User Manual
Edition Notes Edition Notes Trademarks Copyright Notice Manual Usage The AmHaze™ User Manual Rev. 01g covers the description, safety precautions, installation, programming, operation, and maintenance of the AmHaze™. CHAUVET® released this edition of the AmHaze™ User Manual in June 2011. CHAUVET® is a registered trademark of CHAUVET & Sons Inc. (d/b/a CHAUVET® or Chauvet).
Table of Contents Table of Contents 1. Before You Begin ............................................................................................... 1 What is Included ............................................................................................................ 1 Unpacking Instructions ................................................................................................... 1 Typographic Conventions.................................................................................
Table of Contents NOTES -b- AmHaze™ User Manual Rev.
Before You Begin 1. Before You Begin What is Included Unpacking Instructions Typographic Conventions • • • • • One AmHaze™ with flight case One power cord (2 m) One fluid tank (5 liter) One Warranty Card One User Manual Immediately upon receiving this product, carefully unpack it and check the container in which you received it. Make sure that you have received all the parts indicated above and that they are all in good condition.
Before You Begin Safety Notes There is risk of burns or electric shock while operating this product. Please read the following notes carefully before working with this product because they include important safety information about the installation, usage, and maintenance of this product. There are no user serviceable parts inside this product. Any reference to servicing it you may find from now on in this User Manual will only apply to properly CHAUVET® certified technicians.
Introduction 2. Introduction Product Description The AmHaze™ is a professional, water-based, DMX controllable haze machine that provides continuous output with various degrees of density. It consists of a chassis that contains the pump, fan, power supply, DMX connections, and control panel. It comes installed in a stackable flight case that also provides room to keep the fluid tank during operation.
Introduction Product Overview 3- & 5-pin DMX connectors Control Panel (LCD) Control Panel (Buttons) -4- AmHaze™ User Manual Rev.
Setup 3. Setup AC Power This product comes in two models, each with a fixed input voltage power supplies, either 120 V, 60 Hz or 230 V, 50 Hz. Therefore, you have to order the correct model for the line voltage in your area. Make sure that you are connecting this product to the proper voltage, as per the specifications in this guide, the product’s user manual, or on the product’s sticker.
Setup DMX Linking You may link the AmHaze™ to a DMX controller using a standard DMX serial connection. If using other DMX compatible units with this product, it is possible to control them individually with a single DMX controller. If you are not familiar with the DMX standard, or if you need information about the DMX cables needed to link this product to a DMX controller, you may download the “DMX Primer” document from the CHAUVET® Web site.
Operation 4. Operation Preparation Once installed, you have to prepare the AmHaze™ for operation. To do so, follow these steps: 1) Open both ends of the flight case. 2) Pull the fluid tank out of its location. 3) Remove the cap of the fluid tank. 4) Verify that the two plastic hoses attached to the cap are in place and in good condition. 5) Pour Chauvet haze fluid inside the tank. 6) Replace the cap of the fluid tank making sure that is tightly closed 7) Reinsert the tank in its location.
Operation Startup The AmHaze™ does not have an On/Off switch. As soon as you connect the AmHaze™ to the power outlet, it will start operating. To start up the AmHaze™, do the following: 1) Insert the Neutrik® powerCON® A connector of the power input cord into the lockable (blue) socket on the back of the AmHaze™. 2) Turn the connector right until it locks in position. 3) Plug the power input cords to a suitable power outlet (the display will show “Warming Up”).
Operation Programming Timer Mode Parameters Continuous Mode Parameters The Programming mode allows you to change the options that affect the various operating modes as well as setting the DMX address. These parameters determine the on and off intervals as well as the output volume when the AmHaze™ is in Timer mode. To configure these parameters do the following: 1) Press repeatedly until TIME BETWEEN shows on the display. 2) Use or to set the time off timer (1~200 s).
Technical Information 5. Technical Information Hazer Maintenance Do not allow the hazer to become contaminated. After 40 hours of continuous operation, it is recommended to run a cleaning solution composed of 80% distilled water and 20% distilled vinegar through the system to prevent the accumulation of particulate matter in the heating element. The recommended cleaning routine is as follows: 1) Empty all fog liquid from the machine. 2) Add cleaning solution to tank.
Technical Information Troubleshooting Guide Symptom Unit powers up but it generates no haze Haze comes out but it is too thick/thin Circuit breaker/fuse keeps tripping/blowing Unit does not power up Unit does not respond to wired DMX or responds erratically Cause(s) Hazer is still cold Wrong fluid Lack of fluid Faulty pump Erroneous haze volume adjustment Wrong fluid Faulty pump Excessive circuit load Short circuit along the power wires No power Loose or damaged power cord Built-in breaker tripped Fault
Technical Information Returns Procedure The user must send the merchandise prepaid, in the original box, and with its original packing and accessories. CHAUVET® will not issue call tags. Call CHAUVET® and request a Return Merchandise Authorization (RMA) number before shipping the unit. Be prepared to provide the model number, serial number, and a brief description of the cause for the return. The user must clearly label the package with a Return Merchandise Authorization (RMA) number.
Technical Information Technical Specifications Dimensions and Weight Length 24 in (610 mm) Width 20.9 in (530mm) Height 7.8 in (199 mm) Weight 46.3 lbs (21 kg) Note: Dimensions in inches rounded to the nearest decimal digit. Electrical Haze Production Thermal DMX Ordering AmHaze™ User Manual Rev.
Technical Information CHAUVET® 5200 NW 108th Avenue Sunrise, FL 33351 (USA) (800) 762-1084 – (954) 929-1115 FAX (954) 929-5560 www.chauvetlighting.com AmHaze™ User Manual Rev.