AXA10D AXA20 AXA40D AXA SERIES INSTALLATION / OWNER'S MANUAL Mobile Power Amplifiers
INSTALLATION Preparation Please read entire manual before installation. Due to the technical nature of amplifiers, it is highly recommended that your Axxera amplifier is installed by a professional installer or an authorized dealer. Before You Start • Disconnect negative battery terminal.
INSTALLATION Connection Descriptions NOTE: Be sure to follow specific instructions included with your amplifier installation kit (not included with this amplifier). The information below should be used as a general guideline only. Power Wire (+12V) • Disconnect negative battery terminal before proceeding. Consult a qualified technician for instructions if you are unsure. • Plan wire routing before cutting any wires to length.
INSTALLATION Audio Inputs and Controls AXA10D 1 10 1 2 2 3 4 9 3 6 5 7 5 11 6 8 AXA20 AXA40D 3 4 8 1 9 2 2 9 1 8 3 1 High Level Inputs 7 Remote Bass Control Input 2 RCA Line Inputs 8 Crossover Mode 3 Gain 9 Crossover Frequency Control 4 Subsonic Filter 10 Pass Through 5 Bass Boost 11 Power and Protection LEDs 6 Low Pass Filter
INSTALLATION Power and Speaker Connections AXA10D 1 2 3 1 4 2 5 4 3 5 AXA20 AXA40D 1 4 6 5 3 2 1 Speaker Connections 4 Remote Turn On 2 Fuse(s) 5 Ground Connection 3 +12VDC Battery Connection 6 Remote Turn On Output 5
INSTALLATION Typical Wire Routing MAXIMUM GROUND FUSE 12V BATTERY 12V DC (Power) RCA CABLES SPEAKERS REM (Remote Turn On) Main Power Connections Connect +12V, GND and REM wires accordingly. A suitable fuse MUST be installed on the +12V lead within 18" of the battery for protection of the vehicle’s electrical system. 6 Fuse Rating Power/Ground Wire Size When replacing fuses, make sure new fuse is the correct type and amperage. Using an incorrect fuse could damage the amplifier.
INSTALLATION Amplifier Connections Speaker Connections 2 Speakers (stereo) Subwoofer (mono) Typical Stereo Wiring Typical Bridged Wiring Connect speaker wires observing polarity. The minimum impedance load for the AXA20 and AXA40D is 2 ohms stereo and 4 ohms bridged. Use of loads lower than these is not recommended and may cause amplifier damage. The AXA20 and AXA40D can be wired for stereo, bridged or stereo/ bridged simultaneous operation.
OPERATION Configuration/Setup Input level Control Crossover Mode The input level control (gain) is used to obtain the best possible match between the head unit audio output and the amplifier input. Begin by turning the input level control fully counterclockwise. Next, turn up the head unit volume control around 3/4 of the way up. Adjust the input level control clockwise until audible distortion is heard, then slightly counterclockwise to provide the best match. Repeat for all input level controls.
OPERATION Troubleshooting Problem Unit will not turn on (no power LED indicator) Cause GND wire not connected Fuse(s) blown Speaker wires not connected Volume turned all the way down One or more speaker wires touching each Unit has power - LED is other or touching chassis ground green (but no sound) Speaker(s) defective or damaged Input signal not connected Unit blows fuse(s) Incorrect fuse rating +12V wire touching chassis ground Speaker(s) defective or damaged Bad ground connection Engine noise Sig
OPERATION Specifications CEA-2006 Power Standard Specifications (reference: 14.4VDC, 20Hz~20kHz) AXA10D Power Output (14.4VDC, 20Hz ~ 20kHz): 350 Watts x 1 channel @ 4 ohms and ≤ 1% THD+N 650 Watts x 1 channel @ 2 ohms and ≤ 1% THD+N Peak Music Power Output: 1750 Watts Signal to noise ratio: 70dBA (reference: 1 watt into 4 ohms) Frequency response: 20Hz - 150Hz Amplifier dimensions: 1.58" x 4.7" x 9" CEA-2006 Power Standard Specifications (reference: 14.4VDC, 20Hz~20kHz) AXA20 Power Output (14.
WARRANTY Limited One-Year Warranty This warranty gives you specific legal rights. You may also have other rights which vary from state to state. Dual Electronics Corp. warrants this product to the original purchaser to be free from defects in material and workmanship for a period of one year from the date of the original purchase. Dual Electronics Corp.
Dual Electronics Corp. Toll Free: 1-866-382-5476 www.axxeraaudio.com ©2013 Dual Electronics Corp.