 2” (50.08mm) minimum threshold Contact the manufacturer of the base, tub or threshold material with any questions regarding the drilling of holes into their product.
©2020 DreamLine® All Rights Reserved Tools Tape Measure Level Pencil Phillips Screwdriver d e e n v i r L e s m e a R e Dr ghts © Ri All ® Silicone Painter’s Tape Drill bit 5/16” (8mm) Power Drill Power Driver Drill bit 3/16" (5mm) Compound Hack Saw OR Miter Saw Drill bit 1/8" (3mm) Mallet Metal File Measure the finished opening before proceeding with the installation to be sure that the correct model size has been ordered.
CHARISMA Shower Door Manual Ver 4 052020 5 2 inside 6 04 12a 09 inside ® The glass surface with the ClearMax™ label must be installed facing the inside of the shower d e e in erv L s m e a R e r s t D gh © Ri l l A 12b The glass surface with the ClearMax™ label must be installed facing the inside of the shower d e e in erv L s m e a R e r s t D gh © Ri All 3 3 01 Detailed Diagram of Shower Door Components ® 10 13 05 08 ©2020 DreamLine® All Rights Reserved 12c inside 16 11
©2020 DreamLine® All Rights Reserved Parts List 03 02 01 d e e n v i x1er L x1 s m e a R e r s D ght 06 © R05i All ® Top Guide Rail 04 Towel Bar Handle Bottom Guide Rail x2 09 08 x4 Wall Anchor, 8mm Door Glass ST4.0 x16mm Pan Head Screw x2 x6 10 cap washer ST4.
©2020 DreamLine® All Rights Reserved Parts List 15 16 d e e n v i r L e x1 x4 s m e a R e Dr ghts © Ri All ® 3mm Hex Wrench ST4.
©2020 DreamLine® All Rights Reserved Installation Steps 1 W-Top *at model height NOTE ________” d e e n v i r L e s m e a R e Dr ghts © Ri All ® Measure and use a level to check for any out-of-plumb condition. W W-Middle If the Finished Opening Width (W) is less than 48” (1219.2mm) or 60” (1524mm), the Top Guide Rail (#01) and the Bottom Guide Rail (#02) must be cut to: W = Finished Opening (-) 1/16” (1.
©2020 DreamLine® All Rights Reserved 2 NOTE Before marking its desired position, make sure the Bottom Guide Rail (#02) is parallel to the front edge of the shower base or tub deck. d TIP e e n v i r L e s m e a R e Dr1 ghts 2 © Ri All ® Use a good quality waterproof, mildew-resistant 100% silicone caulk. 3 d e e n v i r L e s m e a R e Dr ghts © Ri All Fig 2 TIP ® Use painter’s tape to secure the Bottom Guide Rail (#02) in place while the silicone caulk cures.
©2020 DreamLine® All Rights Reserved 3 Plumb ±0.0 d e e n v r 74”i m) L e m s m 880e base e a 1 ( R e th r m s o D gfrht © Ri All ® Draw the plumb line from the outside edge of the Bottom Guide Rail (#02) Fig 3a NOTE From the base or threshold deck, draw a plumb line up at least 74” (1880mm). *see Fig 3a d e e n v i r L e s m e a R e Dr ghts © Ri All ® 74” mm) 0 8 8 (1 Parts Needed 11 x2 NOTE At the 74-inch measurement, mark this location to properly install the Guide Rail Bracket (#11).
CHARISMA Shower Door Manual Ver 4 052020 11 4 Fig 4 NOTE TIP 4 ◾If a stud is present behind the wall: drill a Ø3/16”(4mm) hole up to the stud, drill an Ø1/8” (3mm) pilot hole into the stud and use the ST4.0 x 40mm Pan Head Screws (#08) OR ◾If no stud is present behind the wall: drill a Ø5/16”(7mm) hole and insert the Wall Anchors, 8mm (#05) and use the ST4.0 x 40mm Pan Head Screws (#08).
CHARISMA Shower Door Manual Ver 4 052020 12 4 5 NOTE 5 6 ® NOTE Ø5/16” (8mm) drill bit Fig 5b *see NOTE on page 11 ±0.0 3 Level d e v 7 Tools Needed 05 08 01 11 x4 x4 x1 x2 Parts Needed ©2020 DreamLine® All Rights Reserved Repeat Step 4 to mount the second Guide Rail Bracket (#11) to the opposite wall.
