Installation Guide

ManualsBrandsAmerican Standard ManualsBathtub & Shower Parts1.5-in Solid Color Foot Lock Drain with Plastic Pipe

BATH WASTE AND OVERFLOW

WITH TOE TAPPER DRAIN PLUG

Note: THIS DRAIN IS INTENDED FOR USE WITH BATH DRAINS ONLY!

Installation

Instructions

1640.305.XXX

Thank you for selecting American-Standard...the benchmark

of fine quality for over 140 years.

To ensure that your installation proceeds smoothly--please

read these instructions carefully before you begin.

Plumbers' Putty or Caulking Phillips ScrewdriverChannel Locks

DEEP SOAK

BATH DRAIN

ROUGH-IN DIMENSIONS

RECOMMENDED TOOLS

1-1/2" OD

TAILPIECE

*NOTE: A smaller dimension can be accommodated by cutting pipe.

TOE TAPPER

DRAIN PLUG

ADJUSTABLE

SEE TABLE BELOW

ADJUSTABLE

SEE TABLE BELOW

2-13/16" DIA.

754096-100 Rev. 3 (1/20)

Product names listed herein are trademarks of AS America, Inc.

OVERFLOW HEIGHT

MODEL #

1640.305.XXX

*MIN

17"

MAX

19-1/2"

*MIN

6-1/2"

*MAX

DRAIN LENGTH

Summary of content (4 pages)

PAGE 1
Installation Instructions DEEP SOAK® BATH DRAIN 1640.305.XXX BATH WASTE AND OVERFLOW WITH TOE TAPPER DRAIN PLUG Note: THIS DRAIN IS INTENDED FOR USE WITH BATH DRAINS ONLY! Thank you for selecting American-Standard...the benchmark of fine quality for over 140 years. To ensure that your installation proceeds smoothly--please read these instructions carefully before you begin.
PAGE 2
1 INSTALL DRAIN PLUG AND ELL (STANDARD AND OVER-THE-RIM DRAINS) Apply putty to underside of DRAIN PLUG (1) and drop into drain outlet. 1 PUTTY Slip RUBBER WASHER (2) on from below and thread DRAIN PLUG (1) into DRAIN ELL ASSEMBLY (3). 2 NOTE: TUB IS SHOWN CUT AWAY FOR CLARITY OF INSTALLATION. 2 BATH DRAIN OUTLET 3 INSTALL OVERFLOW ASSEMBLY AND DRAIN TEE (STANDARD DRAIN) Loosen SLIP JOINT NUT & SEAL (1) and install onto OVERFLOW TUBE (2).
PAGE 3
4 ABOVE FLOOR OUTLET INSTALLATION (STANDARD DRAIN) Note: Waste outlet can be installed either above the floor or below floor. Fig.1. For above floor drain outlet, Rotate DRAIN TEE ASSEMBLY (1) 90 degrees so TAILPIECE (2) faces out the back from tub as shown. ROUGH FLOOR TUB TUB ABOVE FLOOR ROUGH BELOW FLOOR ROUGH TYPICAL ABOVE FLOOR INSTALLATION 2 1 NOTE: TUB IS SHOWN CUT AWAY FOR CLARITY OF INSTALLATION. CARE INSTRUCTIONS: DO: SIMPLY RINSE THE PRODUCT CLEAN WITH CLEAR WATER.
PAGE 4
DEEP SOAK® BATH DRAIN BATH WASTE AND OVERFLOW WITH TOE TAPPER DRAIN PLUG PRODUCT NUMBER 1640.305.XXX 754129-0070A OVERFLOW HOLD RING REPAIR KIT 754053-YYY0A OVERFLOW CAP REPAIR KIT 754068-0070A OVERFLOW FITTING 753980-YYY0A TOE TAPPER DRAIN 753983-YYY0A DRAIN PLUG 751977-0070A DRAIN PLUG WASHER Replace the "YYY" with appropriate finish code CHROME ARCTIC WHITE LINEN POL.