INSTRUCTION MANUAL DWV902M-XE HEAVY-DUTY DUST EXTRACTOR VACUUM
Power connection data of power tool Hose length Hose diameter Weight Definitions: Safety Guidelines The definitions below describe the level of severity for each signal word. Please read the manual and pay attention to these symbols. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING: Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.
• Use this appliance ONLY as described in the manual. Use only DEWALT recommended attachments. • Do not use this appliance with a damaged cord or plug. If the appliance is not working correctly, or if it has been dropped, damaged, left outdoors, or dropped in water, return it to a service center. • Do not pull or carry this appliance by the cord, use the cord as a handle, close a door on the cord, or pull the cord around sharp edges or corners. Do not run the appliance over the cord.
Extension Cords R FIG. 1 CAUTION: Use only extension cords that are approved by the country’s Electrical Authority. Before using extension cords, inspect them for loose or exposed wires, damaged insulation and defective fittings. Replace the cord if necessary. K A Additional Safety Warnings • Do not pick up anything that is burning or smoking, such as cigarettes, matches, or hot ashes.
COMPONENTS (Fig. 1) DO NOT use the dust extractor for combustible dust. DO NOT use the dust extractor in explosive atmospheres. NOTE: This appliance is suited for the commercial use, e.g. in hotels, schools, hospitals, factories, shops, offices, rental companies, and on construction sites. WARNING: Never modify the power tool or any part of it. Damage or personal injury could result. A. Top handle/cord wrap K. Hose clip B. Power cord L. Front handle C. Vacuum head M. Outlet for power tools D.
OPERATION NOTE: The vacuum cleaner starts automatically within 0.5 seconds and continues to run for 15 seconds after the power tool has been turned off. 4. To switch back to manual mode, turn the on/off/tool control switch (O) to the ON position ( ). In manual mode the tool and the vacuum are turned on and off independent of each other.
AUTOMATIC FILTER CLEANING SYSTEM This vacuum has a highly effective filter cleaning system which minimizes filter clogging. Every 30 seconds, one of the two filters gets automatically cleaned. The cleaning process alternates between the filters and continues through the life of the unit. NOTE: It is normal to hear a clicking sound during this process. NOTE: After many hours of operation the automatic filter cleaning system may not be effective.
TELESCOPING HANDLE (FIG. 1, 8) Press release button (Q) to raise and lower the telescoping handle (R). as contaminated when removed from the hazardous area and appropriate action taken to prevent dust dispersal. • For dust extractors it is necessary to provide for an adequate air change rate L in the room if the exhaust air is returned to the room. (NOTE: Reference to National Regulations is necessary.) FIG. 8 To Shut Down/Transportation (Fig. 1, 11) 1.
Storage (Fig. 11) 5. Inspect filters for wear, tears or other damage. NOTE: If there is any doubt on the condition of the filters they MUST be replaced. DO NOT continue use if filters are damaged. 6. If no damage to filters: Wash filters in low pressure, room temperature water and allowed to dry. Filters may be reinstalled after they are completely dry, refer to To Install Filters. To Install Filters 1. Ensure filter seal (Z) is in place and is secure FIG. 10 Z 1.
OPTIONAL ACCESSORIES DWV9310-XJ HE Filter: Captures 99.0% of all particles greater or equal to 0.3 microns. DWE46100 127–152 mm (5"–6") Cutting/tuckpointing shroud DWE46150 127 mm (5") Cutting/tuckpointing shroud DWV9316-XJ Anti-static 4.6 m (15') hose DWV9315-XJ Crush proof 4.6 m (15') hose The filter bags provide a clean, easy and quick way to dispose of the dust collected. Paper filter bags: The DWV9401 filter bags are designed to capture many types of dust including drywall, concrete and wood.
PROBLEM D279059B Dust comes out while vacuuming Dust extraction beater bar kit SOLUTION Check for proper installation of the filters. Ensure filters are not damaged; replace if necessary. Ensure filter seals are in place and are secure. Automatic filter cleaning is not working Power tool does not turn on. TROUBLESHOOTING PROBLEM Motor does not run SOLUTION Check power cord, plugs and outlet. Ensure the on/off /tool control switch is in the ON position ( ).
Stanley Black & Decker 82 Taryn Drive, Epping, VIC 3076 Australia • 1800 444 224 (Aust) or 0800 339 258 (NZ) www.dewalt.com.au • www.dewalt.co.nz (DEC12) Part No. N246440 DWV902M-XE Copyright © 2012 DEWALT The following are trademarks for one or more DEWALT power tools: the yellow and black color scheme; the “D” shaped air intake grill; the array of pyramids on the handgrip; the kit box configuration; and the array of lozenge-shaped humps on the surface of the tool.