CHARISMA Shower Door Manual Ver 4 052020 13 6 Fig 6 NOTE ! ® 4 outside The Top Guide Rail (#01) must be installed level and parallel to the Bottom Guide Rail (#02) to ensure proper operation of the doors! d e e in erv L s m e a R e r s t D gh © Ri l l A 3 outside d e e in erv L s m e a R e r s t D 1 gh 2 © Ri All 10 01 x4 x1 Parts Needed ©2020 DreamLine® All Rights Reserved Ensure that all Roller Assemblies (#10) face towards the outside of the shower and only two roller assemblies are i
CHARISMA Shower Door Manual Ver 4 052020 14 NOTE 7 ® d e v drill the holes using the same Ø1/8” (3mm) drill bit. e r n i L e s m e a sR e r t D h gholes in the Use a Ø1/8” (3mm) drill bit© to mark the drill i R underside of the Top Guide Rail (#01) through the holes in the l l bottom of the brackets.
CHARISMA Shower Door Manual Ver 4 052020 15 8 NOTE d e e in erv L s m e a R e r s t D gh © Ri l l A ® Secure the Top Guide Rail (#01) to both of the Guide Rail Brackets (#11) with the ST4.0×10mm Pan Head Screws (#16).
©2020 DreamLine® All Rights Reserved 9 ! To avoid glass-to-metal contact, use 0-5/16” wedged shims when installing the Door Glass (#03) onto the Roller Assemblies (#10)! d e e n v i r L e s m e a R e Dr ghts © Ri All Fig 9 ® NOTE Secure the Door Glass (#03) onto the Roller Assemblies (#10) and fasten them with the provided bolts.
CHARISMA Shower Door Manual Ver 4 052020 17 ! 5 4 Washer (#14) Ensure the Decorative Cover (#14) washer is present when securing the Guide Blocks with the ST4.0×16mm Pan Head Screws (#06)! Decorative Cap (#14) ST4.0×16mm Round Head Screw (#06) 2 NOTE ® 1 d e v Be sure the Guide Blocks (#12) are inserted under the lip on the Bottom Guide Rail (#02) prior to drilling screw holes.
CHARISMA Shower Door Manual Ver 4 052020 18 3 1 NOTE 12 ® Fig 12 Move the Door Glass (#03) to the left and repeat the instructions from Step 11 to install the Middle (#12b) and Right (#12c) Guide Blocks into the pre-drilled holes in the Bottom Guide Rail (#02) using the ST4.0×16mm Pan Head Screws (#06). Cover the Guide Block screw heads with the Decorative Cover (#09) caps. Ensure the Decorative Cover (#14) washer is present when securing the Guide Blocks with the ST4.
©2020 DreamLine® All Rights Reserved 13 TIP d e e n v i r L e s m e a R e Dr ghts © Ri l l A Fig 13 ®Trim the bottom of the Bumper Vinyls (#13) to prevent binding in the guide blocks when installing them on the vertical edges of the Door Glass (#03). 14 24 Hours NOTE The surfaces need to be clean and free of debris before applying silicone.
©2020 DreamLine® All Rights Reserved Product Maintenance BASES and BACKWALLS: To ensure long lasting life for your acrylic back walls: wipe them off after each use with a soft cloth. To clean the acrylic back walls use non-abrasive sprays or cream based cleaners. Avoid the use of aerosol spray cleaners. Never use abrasive cleansers, metal brushes or scrapers that could permanently scratch or dull the surface.
©2020 DreamLine® All Rights Reserved Troubleshooting Problem/Symptom Suggested Solution •Check all shipping/packaging material for missing parts/components. Missing Parts •If not found, contact DreamLine Customer Support [1-866-731-2244] to order factory part replacement.
CHARISMA Shower Door Manual Ver 4 052020 22 ITEM # 01 02 03 04 05 06 08 09 10 11 12a 12b 12c 13 16 ITEM DESCRIPTION ® Top Guide Rail Bottom Guide Rail Door Glass Towel Bar Handle Assembly for 8mm (5/16 in) Glass Wall Anchor 8mm (5/16in) ST4.0 x 16mm Pan Head Screw ST4.
CHARISMA Shower Door Manual Ver 4 052020 23 ITEM # 01 02 03 04 05 06 08 09 10 11 12a 12b 12c 13 16 ® Top Guide Rail Bottom Guide Rail Door Glass Towel Bar Handle Assembly for 8mm (5/16 in) Glass Wall Anchor 8mm (5/16in) ST4.0 x 16mm Pan Head Screw ST4.
©2020 DreamLine® All Rights Reserved NOTES d e e n v i r L e s m e a R e Dr ghts © Ri All ® d e e n v i r L e s m e a R e Dr ghts © Ri All ® CHARISMA Shower Door Manual Ver 4 052020 24
©2020 DreamLine® All Rights Reserved NOTES d e e n v i r L e s m e a R e Dr ghts © Ri All ® d e e n v i r L e s m e a R e Dr ghts © Ri All ® CHARISMA Shower Door Manual Ver 4 052020 25
d e e n v i r L e s m e a R e Dr ghts © Ri All ® TEL: 866-731-2244 FAX: 866-857-3638 DREAMLINE.COM For more information on DreamLine® Shower Doors and Enclosures please visit DreamLine.