Owners manual

PARTS LIST:

Qty Description Qty Description

1 Grill Guard 2 12mm Lock Nuts

1 Driver/Left Upper Brace Bracket (Ranger) 4 12mm ID x 35mm OD Flat Washers

1 Passenger/Right Upper Brace Mounting Bracket (Ranger) 2 10mm x 30mm Hex Bolts

1 Driver/Left Upper Brace Bracket (Mazda) 2 10mm Lock Nuts

1 Passenger/Right Upper Brace Bracket (Mazda) 4 10mm ID x 27mm OD Flat Washers

2 12mm x 100mm Hex Bolts

Drive

Left Side

Brace Bracket

Mazda only

PROCEDURE:

1. REMOVE CONTENTS FROM BOX. VERIFY ALL PARTS ARE PRESENT. READ

INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION.

2. From underneath vehicle locate the existing slotted holes in both side of the frame just behind

the bumper, with assistance attach the grill guard to the inner side of frame using the 12mm x

100mm Hex bolts, 12mm flat washers & the 12mm lock nuts (Note; due to variances in

plastic below bumper some models may need trimming or notching of the plastic to

allow for adjustment of grill guard.) Snug hardware, but do not tighten hardware at this time.

3. Locate the factory bolts which are near the top back side of front bumper, these can be

accessed from either reaching through the gap between the bottom of the grill and the top of

bumper or from the underneath, depending on the space available, remove these factory bolts

and attach upper brace brackets for your vehicle type (refer to diagram below for bracket

selection of vehicle type driver & passenger sides) secure these brackets with the factory

bolts. Snug but do not tighten hardware at this time. Secure the other ends of brackets to the

grill guard with the 10mm fasteners, Snug hardware, but do not tighten hardware at this time.

4. Once all hardware is installed align your grill guard to vehicle, and tighten all hardware,

Do periodic inspections to the installation to make sure all hardware is secure and tight.

Page 1 of 2 4/8/2011

INSTALLATION INSTRUCTIONS

1998-2000 Ford Ranger & Mazda B-Series Pickups

Part 3044 / 3044-2

Passenge

Right

Side Brace Bracket

Ranger only