DZ-CR2032.PZ.2020.04.20. 东莞市东赞锂能源科技有限公司 Dongzan Lithium Energy Technology Co.,LTD (DongGuan) 锂-二氧化锰扣式一次电池 Lithium - Manganese dioxide single-use button batteries 产品承认书 Product Commitment Letter 电池型号:CR2032 Battery Model: CR2032 客户确认: Customer confirmation: 日期: Date: 制 作: Product: 审核: Auditor: 制造商:东莞市东赞锂能源科技有限公司 Manufacturer: DongGuan Dongzan Lithium Energy Technology Co.
PC:523943
DZ-CR2032.PZ.2020.04.20. 锂锰扣式电池产品承认书 Lithium Manganese Button Batteries Product Commitment Letter 1.目的Purpose: 1.1对东赞锂能源科技有限公司出品的锂锰电池的产品规格、测试方法进行规范,避免因 测试条件、方法的不同引起偏差。 1.1 To standardize the product specifications and test methods of lithium manganese batteries produced by Dongzan Lithium Energy Technology Co., LTD., to avoid deviation caused by different test conditions and methods. 1.2指导客户正确选择和使用我公司电池。 1.2 To guide customers choose and use our batteries correctly.
贮存条件 Storage condition 标准重量 Standard weight 标准条件下 Under standard conditions g 约3.0 approx. 3.0 标准条件下,单个电池 Under standard conditions, a single cell 注: 1.最大脉冲电流指在23℃环境下,放电深度40%的电池接上负载,15秒后,电池的负载 电压2.0V所对应的最大电流. Remark: 1. The maximum surge current refers to the maximum current corresponding to the load voltage of 2.0V of the battery after 15 seconds when the battery with 40% discharge depth is connected to the load at 23℃. 2. 最大连续放电电流在23℃的环境下,将电池用恒定电流持续放电至2.0V,获得标称 容量的50%所对应的最大放电电流. 2.
DZ-CR2032.PZ.2020.04.20. 3、试验方法及检验标准 Test methods and inspection standards 检验项目 Inspection items 测试方法 检验标准 Inspection standards Test methods 用精确度不低于0.02㎜,精密度应不低 直径(Dia):20.0(+0.00 -0.20)mm 于最后一位有效数值的50%,的游标卡 尺或厚度尺测量,测试时应防止电池短 路 外形尺寸 With accuracy of not less than 0.02 Physical dimension mm, precision should not be less than 高度(H): 3.2(+0.02-0.15)mm 50% of the last effective value of the vernier caliper or thickness ruler measurement, test should prevent short circuit of the battery. 测量仪表的精确度不低于0.
value is less than 0.5%; 2、放电应在电池生产后24小时30天内进行;Discharge should be 放电容量 carried out within 24 hours to 30 days Discharge capacity after battery production; 210±3%(mAh) 3、负载15KΩ电阻连续放电至终止电压2 .0V时的放电容量 Loading 15KΩ electric resistance continuous when discharge capacity to termination voltage 2.0V。 高温耐漏液 在60℃的条件下贮存30天 High temperature leakage resistance Store at 60℃ condition for 30 days 无漏液No leakage 在电池终止电压达到2.
DZ-CR2032.PZ.2020.04.20. 4.包装(工业包装)Packing(industrial packing) 每盘数量pcs per tray 25 每包数量pcs per tray 300 每箱数量pcs per tray 6000 纸箱外形尺寸 master carton dimension: mm 包装箱毛重 Gross weight per carton:kg 净重 Net weight per carton: kg 277*277*250 19.6 18.1 5.环保要求 Environmental requirements 本产品不含一级环境管理物质 This product does not contain Class I environmental management substances 6.
.储存 Storage 8.1电池应保存在10℃~25℃(不可超过30℃)、湿度45%~75%的环境中; 8.1 Keep batteries in an environment of 10℃ to 25℃ (not more than 30℃) and humidity during 45% to 75% . 8.2电池储存时要远离热源,也不能置于阳光直射的地方,保证清洁、凉爽、 干燥、通风,并不受气候影响; 8.2 Batteries should be stored away from heat sources or in direct sunlight, to ensure that they are clean, cool, dry, ventilated and not affected by climate. 8.3电池的堆放高度取决于包装强度,一般规定,纸质包装箱堆放高度不得 超过1.5米,木箱不超过3米; 8.
DZ-CR2032.PZ.2020.04.20. 9、注意事项 Notes !危险 Dangerous ! 9.1 不要把电池加热或投进火中; 9.1 Do not heat the battery or put it on fire. 9.2 不要把电池投入水中,也不要置于潮湿的环境中; 9.2 Do not put the battery in water or put it in a humid environment. 9.3不要把电池同项链、发夹、硬币或螺丝等金属品一起放在兜中或包中,也不要 把电池同上述物品一起储存; 9.3 Do not carry batteries in a pocket or bag with metal items such as necklaces, hairpins, coins or screws, and do not store batteries with these items. 9.4不要使用金属导体短路电池的正负极; 9.
9.12在使用或储存期间如发现电池有发热、散发气味、变色、变形或其他异常之处 停止使用; 9.12 During use or storage, if the battery is found to have heat, odor, discoloration, deformation or other abnormalities, stop use it. 9.13不要对电池充电;Do not charge the battery.
DZ-CR2032.PZ.2020.04.20. 9.14不要使电池强制放电;Do not force the battery to discharge; 9.15如果电解液渗透到你的皮肤或衣服上,立刻用清水清洗; 9.15 If the electrolyte gets on your skin or clothes, wash it off immediately with water. 9.16如果电解液渗出并进入你的眼睛里,不要揉擦你的眼睛,立刻用干净的水清洗 并去医院检查; 9.16 If the electrolyte seeps out and gets into your eyes, do not rub your eyes, wash them immediately with clean water and go to the hospital for examination. !注意 Pay attention 9.17把电池放在小孩触摸不到的地方以免吞食,若不慎误吞,应立即送往医院; 9.
5