FOR TECHNICAL SUPPORT CONTACT: eee ltt ee ease es www.astonbath.
READ THESE WARNINGS BEFORE PROCEEDING IMPORTANT Inspect all glass panels, parts, and hardware for damage prior to installing. Do not proceed if damage is detected. IMPORTANT Glass is very HEAVY. It is recommended that this door be installed by professionals with a minimum of two adults who are experienced in the process. IMPORTANT Glass is manufactured TEMPERED for safety, which causes it to shatter into small but sharp pieces, rather than large dagger like shards that could cause greater damage.
Before You Start Thank you and congratulations on your purchase of a new Shower Door from Aston. We hope it will provide you and your home with years of satisfying functionality, usage and beauty. about how to safely and properly install this unit. If you do not follow these certain conditions for assembly, installation, and maintenance, your warranty may be affected. 1 Please read this manual carefully as it contains information and instructions 1. Inspect boxes for shipping damage.
Detailed Diagram of Shower Door Components Description Qty. Part No. 01 | Glass Door 1 GLSD10* 02 | Handle 1 1210 03 | Wall Anchor 8 1615 Screw 8 1605 05 | Hinge 2 1100 06 | Side Strip Seal (cut to 3 sections) 1 1712 07 | Bottom Anti-water Strip Seal 1 1750 08 | L-Shaped Strip Seal 1 1762 Note: All part numbers marked with are different depending on the width of shower opening, and if the glass is treated with Endure Shield glass protection or frosted.
Assembly and Installation Guide Please read the following assembly and installation instructions and guidelines in this section. Failure to follow the recommended instructions and installation techniques may lead to possible damage to the unit, the surrounding area, or can cause serious personal injury. This can affect warranty claims as well. ATTENTION: This unit requires assembly.
Shower Door Assembly and Installation causes it to shatter into small but sharp pieces, rather than large dagger like WARNING: Could cause SERIOUS INJURY. This glass is TEMPERED which plates that could cause greater damage. glass is the corners. Keep the plastic corner protectors on until the glass is in WARNING: Could cause SERIOUS INJURY. The weakest point on tempered place. Even the slightest bump could cause the glass to shatter.
recommended that this door be installed by professionals with a minimum of WARNING: Could cause SERIOUS INJURY. Glass is very HEAVY. lt is two installers. 2. Place a board thick) on the threshold or the shower base. Remove the corner pads from the Glass Door (01). Place the Glass Door (01) on 1/2" thick board. Carefully position the hinged side of shower door against the wall and * check with level for plumb. NOTE: Please check with a level and be sure that the door is absolutely plumb.
the door is fully mounted. Lifting the door by the handle will cause the door to WARNING: Could cause SERIOUS INJURY. DO NOT install the handle until shatter. 4. Install the Handle (02) to the Glass Door (01) using the hardware provided. See Figure Inside Outside Figure 4 5. Locate the Side Strip Seal (06), measure and cut lengths at and see | 7 e Install the cut Side Strip Seal to the top edge of glass door to the : : edge of the top hinge.
6. Measure the bottom of the Glass Door (01) from the Side Strip Seal (06) to the vertical edge of Glass Door (01). (Handle side of Glass Door) Cut the Bottom Anti-water Strip Seal (07) to the size of your measurement and notch 3%" of the inner side of the Bottom Anti-water Strip Seal (07). See Figure 6 for details. ATTENTION: Prior to next step, please be sure that the section of the wall for installation of the L-Shaped Strip Seal (08) is clean, dry and free from soap, oil and any construction debris. 7.
Care and Maintenance As with any luxury item, maintenance and care are critical to the long-lasting quality and enjoyment of your shower door. The proper care and maintenance outlined in this section are necessary to ensure the longevity of the unit. Damage caused by not following the care and maintenance guidelines in this section is not covered under the manufacturer's warranty.
ASTON GLOBAL INC. — Limited Warranty This warranty applies to products purchased from Aston Global Inc. after May 1, 2017. Aston Global Inc., a Texas Corporation ("Aston"), provides the following warranty coverage for shower doors and enclosures, bathtubs, shower panels and related components (The Products).
PARTS ONLY WARRANTY This warranty is extensive in that it covers replacement of all defects. LABOR CHARGES AND/OR DAMAGE INCURRED DURING INSTALLATION, REPAIR, OR REPLACEMENT, AS WELL AS ANY OTHER KIND OF ANCILLARY COST, LOSS OR DAMAGE ARE EXCLUDED. COMMERCIAL USE AND OTHER EXCLUSIONS This warranty excludes all industrial, commercial and business usage.
THE FOREGOING WARRANTIES ARE IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF MERCHANT ABILITY AND FITNESS FOR A PARTICULAR PURPOSE. ASTON DISCLAIMS ALL LIABILITY FOR SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES.
RESIDENTIAL INSTALLATIONS SHOWER DOORS and ENCLOSURES GLASS: Limited Lifetime Aston warrants the glass of shower doors, tub doors and shower enclosures to be free from defects in workmanship and materials under normal residential use for the life of the product. * Aston does not warrant glass for scratches, chips, water spots, breaking or any other damage during installation or after. Star Cast Protective Coating by Windshield (On Certain Models Only): Ten (10) Years, provided by PCT Global LLC.
HARDWARE: One (1) Year Aston warrants shower door, tub door and shower enclosure hardware (i.e. handles, rollers, hinges, profiles, clips, guides, brackets, towel and support bars) to be free from defects in workmanship and materials under normal commercial use for one (1) year. SHOWER BASES: One (1) Year Aston warrants shower bases to be free from defects in workmanship and materials under normal commercial use for one (1) year.
ANTON ESCAPE THE EVERYDAY Customer Service 877-424-9699 Aston Global Inc 902 Nicholson Rd Suite 100 Garland, TX 75042 If further assistance is needed , or you have a question, please visit our wed site at: www.astonbath.