Wireless Joystick Control User manual 2.
1 Dockmate is a registered trademark from PPA-Electronics B.V. Leuvensesteenweg 177 – BE-3191 Boortmeerbeek – Belgium VAT BE 0891.773.260 – Tel. +32 (0)15 43 39 94 – Mob. +32 (0)475 45 37 35 info@dockmate.eu – www.dockmate.eu – info@ppa-electronics.com – www.ppa-electronics.
2 Congratulations on your purchase of a DOCKMATE TWIST system. Please read the following instructions carefully before getting started. DOCKMATE is a wireless system that enables you to maneuver your ship. With your fingertips you can control the engines, horn, bow- and stern thruster and anchor winch. IMPORTANT: Read the precautions before first use! Contents 1. What’s in the box ? 2. Precautions 3. Installation 4. Use of the DOCKMATE 5. Charging the batteries 6. Turning on the transmitter 7.
3 1. What’s in the box ? - This user manual Installation manual The DOCKMATE Receiver The DOCKMATE TWIST transmitter Dockmate Cradle/wireless charger Lanyard All necessary wiring cut to length Antenna 2. Precautions To avoid damage to your DOCKMATE and hurting yourself or others, you should read the following safety precautions before using the device. Keep these safety instructions in an area where all users can read them.
4 2.6. Keep out of reach of children. The devices contain small parts which can be swallowed by children. Beware for suffocation by plastic packaging. 2.7. The DOCKMATE may only be used by persons who have the necessary skills of maneuvering a yacht. 2.8. Be careful with the lanyard. Keep it away from small children (choking hazard). 2.9. Do not use the DOCKMATE when the transmitter or receiver have been immersed in water. The units may be damaged beyond repair.
5 3. Installation The installation has to be done by a qualified engineer. Our system consists of two major components: a transmitter and a Receiver. These have already been paired so they recognize each other. 3.1. Installation of the Receiver Dimensions rev.G : 23,8 x 20,5 x 8,6 cm or 9.4 x 7.9 x 3.2” Install the Receiver in a dry, not too warm area. Install the Receiver free of vibrations.
6 4. Use of the DOCKMATE Dockmate is a registered trademark from PPA-Electronics B.V. Leuvensesteenweg 177 – BE-3191 Boortmeerbeek – Belgium VAT BE 0891.773.260 – Tel. +32 (0)15 43 39 94 – Mob. +32 (0)475 45 37 35 info@dockmate.eu – www.dockmate.eu – info@ppa-electronics.com – www.ppa-electronics.
7 We recommend that you always wear the lanyard around your neck while using the DOCKMATE. The transmitter has the following features : LINK LED Shows the status of connection with the Receiver. It also shows warnings and errors if there are any. Status LED Shows the status of the transmitter. It also shows if any special options have been activated through Dockmate. BUZZER & VIBRATOR Indicates no communication, low battery, warning or error.
8 By moving the joystick astern both engines are switched to the rear. Moving the joystick to the left makes both (if installed) thrusters move the boat to port. Moving the joystick to the right makes both thrusters move the boat to starboard. In case the boat has 2 engines and only a bow thruster, moving the joystick sideways will engage the bow thruster and 2 engines in order to walk the boat sideways.
9 5. Charging the batteries The Dockmate TWIST transmitter is fitted with a Li-Ion battery that has to be charged occasionally. When the Dockmate TWIST transmitter is turned on, both LEDs will go white. Then the Status LED will show one of the following: Battery fully charged More than 3.90V Battery OK Between 3.45V and 3.90V Battery Warning Between 3.45V and 3.30V Battery Failed Less than 3.30V Battery Failed Less than 3.
10 6. Turning the transmitter on and off Press the key for 1 second to turn on the transmitter. The transmitter will be automatically switched off after 30 minutes of non use. Alternatively the transmitter can be switched off by pressing 3 times the button or holding it down for 3 sec. After the transmitter is switched on, both LEDs will go white. Then the LINK light will go dark and the STATUS LED will show one of following: Battery fully charged More than 3.90V Battery OK Between 3.45V and 3.
11 Then it will go dark and the LINK light will show the communication status: Communication OK, actively transmitting data When moving the joystick or pressing a button Communication OK, standby mode When not moving the joystick or pressing any button for more than 5s Communication lost When communication could not been established or was interrupted. The transmitter also beeps.
12 8. Troubleshooting PROBLEM POSSIBLE CAUSE The Receiver does not work. The Dockmate transmitter is switched off. SOLUTION Switch on (see point 6 in this manual). The Dockmate Receiver does not receive D/C Volts. Check : fuse blown ? The transmitter does not work. The batteries are empty. Charge the batteries (see point 5 in this manual). The LED low battery on the transmitter is on. The batteries are empty. Charge the batteries (see point 5 in this manual).
13 9. Technical specifications Transmitter Joystick: Dimensions: Weight: Frequency : Range: Housing: Battery: Operating temperature: 3-axis, proportional 70 x 150 x 40 mm or 2.75 x 5.91 x 1.57” ca. 150 gr or 5.29 oz 433.081MHz to 434.757MHz 50 metres or 165 feet ABS & rubber - according to IP67 specifications Lasts up to at least 15 10min docking manoeuvres 350 mAh Li-ion Qi-certified wireless charging 0°C to +43°C or +32°F to +110°F Receiver Dimensions Rev.G: Weight Rev.
14 10. Environmental Information The equipment that you have bought requires the extraction and use of natural sources for its production. It may contain substances that are hazardous to health and the environment. In order to avoid the dissemination of those substances in our environment, and to diminish the pressure on natural resources, we encourage you to use the appropriate take-back systems.
15 12. Warranty Each DOCKMATE has a 3-year warranty from the date of registration by the first owner. The warranty covers all defects and failures that are not caused by the customer. The manufacturer will repair or replace your product free of charge on the following conditions: - The warranty is not valid in case of improper installation or improper use of the device. Products must have been used strictly in accordance with operating instructions supplied.
16 This manual may in no way be reproduced, complete or partial, without the written permission of PPA-Electronics. Dockmate is a registered trademark from PPA-Electronics B.V. Leuvensesteenweg 177 – BE-3191 Boortmeerbeek – Belgium VAT BE 0891.773.260 – Tel. +32 (0)15 43 39 94 – Mob. +32 (0)475 45 37 35 info@dockmate.eu – www.dockmate.eu – info@ppa-electronics.com – www.ppa-electronics.