Ovens FL-2270 Rev. 10 (4/08) Page 1 of 13 5925 Heisley Road • Mentor, OH 44060-1833 INSTALLATION, OPERATION and MAINTENANCE MANUAL for Cres Cor AQUATEMP HUMIDITY CONVECTION and RETHERM OVENS CO151FUA12B CO151FWUA12B CO151FW1818B CO151FPWUA12B RO151FWUA18B CO151HUA6B CO151HWUA6B CO151HW189B CO151XWUA5B CO151XW185B Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.
Ovens FL-2270 Rev. 10 (4/08) Page 2 of 13 5925 Heisley Road • Mentor, OH 44060-1833 TABLE OF CONTENTS SUBJECT PAGE INSTALLATION INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 OPERATING INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4, 5 Illustration, Figure 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ovens FL-2270 Rev. 10 (4/08) Page 3 of 13 5925 Heisley Road • Mentor, OH 44060-1833 INSTALLATION INSTRUCTIONS VENTING YOUR OVEN: 1. The purpose of ventilating hoods is to direct and capture smoke, grease-laden vapors, heat, odors, or fumes. 2. Low temperature equipment (maximum temperature 250°F/121°C) does not produce heat, odors, fumes, grease-laden vapors or smoke and is not required to be vented. 3.
Ovens FL-2270 Rev.
Ovens FL-2270 Rev. 10 (4/08) Page 5 of 13 5925 Heisley Road • Mentor, OH 44060-1833 OPERATING INSTRUCTIONS (continued) HOW TO START UNIT HOW TO COOK, continued 3. Set Humidity control to the desired relative humidity you need in the oven. This setting is for both COOK and HOLD cycles. 4. Set Timer for the cooking time. Press timer start button. The oven will automatically switch to the preset hold temperature after cooking time has expired. (After first-time operation): Push POWER switch “ON”.
Ovens FL-2270 Rev. 10 (4/08) Page 6 of 13 5925 Heisley Road • Mentor, OH 44060-1833 OPERATING INSTRUCTIONS (continued) MAINTENANCE: WATER PAN MAINTENANCE: CABINET Drain, wipe and fill water pan daily. (Clear vinyl drainhose is provided). 1. Wipe the inside of cabinet after daily use. 2. Leave doors slightly open to fully dry interior. 1. Push hose into drain nozzle under the base. 2. Turn knob to open the drain. WARNING To Fully Dry Out: BEFORE cleaning the cabinet: 1.
Ovens FL-2270 Rev. 10 (4/08) Page 7 of 13 5925 Heisley Road • Mentor, OH 44060-1833 MAINTENANCE INSTRUCTIONS: TROUBLE-SHOOTING GUIDE WARNING IF UNIT GETS TOO HOT OR WON’T SHUT OFF, DISCONNECT POWER AT BRANCH PANEL. DO NOT UNPLUG CORD! If hot unit is NOT working, first check the following causes: 1. Cord is unplugged from wall outlet. 3. Switch is turned off. 2. Circuit breaker/fuse to wall outlet is blown. 4. Thermostat is turned off, or is set too low.
Ovens FL-2270 Rev. 10 (4/08) Page 8 of 13 5925 Heisley Road • Mentor, OH 44060-1833 MAINTENANCE INSTRUCTIONS TROUBLE-SHOOTING GUIDE, continued HOW TO ADJUST THE DOOR LATCH: 1. For vertical (up and down movement) adjustment: a. Loosen (2) screws located in magnetic strike. b. Move strike up or down for alignment to magnet on latch. c. Tighten screws to secure 2. For horizontal (greater or lesser magnetic draw) adjustment: a. Loosen (4) screws in door latch. b.
Ovens FL-2270 Rev.
Ovens FL-2270 Rev. 10 (4/08) Page 10 of 13 5925 Heisley Road • Mentor, OH 44060-1833 REPLACEMENT PARTS for OVENS CO or RO 151FW SERIES: Include all information on nameplate when ordering parts 16 15 18 17 19 14 13 29 21 27 20 12 22 25 FIGURE 4; Hot Unit w/o Top cover (For parts description, refer to page 9.) 26 26 28 FIGURE 5; Bottom of Hot Unit, Cover Removed (For parts description, refer to page 9.) Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.
Ovens FL-2270 Rev. 10 (4/08) Page 11 of 13 5925 Heisley Road • Mentor, OH 44060-1833 REPLACEMENT PARTS for “PASS-THRU” OVENS CO or RO 151FW SERIES: Include all information on nameplate when ordering parts 16 22 29 27 21 20 12 13 14 15 18 22 19 17 FIGURE 4; Hot Unit w/o Top cover (For parts description, refer to page 9.) 26 26 28 FIGURE 5; Bottom of Hot Unit, Cover Removed (For parts description, refer to page 9.) Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.
Ovens FL-2270 Rev.
Ovens FL-2270 Rev.