Instructions / Assembly

ManualsBrandsCamp Chef ManualsAccessoriesTriton 5 l Portable Water Heater

OUTDOOR LP HOT WATER HEATER CARE, USE AND

SAFETY INSTRUCTIONS

• To the installer or person assembling this appliance: Leave this manual

with this appliance for future reference.

• To consumer: Keep this manual for future reference. This instruction

manual contains important information necessary for the proper

assembly and safe use of this product.

Read and follow all warnings and instructions before assembling and using

the appliance.

Follow all warnings and instructions when using the appliance.

DO NOT DISCARD THIS INSTRUCTION MANUAL.

For outdoor use only.

This product contains chemicals known

to the State of California to cause cancer,

birth defects, or other reproductive harm.

CALIFORNIA PROPOSITION 65 WARNING

If the outside temperature is

near or below freezing 32F (0C)

ensure that the system is properly

drained. See instructions inside.

FREEZE WARNING

Use two wrenches when

connecting the gas regulator

hose to the appliance or damage

to the gas valve may occur.

WARNING

3985 N. 75 W. • Logan, UT 84321 • 1.800.650.2433 • www.campchef.com

Model HWD5

0711-HWD5-INSTRUCTIONS

Summary of content (12 pages)

PAGE 1
OUTDOOR LP HOT WATER HEATER CARE, USE AND SAFETY INSTRUCTIONS Model HWD5 • To the installer or person assembling this appliance: Leave this manual with this appliance for future reference. • To consumer: Keep this manual for future reference. This instruction manual contains important information necessary for the proper assembly and safe use of this product. Read and follow all warnings and instructions before assembling and using the appliance.
PAGE 2
DANGER Install and properly vent the water heater. Failure to properly install the water heater in this manual can result in unsafe operation of the water heater. To avoid the risk of fire, explosion, or asphyxiation from carbon monoxide, never operate this water heater unless it is installed properly and has an adequate air supply for proper operation. Be sure to inspect the flue terminal for proper installation at initial start-up; and at least annually thereafter.
PAGE 3
Stay clear from flames. 12. T his product is not intended for commercial use. 13. Should overheating occur or the gas supply fails to shut off turn off the gas supply at the tank. 14. D o not obstruct flow of combustion and ventilation to or from the appliance. 15. T his appliance will be hot during and after use. Use insulated oven mitts or gloves for protection from hot surfaces. 16. A lways allow the appliance to cool before covering. 17. A lways cover the appliance when not in use.
PAGE 4
LP TANK REMOVAL, TRANSPORT AND STORAGE • Turn OFF all LP tank valve. Turn coupling nut counterclockwise by hand only – do not use tools to disconnect. Install safety cap onto LP tank valve. Always use cap and strap supplied with valve. Failure to use safety cap as directed may result in serious personal injury and/or property damage. • A disconnected LP tank in storage or being transported must have a safety cap installed (as shown).
PAGE 5
overfill. Immediately close LP tank valve and call local LP gas dealer for assistance. • Do not release liquid propane (LP) gas into the atmosphere. This is a hazardous practice. • To remove gas from LP tank, contact an LP dealer or call a local fire department for assistance. Check the telephone directory under “Gas companies” for nearest certified LP dealers. LP TANK EXCHANGE • Many retailers that sell appliances offer you the option of replacing your empty LP tanks through an exchange service.
PAGE 6
shown and install the connector fitting to one end of the stand. B. C onnect the two sides of the stand together as shown. C. I nsert the two ends of the wires into the brackets on the back of the appliance as shown. D. Insert the tension strap through the bottom bracket of the appliance and pull tight. the bottom of the appliance labeled water output. Hand tighten only. Attach the garden hose to this RUBBER GASKET connection. Make sure the garden hose has a rubber gasket inserted in the connector.
PAGE 7
the end of the hose. • Use two adjustable wrenches or 3/4” and 7/8” wrenches for tightening the hose to the brass valve of the appliance. WARNING Attempting to tighten the hose fitting to the appliance without using a wrench on the brass adapter fitting on the bottom of the appliance could damage the product and cause a gas leak. Two wrenches must be used to avoid putting too much torque on the appliance. Damage may occur to the unit if tightened improperly.
PAGE 8
proceeding. 4. B rush soapy solution onto indicated connections shown at right. 5. I f “growing bubbles appear, there is a leak. Close LP tank valve immediately and retighten connections. If leaks cannot be stopped, do not try to repair. Call for replacement parts. Order new parts by giving the serial number, model number and name of the items needed to the Service Center 1.435.752.3922. 6. A lways close LP tank valve after performing tank leak test by turning hand wheel clockwise.
PAGE 9
Adjust the temperature of the water by first increasing the heat valve. If a hotter temperature is desired decrease the water flow by adjusting the water valve. WARNING The temperature of the water is dependent on the incoming water temperature and flow and the amount of heat. Use extreme caution when adjusting the water and heat settings. There is a potential scalding hazard! CLEANING AND MAINTENANCE Correct care and maintenance will keep your appliance operating smoothly.
PAGE 10
the front cover. This is the only screw you need to remove. All of the wiring is done with push together plastic connectors. Make sure that the wire terminals are connected to the top of the battery compartment and all other wires are connected. (Call Technical Support at 1.800.650.2433) 6. D ebris may have entered into the water regulator. Reverse the flow of water by connecting the water source to the outlet of the water heater and run water in reverse through the system.
PAGE 11
LIMITED WARRANTY The manufacturer warrants heater components (except paint and finish) to be free from defect in materials and workmanship for 1 year from the date of purchase. All accessories (included with shower or purchased separately) are warranted from defect in materials and workmanship for 90 days from the original purchasing date. Within these periods, the manufacturer will replace or repair defective parts deemed unusable from its original intent by making available the parts thereof FOB 3985 N.
PAGE 12
THE TRITON PORTABLE GAS POWERED WATER HEATER HEATS WATER IN SECONDS AUTOMATICALLY IGNITES WHEN WATER IS TURNED ON • Easy turn brass garden hose connector • Fully adjustable heat and water flow • 4 settings shower head: off, mist, shower, and jet. • Includes regulator hose for bulk propane tank • Includes 8 feet/96” shower hose • Carry handle folds down for storage • Comes with garden hose adapter • 1.5 gallons a min.