Installation Manual Model #’s: MCD-102-CH (-x) MCD-102-RU (-x) MCD-103-CH (-x) MCD-102-CP-x MCD-104-01-x 10 Disc CD Player/Changer Document #540031 7300 Industry Drive, North Little Rock, AR 72117 Phone: 501-955-2929 Fax: 501-955-2988 www.audiointl.
MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Audio International, Inc. Document Revision History Rev.
MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Audio International, Inc. Table of Contents Section Description 1.0 Page 1.1 1.2 1.3 1.4 General Information ……………………………………………. Introduction ……………………………………………………….. Purpose of the Equipment ………………………………………. Operational Features …………………………………………….. Optional Equipment ……………………………………………… 4 4 4 5 5 2.1 2.2 2.3 Application ……………………………………………………….. Introduction ………………………………………………………..
MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Audio International, Inc. MODEL #’s: MCD-102-CH (-x) MCD-102-RU (-x) MCD-103-RU (-x) MCD-102-CP (-x) MCD-104-01-x 10 Disc CD Player/Changer 1.0 General Information 1.1 Introduction This manual contains information for the installation of Audio International, Inc.
Audio International, Inc. 1.3 MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Operational Features Listed below are key features of the MCD units: q q q q q q q q q q q 1.
Audio International, Inc. 3.0 MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Installation 3.1 Prior to Installation Prior to installation, the following items should be considered: 3.1.1 During the design and layout of the aircraft cabin, careful consideration of the location of this module is necessary. Some of the items to be considered include: • Space • Available power supply • Environmental conditions (temperature, humidity, etc.
Audio International, Inc. 3.3 MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Cautions and Warnings 3.3.1 It is important to do a pin-to-pin power and ground check on all connectors. Ensure that power and ground are applied only where specified. Damage to the unit may result if power or ground is applied to the wrong points. 3.3.2 DO NOT connect or disconnect the unit while power is applied. 3.3.3 DO NOT remove any factory-installed screws.
Audio International, Inc. MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual 3.4.4 Data Bus Lines All data bus connections require twisted shielded cable with the cable shields properly grounded. Twisted, shielded cable must be in accordance with MIL-W-27500 or equivalent. The wire size for the conductors in this cable is to be 22 AWG (minimum). The shield is to be connected wherever a shield pin is provided.
MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Audio International, Inc. 3.6.4 The MCD-102-RU remote unit utilizes one 15-pin connector for electrical connections. This connector provides +12 VDC power input, control lines 1 through 4, and audio output. Up to ten 5-inch CD disc may be placed in the magazine. 3.6.5 The MCD-103-CH control head is identical to the MCD-102-Ch control head with an additional pigtail connector.
MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Audio International, Inc. 3.8 Pinout Assignment Descriptions 3.8.
MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Audio International, Inc. 3.8.4 The MCD-102-RU (-x) remote unit pinout is as follows: Pin # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 Description +12 VDC Power Input Ground Input Control 1 Control 2 Control 3 Control 4 Reserved Reserved R+ Audio Output R- Audio Output L+ Audio Output L- Audio Output Reserved Reserved Reserved 3.8.
MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Audio International, Inc. display several different error codes. Refer to Section 4.0 for a definition of these error codes. 4.0 Troubleshooting Guide 4.1 General Troubleshooting Procedures Many problems can be isolated with the following general techniques: • • • 4.2 To verify power to the unit, recheck +28 VDC is applied to the proper pins on the unit. Use a voltmeter to verify correct level.
MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Audio International, Inc. 5.0 Specifications 5.1 Unit Specifications – MCD-102-CH (-x) MCD-102-RU (-x) MCD-103-CH (-x) MCD-104-01-x Physical Specifications Housing Dimensions & Weight MCD-102-CH (-x) & MCD-103-CH (-x) Aluminum Length 7.89” / 20.04cm Width w/bezel 7.38” / 18.75cm Height 2.30” / 5.84cm Weight 2.06 lbs. / 0.93 kg Length 7.30” / 18.54cm Width w/bracket 12.63” / 32.00cm Height 3.60” / 9.
Audio International, Inc. 6.0 MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual Reference Drawings 6.1 The following diagrams show the MCD-102-CH (-x) control head with unit dimensions and attachment points. All dimensions are shown in inches. Document #540031, Rev.
Audio International, Inc. 6.2 MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual The following diagrams show the MCD-102-RU (-x) remote unit with unit dimensions and attachment points. All dimensions are shown in inches. Document #540031, Rev.
Audio International, Inc. 6.3 MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual The following diagrams show the MCD-103-CH (-x) control head unit with unit dimensions. All dimensions are shown in inches. Document #540031, Rev.
Audio International, Inc. 6.4 MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual The following diagrams show the MCD-102-CP (-x) control head unit with unit dimensions. All dimensions are shown in inches. Document #540031, Rev.
Audio International, Inc. 6.5 MCD-102-CH (-x), MCD-102-RU (-x) MCD-103-CH (-x), MCD-102-CP (-x), & MCD-104-01-x Installation Manual The following diagrams show the MCD-104-01-x unit with dimensions. All dimensions are shown in inches. Document #540031, Rev.