SEARS operator's manual MODEL NO. 143.004010 4.0 HORSEPOWER 10 CUBIC INCH (163 cc) DISPLACEMENT SOLID STATE IGNITION ENGIN CAUTION: • Operating Read RULES for Safe OPERATION and INSTRUCTIONS Carefully _ • Maintenance • Repair Parts WARNING: to cause cancer, alifornia Proposition 65 known to the State of California The engine exhaust from this product contains birth defects or other reproductive harm. chemicals Sold by SEARS, ROEBUCK AND CO., CHICAGO, IL 60684 U.S.A. and SEARS CANADA, INC.
OIL FILL PLUG AND DIPSTICK o @_ STARTER RECOIL MODEL AND D.O.M. DECAL COOLING FINS OIL DRAIN PLUG SPARK PLUG WIRE CLEANEF \ CONTROL LEVER BOTTOM OF ENGINE CARBUERTOR SPARK PLUG _MUFFLER Figure 1 THIS SYMBOL POINTS OUT IMPORTANT SAFETY INSTRUCTIONS WHICH IF NOT FOLLOWED COULD ENDANGER THE PERSONAL SAFETY ANDIOR PROPERTY OF YOURSELF AND OTHERS.
BEFORE STARTING (Continued) C. Slide rope stop onto starter rope and feed starter rope through rope guide on mower handte (see Figure 4). D. Feed starter rope through starter handle (see Figure 5) and tie a left hand knot, leaving 1/2 inch to 1 inch of starter rope extending beyond left hand knot. DO NOT PULL LEFT HAND KNOT INTO STARTER HANDLE YET. E, With starter handle resting on rope guide (see Figure 4), check starter rope for slack.
STARTING ,_k _k MAINTENANCE NEVER RUN ENGINE INDOORS OR IN ENCLOSED, POORLY] VENTILATED AREAS. ENGINE EXHAUST CONTAINS / CARBON MONOXIDE, AN ODORLESS AND DEADLY GAS/ (CARBON MONOXIDE IS ALSO PRESENT IN ENGINE_ EXHAUST FROM LIQUID PETROLEUM (LPG) AND NATURAL / GAS FUEL SYSTEMS). i_ WARNING -- EXCEED TEMPERATURE OF MUFFLER AND NEARBY AREAS MAY 150°F (65°C). AVOID THESE AREAS. CHECK Check oil level every five (5) operating hours or each time engine is used.
MAINTENANCE (_ SPARK STORAGE (Continued) PLUG (see Figure 8): ._ NEVER STORE ENGINE WITH FUEL IN TANK INDOORS OR IN ENCLOSED, POORLY VENTILATED AREAS, WHERE FUEL FUMES MAY REACH AN OPEN FLAME, SPARK OR PILOT LIGHT AS ON A FURNACE, WATER HEATER, CLOTHES DRYER OR OTHER GAS APPLIANCE. This spark ignition system meets all requirements of the Canadian Interference-Causing Equipment Regulations.
TROUBLESHOOTING THE FOLLOWING MAY HELP AVOID A DELAY IN YOUR WORK SAVE THE EXPENSE OF A SERVICE CALL. OR ENGINE FALLS TO START OR STARTS WITH DIFFICULTY CAUSE Controls not in start position. Spark plug wife disconnected REMEDY Move ENGINE CONTROL or equipment control to "HI" or START postion. See "STARTING" instructions in this manual. from spark plug. Connect SPARK PLUG WIRE to SPARK PLUG. Spark plug fouled. Remove SPARK PLUG and clean it.
SEARS, ROEBUCK AND CO. Federal and California Emission Control Systems Limited Warranty Small Off-Road Engines CALIFORNIA & US EPA EMISSION CONTROL WARRANTY STATEMENT B. GENERAL EMISSIONS WARRANTY COVERAGE: Sears, Roebuck and Co. warrants to the original, end-use purchaser of the new engine or equipment and to each subsequent purchaser that each of its small off-road engines is: The U. S.
CRAFTSMAN 4-CYCLE ENGINE MODEL:143.004010 _--370K /287 298 go0 370C 262/_ /93 _/g2 _285 400 _'292 290 135 _292 130 101 126 275A 416 120 119 125 "284 / 284A 370B_.
CRAFTSMAN Ref. No. Part No.
CRAFTSMAN Ref, No. Pa_ No. 370 370A 370B 370C 370K 370R 380 390 37269 36261 35167 37318 36695 37317 640262 590737 400 37029A CARBURETOR 4-CYCLE ENGINE Ref. No. Part Name 4.0 H.E Craftsman Lubrication Decal Control Decal Primer Decal Starter Decal MODEL:143.004010 Decal Warning Decal Carburetor (Incl. 184) Rewind Starter (NOTE: This engine could have been built with 590694 starter). Gasket Set (Incl. Items Marked *) Part No. 416 36085 417 900 650821 900 Part Name Spark Arrestor Kit (Incl.
REWIND STARTER NO. 590737 Ref. No. 12 / Part No. 3 6 7 8 11 590737 590740 590616 590617 590618A 590687A 12 590535 13 14 590701 590760 13 m STARTER Part Name Rewind Starter Retainer Starter Dog DogSpring Pultey & Rewind Spring Ass'y Starter Housing Ass'y (40 degree irommet) Starter Rope (Length 98" x 9/64" dia.) Starter Handle Spring Clip I -7 NO. 590694 12 R_.
How to ORDER Repair Parts SEARS operator's manual The Model Number can be found on a decal on the blower housing (See Figure 1). Always mention the Model Number when requesting service or repair parts for your Craftsman Engine. All parts listed herein may be ordered from any SEARS, ROEBUCK AND CO. or SEARS CANADA, INC. retail or catalog store. If the parts you need are not stocked locally, your order will be electronically transmitted to a Sears Repair Parts Distribution Center for expedited handling.